Gebruiksaanwijzing /service van het product HDVF3018P van de fabrikant Desa
Ga naar pagina of 28
For more information, visit www .desatech.com UNVENTED (VENT -FREE) GAS LOG HEA TER OWNER’S OPERA TION AND INST ALLA TION MANU AL Also Design-Cer tied As V ented Decor a tive Appliances V ARIAbLE.
www .desatech.com 1 19421-01A 2 SAFETy INFORMATION W ARNIN G: Impro per in - stallation, adjustment, al - teration, service or main- tenance can cause in- jury or property damage. Refer to this manual for correct installation and op era tion al pro ced ure s.
www .desatech.com 1 19421-01A 3 WAR NIN G: This pro duc t con - ta ins an d/ or gen era tes ch emi ca ls kno wn to the state o f Calif orni a to cause ca nce r o r bir th def ect s or oth er repr odu cti ve harm .
www .desatech.com 1 19421-01A 4 4. If you smell gas • shut off gas supply • do not try to light any appliance • do not touch any electrica l switch; do not use any phone in your building • immediately call your gas supplier from a neighbor’s phone.
www .desatech.com 1 19421-01A 5 Figure 1 - V ent-Free Gas Log Heater Base Grate Log Set Control Knob Burner Piezo Ignitor PRODUCT IDENTIFICATION PRODUCT FEA TURES OpERA TION This heater is clean burning. It requires no outside venting. There is no heat loss out a vent or up a chimney .
www .desatech.com 1 19421-01A 6 Exhaust fans, replaces, clothes dryers and fuel burni ng applia nces draw ai r f rom the h ouse to operate. Y ou must provide adequate fresh air for these appliances. This will insure proper venting of vented fuel-burning appliances.
www .desatech.com 1 19421-01A 7 Example: Gas water heater ____________ Btu/Hr V ent-free replace + ___________ Btu/Hr T otal = ___________ Btu/Hr 4.
www .desatech.com 1 19421-01A 8 INST ALLA TION NOTICE: This heater is intended for use as supplemental heat. Use this heater along with your primary heating system. Do not install this heater as your pri - mary heat source. If you have a central heatin g system, you may run system’s circulating blower while using log heater .
www .desatech.com 1 19421-01A 9 INST ALLA TION AND CLEARANCES (V ent-Free Operation Only) W ARNING: Maintain the minimum clearances. If you can, provide greater clearances from oor , ceiling and adjoining wall.
www .desatech.com 1 19421-01A 10 If Using Mantel Y ou must have noncombustible material(s) above the replace opening. Noncombustible materials (such as slate, marble, tile, etc.) must be at least 1/2" thick. W ith sheet metal, you must have non - combustible material behind it.
www .desatech.com 1 19421-01A 1 1 NOT ICE: If your instal lat ion does not meet the minimum clear- ances shown, you must do one of the following: • operate the logs only with the ue damper open .
www .desatech.com 1 19421-01A 12 Se e ch art bel ow for min imu m pe rma nen t u e opening you must provide. Attach damper clamp so the minimum permanent ue opening will be maintained at all times. INST ALLA TION Continued INST ALLING HEA TER BASE ASSEMBL Y CAUTIO N: Do not remove the da ta plat es atta ch ed to the hea ter base assembly .
www .desatech.com 1 19421-01A 13 INST ALLA TION Continued Figure 12 - Attaching Base Assembly to Fireplace Floor - Dual Burner Model Masonry Screw Mounting Bracket CONNECTING TO GAS SUppLY WARNING: This appliance requires a 1/2" NPT (National Pipe Thread) inlet connection to the pressure regulator.
www .desatech.com 1 19421-01A 14 Installation must include an equipment shutoff va lv e, unio n an d pl ug ge d 1/8 " NPT tap . Lo ca te NP T tap within rea ch fo r tes t ga uge hook up . NPT tap must be upst ream fro m he ater (se e Fi gure 14) .
www .desatech.com 1 19421-01A 15 INST ALLA TION Continued Test Pressures Equal To or Less Than 1/2 PSIG (3.5 kPa) 1. Cl os e eq ui pm en t sh ut of f va lv e (s ee F ig ur e 15).
www .desatech.com 1 19421-01A 16 INST ALLA TION Continued Figure 19 - Installing Middle Log #2 Figure 20 - Installing Back Log #3 Middle Log (#2) T ab Burner U-Shaped Slot Hole in Grate Base Pins Burner Back Log (#3) Figure 18 - Installing Front Log #1 Front Log (#1) Grate Fingers Grate Base 3.
www .desatech.com 1 19421-01A 17 OPERATING HEATER FOR YOUR SAFETY READ BEFORE LIGHTING WARNING: If you do not fol- low these instructions exactly, a re or explosion may result causing property damage, per - sonal injury or loss of life. A. This appliance has a pilot which must be lighted by hand.
www .desatech.com 1 19421-01A 18 Figure 22 - Control Knob and Ignitor Button Location Ignitor Button Control Knob Figure 23 - Pilot Thermocouple Pilot Burner Ignitor Electrode VARIABLE CONTROL OpERATI.
www .desatech.com 1 19421-01A 19 INSPECTING b URNERS Check pilot ame pattern and burner ame pat - terns often. pILOT FLAME p A TTERN Figure 24 sh ows a cor rec t pil ot a me pa tt ern . Figure 25 sh ow s an in co rr ec t pil ot a me pat te rn .
www .desatech.com 1 19421-01A 20 1. Shut off the unit, including the pilot. Allow the unit to cool for at least thirty minutes. 2. In spec t bu rne r , pi lot and pri mar y ai r in let holes on injector holder for dust and d irt (see Figure 26). 3. Blow air through the ports/slots and holes in the burner .
www .desatech.com 1 19421-01A 21 TROUbLESHOO TING W ARNING: T urn off heater and let cool before servicing. Only a qualied service person should service and repair heater . CAUTION: Never use a wire, needle or similar object to clean ODS/pilot. This can damage ODS/pilot unit.
www .desatech.com 1 19421-01A 22 TROUbLESHOO TING Continued pOSSIBLE CAUSE 1. Burner orice clogged 2. Inlet gas pressure is too low 1. Manifold pressure is too low 2. Burner orice clogged 1. Burner orice is clogged or damaged 2. Damaged burner 3.
www .desatech.com 1 19421-01A 23 TROUbLESHOO TING Continued W ARNING: If you smell gas • Shut off gas supply . • Do not try to light any appliance. • Do not touch any electrical switch; do not use any phone in your building. • Immediately call your gas supplier from a neighbor ’ s phone.
www .desatech.com 1 19421-01A 24 SPECIFICA TIONS MODEL HDVF3018P • Rating: 16,000/30,000 Btu/Hr • Gas T ype: Propane/LP • Ignition: Piezo • Manifold Pressure: 8.0" W .C. • Inlet Gas Pressure (inches of water): • Max. 14", Min.* 11" • Shipping W eight: 25 lbs.
www .desatech.com 1 19421-01A 25 ACCESSORIES Purc hase thes e re plac e acc esso ries from your lo - cal deal er. If they can not supp ly these accesso ries , call DESA Heating Products’ Sales Department at 1-866-672-6040 for referral information.
www .desatech.com 1 19421-01A 26 ILL USTRA TED P ARTS bREAkDOWN V ARIABLE MANUALL Y -CONTROLLED MODELS HDVF3018P AND HDVF3018N 24 21 1 1 12 13 4 6 3 2 21 8 21 7 10 9 16 15 17 19 22 18 14 19 23 20 18 5.
www .desatech.com 1 19421-01A 27 P ARTS LIST This list contains replaceable parts used in your heater. When ordering parts, follow the instructions listed under Replacement Parts on page 24 of this manual.
Model Serial No. Date Purchased WARRANTy INFORMA TION kEEP THIS WARRANTy Always specify model and serial numbers when communicating with the factory . W e reserve the right to amend these specications at any time without notice. The only warranty applicable is our standard written warranty .
Een belangrijk punt na aankoop van elk apparaat Desa HDVF3018P (of zelfs voordat je het koopt) is om de handleiding te lezen. Dit moeten wij doen vanwege een paar simpele redenen:
Als u nog geen Desa HDVF3018P heb gekocht dan nu is een goed moment om kennis te maken met de basisgegevens van het product. Eerst kijk dan naar de eerste pagina\'s van de handleiding, die je hierboven vindt. Je moet daar de belangrijkste technische gegevens Desa HDVF3018P vinden. Op dit manier kan je controleren of het apparaat aan jouw behoeften voldoet. Op de volgende pagina's van de handleiding Desa HDVF3018P leer je over alle kenmerken van het product en krijg je informatie over de werking. De informatie die je over Desa HDVF3018P krijgt, zal je zeker helpen om een besluit over de aankoop te nemen.
In een situatie waarin je al een beziter van Desa HDVF3018P bent, maar toch heb je de instructies niet gelezen, moet je het doen voor de hierboven beschreven redenen. Je zult dan weten of je goed de alle beschikbare functies heb gebruikt, en of je fouten heb gemaakt die het leven van de Desa HDVF3018P kunnen verkorten.
Maar de belangrijkste taak van de handleiding is om de gebruiker bij het oplossen van problemen te helpen met Desa HDVF3018P . Bijna altijd, zal je daar het vinden Troubleshooting met de meest voorkomende storingen en defecten #MANUAl# samen met de instructies over hun opplosinge. Zelfs als je zelf niet kan om het probleem op te lossen, zal de instructie je de weg wijzen naar verdere andere procedure, bijv. door contact met de klantenservice of het dichtstbijzijnde servicecentrum.
