Gebruiksaanwijzing /service van het product RFN30T van de fabrikant Desa
Ga naar pagina of 24
Save this manual for future reference. VENT -FREE NA TURAL GAS RADIANT FLAME ® HEA TER OWNER’S OPERA TION AND INST ALLA TION MANUAL 15,000 to 30,000 Btu/ Hr with Thermostat Shown with Optional Mant.
2 104433 VENT -FREE NA TURAL GAS HEA TER 15,000 TO 30,000 BTU/HR 1. Use only natural gas. Do not convert heater to use different fuel type. 2. If you smell gas • shut off gas supply • do not try to light any appliance • do not touch any electrical switch; do not use any phone in your building.
3 104433 OWNER’S MANUAL ASDFKIGLFJI alskdidkoemkgo dkirlnfgpd'fASDFKIGLFJI alskdidkoemkgo dkirlnfgpd'f ASDFKIGLFJI alskdidkoemkgo dkirlnfgpd'fASDFKIGLFJI alskdidkoemkgo dkirlnfgpd&apo.
4 104433 VENT -FREE NA TURAL GAS HEA TER 15,000 TO 30,000 BTU/HR WARNING: Always have burner shield and screen in place before operating heater. This pre- vents excessive temperatures on heater surfaces.
5 104433 OWNER’S MANUAL ASSEMBL Y Continued Assembling and Attaching Brass Trim 1. Remove packaging from remaining three pieces of brass trim. 2. Locate four brass screws, two adjust- ing plates with set screws, and two shims in the hardware packet.
6 104433 VENT -FREE NA TURAL GAS HEA TER 15,000 TO 30,000 BTU/HR WARNING: If the area in which the heater may be operated is smaller than that defined as an unconfined space or if the building is of unusually tight construction, provide adequate combustion and ventilation air by one of the methods described in the National Fuel Gas Code, ANS Z223.
7 104433 OWNER’S MANUAL Or Remove Door into Adjoining Room, Option 3 Ventilation Grills Into Adjoining Room, Option 2 12" 12" Ventilation Grills into Adjoining Room, Option 1 AIR FOR COMBU.
8 104433 VENT -FREE NA TURAL GAS HEA TER 15,000 TO 30,000 BTU/HR CAUTION: If you install the heater in a home garage • heater pilot and burner must be at least 18 inches above floor.
9 104433 OWNER’S MANUAL INST ALLA TION Continued THERMOSTAT SENSING BULB The thermostat sensing bulb has been placed inside the heater for protection during shipping. Locating Thermostat Sensing Bulb 1. Remove front panel of heater (see Fig- ure 2, page 4).
10 104433 VENT -FREE NA TURAL GAS HEA TER 15,000 TO 30,000 BTU/HR Installing Bottom Mounting Screws 1. Locate two bottom mounting holes. These holes are near bottom on back panel of heater (see Figure 17). 2. Mark screw locations on wall. 3. Remove heater from mounting bracket.
11 104433 OWNER’S MANUAL Securing Hearth Base to Floor 1. Position hearth base in desired location. Mark holes for drilling (see Figure 18). Remove hearth base. 2. For carpeted floor , make a small cut with a sharp knife at marked locations before drilling.
12 104433 VENT -FREE NA TURAL GAS HEA TER 15,000 TO 30,000 BTU/HR Tee Joint Reducer Bushing to 1/8" NPT 1/8" NPT Plug Tap Test Gauge Connection * Tee Joint Pipe Nipple Cap Sediment Trap Pres.
13 104433 OWNER’S MANUAL Pressure Testing Gas Supply Piping System Test Pressures In Excess Of 1/2 PSIG (3.5 kPa) 1. Disconnect appliance with its appliance main gas valve (control valve) and equip- ment shutoff valve from gas supply pip- ing system.
14 104433 VENT -FREE NA TURAL GAS HEA TER 15,000 TO 30,000 BTU/HR TO TURN OFF GAS TO APPLIANCE Shutting Off Heater 1. T urn contr ol knob clockwise Clockwise to the OFF position. 2. T ur n off all electric power to the ap- pliance if service is to be perf ormed.
15 104433 OWNER’S MANUAL Good Pilot-Nat. Port GRH/OV 007D INSPECTING BURNER Check pilot flame pattern and burner flame pattern often. PILOT FLAME PATTERN Figure 25 shows a correct pilot flame pat- tern. Figure 26 shows an incorrect pilot flame pattern.
16 104433 VENT -FREE NA TURAL GAS HEA TER 15,000 TO 30,000 BTU/HR CLEANING AND MAINTENANCE CABINET Air Passageways • Use a vacuum cleaner or pressurized air to clean. Exterior • Use a soft cloth dampened with a mild soap and water mixture. W ipe the cabi- net to remove dust.
17 104433 OWNER’S MANUAL TROUBLESHOOTING OBSERVED PROBLEM When ignitor button is pressed, there is no spark at ODS/pilot When ignitor button is pressed, there is spark at ODS/pilot but no ignition ODS/pilot lights but flame goes out when control knob is released CAUTION : Never use a wire, needle, or similar object to clean ODS/pilot.
18 104433 VENT -FREE NA TURAL GAS HEA TER 15,000 TO 30,000 BTU/HR OBSERVED PROBLEM Burner does not light after ODS/pilot is lit Delayed ignition of burner Burner backfiring during combustion Yellow fl.
19 104433 OWNER’S MANUAL TROUBLESHOOTING Continued OBSERVED PROBLEM Heater produces a clicking/ticking noise just after burner is lit or shut off Heater produces unwanted odors Heater shuts off in use (ODS operates) Gas odor even when control knob is in OFF position Gas odor during combustion Moisture/condensation noticed on windows REMEDY 1.
20 104433 VENT -FREE NA TURAL GAS HEA TER 15,000 TO 30,000 BTU/HR These Parts Centrals are privately-owned businesses. They have agreed to support our customer’s needs by providing original replacement parts and accessories. P AR TS CENTRALS TECHNICAL SER VICE You may have further questions about in- stallation, operation, or troubleshooting.
21 104433 OWNER’S MANUAL ACCESSORIES Purchase these heater accessories from your local dealer. If they can not supply these accessories, either contact your nearest Parts Central (see page 20) or call DESA International’s Sales Department at 1-800- 458-2472 for information.
22 104433 VENT -FREE NA TURAL GAS HEA TER 15,000 TO 30,000 BTU/HR 12-1 12-2 1 2 9 10 11 12 17 18 19 21 22 23 8 20 7 1 3 5 16 4 25 24 1 6 13 14 15 26 10 ILLUSTRA TED PA R T S BREAKDOWN RFN30T.
23 104433 OWNER’S MANUAL P AR TS LIST RFN30T This list contains replaceable parts used in your heater. When ordering parts, follow the instructions listed under Replacement Parts on page 16 of this manual.
104433-01 Rev. D 02/00 Model Serial No. Date Purchased Always specify model and serial numbers when communicating with the factory. We reserve the right to amend these specifications at any time without notice. The only warranty applicable is our standard written warranty.
Een belangrijk punt na aankoop van elk apparaat Desa RFN30T (of zelfs voordat je het koopt) is om de handleiding te lezen. Dit moeten wij doen vanwege een paar simpele redenen:
Als u nog geen Desa RFN30T heb gekocht dan nu is een goed moment om kennis te maken met de basisgegevens van het product. Eerst kijk dan naar de eerste pagina\'s van de handleiding, die je hierboven vindt. Je moet daar de belangrijkste technische gegevens Desa RFN30T vinden. Op dit manier kan je controleren of het apparaat aan jouw behoeften voldoet. Op de volgende pagina's van de handleiding Desa RFN30T leer je over alle kenmerken van het product en krijg je informatie over de werking. De informatie die je over Desa RFN30T krijgt, zal je zeker helpen om een besluit over de aankoop te nemen.
In een situatie waarin je al een beziter van Desa RFN30T bent, maar toch heb je de instructies niet gelezen, moet je het doen voor de hierboven beschreven redenen. Je zult dan weten of je goed de alle beschikbare functies heb gebruikt, en of je fouten heb gemaakt die het leven van de Desa RFN30T kunnen verkorten.
Maar de belangrijkste taak van de handleiding is om de gebruiker bij het oplossen van problemen te helpen met Desa RFN30T . Bijna altijd, zal je daar het vinden Troubleshooting met de meest voorkomende storingen en defecten #MANUAl# samen met de instructies over hun opplosinge. Zelfs als je zelf niet kan om het probleem op te lossen, zal de instructie je de weg wijzen naar verdere andere procedure, bijv. door contact met de klantenservice of het dichtstbijzijnde servicecentrum.
