Gebruiksaanwijzing /service van het product CCL3018NR van de fabrikant Desa Tech
Ga naar pagina of 36
Save this manual for future reference. For more information, visit www.desatech.com WARNING: If the information in this manual is not followed exactly, a fire or explosion may result causing property damage, personal injury, or loss of life.
www.desatech.com 111161-01D 2 WARNING: Improper installation, adjustment, altera- tion, service, or maintenance can cause injury or prop- erty damage. Refer to this manual for correct installation and operational procedures. For assistance or addi- tional information consult a qualified installer, service agency, or the gas supplier.
www.desatech.com 111161-01D 3 SAFETY INFORMATION WARNING: This product con- tains and/or generates chemicals known to the state of California to cause cancer or birth defects, or other reproductive harm. IMPORTANT: Read this owner’s manual carefully and completely before trying to assemble, oper- ate, or service this fireplace.
www.desatech.com 111161-01D 4 SAFETY INFORMATION Continued 3. T o prevent performance problems, the use of a propane/LP fuel tank of less than 100 lb. capacity is not recommended (propane/LP units only).
www.desatech.com 111161-01D 5 PRODUCT IDENTIFICATION Figure 1 - Vent-Free Gas Log Heater (Logs May Vary By Model) Log Set Control Knob Base Grate Piezo Ignitor Optional Remote Control Optional Selector Switch Flame Adjustment Knob UNPACKING CAUTION: Do not remove the data plates attached to the heater base assembly.
www.desatech.com 111161-01D 6 AIR FOR COMBUSTION AND VENTILATION Continued PROVIDING ADEQUATE VENTILATION The following are excerpts from National Fuel Gas Code, ANSI Z223.1/NFP A 54, Section 5.3, Air for Combustion and V entilation. All spaces in homes fall into one of the three fol- lowing ventilation classifications: 1.
www.desatech.com 111161-01D 7 * Do not include direct-vent gas appliances. Di- rect-vent draws combustion air from the outdoors and vents to the outdoors. Example: Gas water heater _________ Btu/Hr V ent-free fireplace + ________ Btu/Hr T otal = ________ Btu/Hr 4.
www.desatech.com 111161-01D 8 WARNING: Seal any fresh air vents or ash clean-out doors located on floor or wall of fire- place. If not, drafting may cause pilot outage or sooting.
www.desatech.com 111161-01D 9 INSTALLATION Continued WARNING: This appliance is equipped for (natural or pro- pane/LP) gas. Field conversion is not permitted. INSTALLATION AND CLEARANCES (Vent-Free Operation Only) WARNING: Maintain the minimum clearances.
www.desatech.com 111161-01D 10 INSTALLATION Continued Figure 5 - Heat Resistant Material (Slate, Marble, Tile, etc.) Above Fireplace If Using Mantel Y ou must have noncombustible material(s) above the fireplace opening. Noncombustible materials (such as slate, marble, tile, etc.
www.desatech.com 111161-01D 11 Minimum Noncombustible Material 8" Min. 12" 15" 18" All minimum distances are in inches Lo g S et 18", 24", 30" Models 20" 2 1 /2.
www.desatech.com 111161-01D 12 INSTALLING HEATER BASE ASSEMBLY CAUTION: Do not remove the data plates attached to the heater base assembly. The data plates contain important war- ranty and safety information. WARNING: You must secure this heater to fireplace floor.
www.desatech.com 111161-01D 13 For propane/LP units, the installer must supply an external regulator . The external regulator will re- duce incoming gas pressure. Y ou must reduce in- coming gas pressure to between 1 1 and 14 inches of water . If you do not reduce incoming gas pres- sure, heater regulator damage could occur .
www.desatech.com 111161-01D 14 INSTALLATION Continued * Purchase the optional CSA design-certified equipment shutoff valve from your dealer . See Accessories , page 34.
www.desatech.com 111161-01D 15 INSTALLATION Continued Test Pressures Equal To or Less Than 1/2 PSIG (3.5 kPa) 1. Close equipment shutoff valve (see Figure 15).
www.desatech.com 111161-01D 16 INSTALLING WIRELESS HAND- HELD REMOTE CONTROL ACCESSORY T wo 9-volt alkaline batteries (not included) are required to operate this heater with the wireless hand-held remote control set. One battery must be installed in the receiver and one in the hand- held remote control unit.
www.desatech.com 111161-01D 17 INSTALLATION Continued INSTALLING LOGS WARNING: Failure to posi- tion the parts in accordance with these diagrams or failure to use only parts specifically approved with this heater may result in property damage or personal injury.
www.desatech.com 111161-01D 18 5. Locate pegs on the bottom of crossover log (#5). Slide these pegs into the holes located in crossover log (#4) and front log (#1). See Figure 28. For CCL3018PR/NR Only: Locate holes on the bottom of crossover log (#5).
www.desatech.com 111161-01D 19 OPERATING HEATER FOR YOUR SAFETY READ BEFORE LIGHTING WARNING: If you do not fol- low these instructions exactly, a fire or explosion may result causing property damage, per- sonal injury or loss of life. A. This appliance has a pilot which must be lighted by hand.
www.desatech.com 111161-01D 20 CAUTION: Do not try to ad- just heating levels by using the equipment shutoff valve. WARNING: Make sure the selector switch is in the OFF position when you are away from home for long periods of time. Heater will come on automati- cally with selector switch in the ON position.
www.desatech.com 111161-01D 21 MANUAL LIGHTING PROCEDURE 1. Follow steps 1 through 6 under Lighting In- structions , pages 19 and 20. 2. Depress control knob and light pilot with match. 3. Keep control knob pressed in for 30 sec- onds after lighting pilot.
www.desatech.com 111161-01D 22 OPERATING HEATER Continued Manual Mode 1. Press the POWER and LOCK buttons to- gether to turn on the hand-held r emote contr ol. 2. Press the MANU button to turn on the fire- place. 3. Press the POWER and LOCK buttons to- gether to turn off the fir eplace.
www.desatech.com 111161-01D 23 CLEANING AND MAINTENANCE WARNING: Turn off heater and let cool before cleaning. CAUTION: You must keep control areas, burners, and circu- lating air passageways of heater clean. Inspect these areas of heater before each use.
www.desatech.com 111161-01D 24 TROUBLESHOOTING WARNING: Turn off heater and let cool before servicing. Only a qualified service person should service and repair heater. CAUTION: Never use a wire, needle, or similar object to clean ODS/pilot. This can damage ODS/pilot unit.
www.desatech.com 111161-01D 25 POSSIBLE CAUSE 1. Control knob not fully pressed in 2. Control knob not pressed in long enough 3. Equipment shutoff valve not fully open 4. Pilot flame not touching ther - mocouple, which allows ther- mocouple to cool, causing pi- lot flame to go out.
www.desatech.com 111161-01D 26 POSSIBLE CAUSE 1. Not enough air 2. Gas regulator defective 3. Residues from manufacturing processes and logs curing 1. Not enough combustion/ven- tilation air 1. Turning control knob to HI po- sition when burner is cold 2.
www.desatech.com 111161-01D 27 POSSIBLE CAUSE 1. Heater burning vapors from paint, hair spray , glues, clean- ers, chemicals, new carpet, etc. (See IMPOR T ANT statement above) 2 . Gas leak. See Warning statement at top of page 1. Not enough fresh air is avail- able 2.
www.desatech.com 111161-01D 28 ILLUSTRATED PARTS BREAKDOWN MODELS CCL3018PR, CCL3018PRA, CCL3018NR, AND CCL3018NRA 9 23 25 24 23 21 12 11 14 4 5 1 2 18 10 13 30 22 6 3 8 20 7 15 16 17 17 28 28 27 26 29 19 O F F P I L O T O N H I L O O F F P I L O T O N H I L O Note: Items 16 and 17 are Natural Gas only.
www.desatech.com 111161-01D 29 PARTS LIST This list contains replaceable parts used in your heater . When ordering parts, follow the instructions listed under Replacement Parts on page 33 of this manual.
www.desatech.com 111161-01D 30 30 18 19 27 18 23 12 11 14 4 5 1 2 17 10 21 20 22 6 7 3 9 20 16 8 15 29 28 28 25 26 O F F P I L O T O N H I L O O F F P I L O T O N H I L O 24 31 13 ILLUSTRATED PARTS BR.
www.desatech.com 111161-01D 31 PARTS LIST This list contains replaceable parts used in your heater . When ordering parts, follow the instructions listed under Replacement Parts on page 33 of this manual. P ART NUMBER CHL3924PR CHL3924NR KEY CCL3924PR CCL3924PRA CCL3930PR CCL3930PRA NO .
www.desatech.com 111161-01D 32 SPECIFICATIONS CCL3924PR CCL3018PR CCL3924PRA CCL3930PR CCL3018PRA CHL3924PR CCL3930PRA Btu (V ariable) 16,000/30,000 20,000/39,000 20,000/39,000 T ype Gas Propane/LP Propane/LP Propane/LP Ignition Piezo Piezo Piezo Manifold Pressure 8.
www.desatech.com 111161-01D 33 REPLACEMENT PARTS Note: Use only original replacement parts. This will protect your warranty coverage for parts re- placed under warranty .
www.desatech.com 111161-01D 34 ACCESSORIES Purchase these fireplace accessories from your lo- cal dealer . If they can not supply these accessories, either contact your nearest Parts Central (page 33) or call DESA Heating Products’ Sales Department at 1-866-672-6040 for referral information.
www.desatech.com 111161-01D 35 ___________________________________________________________ ___________________________________________________________ _________________________________________________.
2701 Industrial Drive P.O. Box 90004 Bowling Green, KY 42102-9004 www.desatech.com 111161-01 Rev. D 04/04 NOT A UPC WARRANTY INFORMATION KEEP THIS WARRANTY Model Serial No. Date Purchased Always specify model and serial numbers when communicating with the factory .
Een belangrijk punt na aankoop van elk apparaat Desa Tech CCL3018NR (of zelfs voordat je het koopt) is om de handleiding te lezen. Dit moeten wij doen vanwege een paar simpele redenen:
Als u nog geen Desa Tech CCL3018NR heb gekocht dan nu is een goed moment om kennis te maken met de basisgegevens van het product. Eerst kijk dan naar de eerste pagina\'s van de handleiding, die je hierboven vindt. Je moet daar de belangrijkste technische gegevens Desa Tech CCL3018NR vinden. Op dit manier kan je controleren of het apparaat aan jouw behoeften voldoet. Op de volgende pagina's van de handleiding Desa Tech CCL3018NR leer je over alle kenmerken van het product en krijg je informatie over de werking. De informatie die je over Desa Tech CCL3018NR krijgt, zal je zeker helpen om een besluit over de aankoop te nemen.
In een situatie waarin je al een beziter van Desa Tech CCL3018NR bent, maar toch heb je de instructies niet gelezen, moet je het doen voor de hierboven beschreven redenen. Je zult dan weten of je goed de alle beschikbare functies heb gebruikt, en of je fouten heb gemaakt die het leven van de Desa Tech CCL3018NR kunnen verkorten.
Maar de belangrijkste taak van de handleiding is om de gebruiker bij het oplossen van problemen te helpen met Desa Tech CCL3018NR . Bijna altijd, zal je daar het vinden Troubleshooting met de meest voorkomende storingen en defecten #MANUAl# samen met de instructies over hun opplosinge. Zelfs als je zelf niet kan om het probleem op te lossen, zal de instructie je de weg wijzen naar verdere andere procedure, bijv. door contact met de klantenservice of het dichtstbijzijnde servicecentrum.
