Gebruiksaanwijzing /service van het product VGP30 van de fabrikant Desa
Ga naar pagina of 28
Save this manual for future reference. D E S I G N N A E S T D C E R T I I F I E A M C R I A S O C I A O N ® WARNING: If the information in this manual is not followed exactly, a fire or explosion may result causing property damage, per- sonal injury, or loss of life.
2 CONTENTS SECTION PAGE Safety Information ......................................................................... 2 Product Identification .................................................................... 4 Local Codes ..........................
3 SAFETY INFORMA TION Continued ! WARNING ICON G 001 W ARNINGS Continued 1. Use only propane gas. Do not convert heater to use different fuel type. 2. Do not place propane supply tank(s) inside any structure. Locate propane supply tank(s) outdoors. 3.
4 PRODUCT IDENTIFICA TION Figure 1 - Vent-Free Propane Gas Garage Heater Ignitor Button Control Knob Heater Cabinet Front Panel Heat Shield Grill Guard PRODUCT FEA TURES Safety Device This heater has a pilot with an Oxygen Depletion Sensor Shutoff System (ODS).
5 INST ALLING T O W ALL NOTICE A qualified service person must install heater. Follow all local codes. CHECK GAS TYPE Use only propane gas. If your gas supply is not propane, do not install heater. Call dealer where you bought heater for proper type heater.
6 CAUTION When installing, locate heater where moving vehicle will not hit it. ! WARNING ICON G 001 GRH/PV 009A CLEARANCE-Garage heater 36" 16 3/4" FLOOR CEILING Minimum Minimum To Top Surfa.
7 Methods For Attaching Mounting Bracket To Wall Only use last hole on each end of mounting bracket to attach bracket to wall. These two holes are 16 inches apart from their centers. Attach mounting bracket to wall in one of two ways. 1. Attaching to wall stud 2.
8 18 3/4" Min. 11" Min. 16" Adjoining Wall Only Insert Mounting Screws Through Last Hole On Each End Floor Marking Screw Locations 1. Tape mounting bracket to wall where heater will be located.
9 4. For thin walls (1/2" or less), insert red key into wall anchor. Push red key to “ pop ” open anchor wings. IMPORTANT: Do not hammer key! For thick walls (over 1/2" thick) or solid walls, do not pop open wings. Figure 9 - Installing Bottom Mounting Screws Figure 7 - Popping Open Anchor Wings For Thin Walls 5.
10 CONNECTING T O GAS SUPPL Y CAUTION Never connect heater directly to the propane supply. This heater requires an external regulator (not supplied). Install the external regulator between the heater and propane supply. ! WARNING ICON G 001 The installer must supply an external regulator.
11 CAUTION Make sure external regulator has been installed between propane supply and heater. See guidelines under CONNECTING TO GAS SUPPLY, page 10. ! WARNING ICON G 001 ! WARNING ICON G 001 W ARNING Never use an open flame to check for a leak. Apply a mixture of liquid soap and water to all joints.
12 3. Pressurize supply piping system by either using compressed air or opening propane supply tank valve. 4. Check all joints of gas supply piping system. Apply mixture of liquid soap and water to gas joints. Bubbles forming show a leak. 5. Correct all leaks at once.
13 OPERA TING HEA TER FOR YOUR SAFETY READ BEFORE LIGHTING A. This appliance has a pilot which must be lighted by hand. When lighting the pilot, follow these instructions exactly. B. BEFORE LIGHTING smell all around the appliance area for gas. Be sure to smell next to the floor because some gas is heavier than air and will settle on the floor.
14 CAUTION Do not try to adjust heating levels by using the manual shutoff valve. ! WARNING ICON G 001 C-clockwise 4. Wait five (5) minutes to clear out any gas. Then smell for gas, including near the floor. If you smell gas, STOP! Follow “ B ” in the safety information at the top of page 13.
15 TO TURN OFF GAS TO APPLIANCE Clockwise Continued Figure 17 - Incorrect Pilot Flame Pattern Thermocouple Pilot Burner Clockwise INSPECTING BURNER Check pilot flame pattern and burner flame pattern often. PILOT FLAME PATTERN Figure 16 shows a correct pilot flame pattern.
16 If pilot flame pattern is incorrect, as shown in Figure 17 • turn heater off (see TO TURN OFF GAS TO APPLIANCE, page 15) • see TROUBLESHOOTING, pages 17 thru 20 BURNER FLAME PATTERN Figure 18 shows a correct burner flame pattern. Figure 19 shows an incorrect burner flame pattern.
17 CLEANING AND MAINTENANCE ! WARNING ICON G 001 W ARNING Turn off heater and let cool before cleaning. TROUBLE- SHOOTING POSSIBLE CAUSE 1 . Ignitor electrode posi- tioned wrong 2. Ignitor electrode broken 3. Ignitor electrode not con- nected to ignitor cable 4.
18 REMEDY 1. Turn on gas supply or open manual shutoff valve 2. Turn control knob to PI- LOT position 3. Press in control knob while in PILOT position 4. Continue holding down control knob. Repeat ig- niting operation until air is removed 5. Contact local propane gas company 6.
19 OBSERVED PROBLEM Burner does not light after ODS/pilot is lit (continued from page 18) Delayed ignition of burner Burner backfiring during combustion Yellow flame during burner combustion Slight smoke or odor during initial opera- tion Heater produces a whistling noise when burner is lit REMEDY 2.
20 W ARNING ! WARNING ICON G 001 If you smell gas • Shut off gas supply. • Do not try to light any appliance. • Do not touch any electrical switch; do not use any phone in your building. • Immediately call your gas supplier from a neighbor ’ s phone.
21 TECHNICAL SER VICE You may have further questions about installation, operation, or troubleshooting. If so, contact DESA International ’ s Technical Service Department at 1-800-323- 5190. SPECIFICA TIONS B.T.U (Variable) 15,000/30,000 Type Gas Propane Only Ignition Piezo Pressure Regulator Setting 8" W.
22 REPLACEMENT P ARTS Note: Use only original replacement parts. This will protect your warranty cover- age for parts replaced under warranty. Parts Under Warranty Contact authorized dealers of this product. If they can ’ t supply original replace- ment part(s), call DESA International ’ s Technical Service Department at 1-800- 323-5190.
23 ACCESSORIES Purchase these heater accessories from your local dealer. If they can not supply these accessories, call DESA International ’ s Parts Department at 1-800-972-7879. You can also write to the address listed on the back page of this manual.
24 1 2 3 4 5 6 7 8 8 9 10 11 12 13 14 15 17 25 19 21 22 23 24 20 27 26 18 28 16 10-1 10-2 (Round) 10-3 (Square) ODS/Pilot.
25 P ARTS LIST This list contains replaceable parts used in your heater. When ordering parts, follow the instructions listed under REPLACEMENT PARTS on page 22 of this manual.
26 NOTES.
27 NOTES.
KEEP THIS WARRANTY W ARRANTY INFORMA TION Always specify model and serial numbers when communicating with the factory. We reserve the right to amend these specifications at any time without notice. The only warranty applicable is our standard written warranty.
Een belangrijk punt na aankoop van elk apparaat Desa VGP30 (of zelfs voordat je het koopt) is om de handleiding te lezen. Dit moeten wij doen vanwege een paar simpele redenen:
Als u nog geen Desa VGP30 heb gekocht dan nu is een goed moment om kennis te maken met de basisgegevens van het product. Eerst kijk dan naar de eerste pagina\'s van de handleiding, die je hierboven vindt. Je moet daar de belangrijkste technische gegevens Desa VGP30 vinden. Op dit manier kan je controleren of het apparaat aan jouw behoeften voldoet. Op de volgende pagina's van de handleiding Desa VGP30 leer je over alle kenmerken van het product en krijg je informatie over de werking. De informatie die je over Desa VGP30 krijgt, zal je zeker helpen om een besluit over de aankoop te nemen.
In een situatie waarin je al een beziter van Desa VGP30 bent, maar toch heb je de instructies niet gelezen, moet je het doen voor de hierboven beschreven redenen. Je zult dan weten of je goed de alle beschikbare functies heb gebruikt, en of je fouten heb gemaakt die het leven van de Desa VGP30 kunnen verkorten.
Maar de belangrijkste taak van de handleiding is om de gebruiker bij het oplossen van problemen te helpen met Desa VGP30 . Bijna altijd, zal je daar het vinden Troubleshooting met de meest voorkomende storingen en defecten #MANUAl# samen met de instructies over hun opplosinge. Zelfs als je zelf niet kan om het probleem op te lossen, zal de instructie je de weg wijzen naar verdere andere procedure, bijv. door contact met de klantenservice of het dichtstbijzijnde servicecentrum.
