Gebruiksaanwijzing /service van het product SF-150 SF-250 van de fabrikant Harman Stove Company
Ga naar pagina of 19
1 I nstallation and O perator ’ s M anual SF-150 SF-250 KEEP THESE INSTR UCTIONS “Built to a Standard, Not a Price.” 2003 CA UTION: Read W arnings and S afety Considerations/ R ecommendations for safe installation & operation.
1 Thank you . . . THANK YOU FOR PURCHASING A HARMAN STOVE AND FOR READING THIS OWNER’S MANUAL. It is our desir e to provide as much data as needed to allow you to install and operate your Har man Stove in the safest manner possible. There are a number of excellent sources on wood heating which you might like to purchase for your home library.
2 Index INTRODUCTION READ ALL INFORMA TION “ PRIOR” TO PROCEEDING WITH INST ALLA TIONS, AND CHECK WITH YOUR LOCAL AUTHORITIES FOR PREV AILING FIRE ORDINANCES AND RECOMMEN - DA TIONS. 1. SAFETY CONSIDERA TIONS - W ar nings to owner/operator of possible dangers, fire hazards and cautions.
3 1.1 KEEP CHILDREN A W A Y -- MA Y CAUSE SERIOUS BURNS CAUTION: ALL SURF ACES OF S TO VE A RE HO T . DO N OT TOUCH! KEEP CHILDREN A W A Y . SERIOUS BURNS WILL RESUL T IF TOUCHED. THIS IS A HEA T PRODUCING APPLIANCE. SERI - OUS BURNS MA Y RE SUL T IF THE STOVE IS TOUCHED DUR - ING FIRING.
4 3. Assembly Fasten blower to rear of stove by sliding blower into slots provided. Heat Collector Diagram Fir ebrick Diagram SF-150 SF-250.
5 4. Chimney 4.1 T ypes of Chimneys The chimney is one of the most important, yet most neglected and misunderstood portion of any solid fuel bur ning installation. W e do not r ecommend that the stove be con - nected to a chimney with other heating devices.
6 NOTE: The Chimney on the house illustrated is too low. It should be raised to compensate for drafts. E. Chimney Size - Chimney is not properly sized to adequately vent the appliance. It is either too small or too lar ge. F . Chimne y Off sets - Chimne ys with offsets should not be used.
7 The most common cause of poor draft is an improperly sized flue liner . W e recommend that the chim - ney liner’s inside dimensions be at least as lar ge as the appliance’s col - lar size and no lar ger than 125% of the collar for a round flue.
8 build-up has occurred. I f cr e os o te ha s a c cu mu la t ed , i t should be removed to reduce the risk of a chimney fir e. If an over -fire situation should occur , be sure ash door and fire door ar e closed. In the event of a soot fire, call your fire department immediately, and make sure the ash door , fire door and drafts are closed.
9 HOW MUCH A V AILABLE HEA T IS THERE IN AIR-DRIED (20% MOISTURE) WOOD PER CORD? APPROX. B.T .U. A V AILABLE A VERAGE WEIGHT IN AN AIR-DRIED CORD ORDER OF MOST TYPE PER CORD BURNED A T 50% EFFICIENCY HEA T PER CORD Ash 2.950 lbs. 11,300,000 Eleventh Aspen 1,900 lbs.
10 installation instructions. 4. M ul t ip l e v e nt in g s ho u ld b e avoided wherever possible. Never install your stove into the same vent as a gas fur nace. 5. Check for proper r oof clear - ances. See page 5 and check your local codes. 6. Chimney must be two feet high - er than anything ten feet around it.
11 than 8 inches of brickwork or equiv - alent firepr oofing material. C. Where all combustible material is cut out of the partition wall for a sufficient distance to provide not less than 18 inches clearance on all sides of the connector . Any material used to close this opening must be non-combustible insulating material.
12 One-eighth to 1/4" accumulation on interior parts is nor mal. The most important area is between the pipes indicated by the arrow in Figure 6. Under nor mal operation it is not necessary to clean the cham - b e r . E xce s si ve a cc um ul ati o n wi ll only occur when wood is bur ned very slowly for long periods of time.
13 the fire has started to die. This will cause the reloading process to be much longer , and ther e is a good possibility of losing the fire. Do not shake or stir with a low fire. Open the draft control wide or open the ash cleanout door to get the maximum draft.
14 Serious damage to the stove can occur from overheating. Coal stoves should not be installed in any chimney that has had a his - tory of back-drafting or flow rever - sal. The se co ndition s can ca use improper draft, r esulting in carbon monoxide entering the house rather than being drawn up the chimney.
15 PLUMBING DIAGRAM FOR THERMO-SIPHON METHOD - MAX. DIST ANCE 10 FT . COIL INST ALLA TION (See Coil Diagram on Page 14) Place one of the nuts supplied on each leg of the coil. Place coil through the holes in the back of the fir ebox and adjust the nuts so the pipes stick out about 1 1/4 to 1 1/2 inches from the side of the stove.
16 PLUMBING DIAGRAM FOR CIRCULA TING PUMP METHOD - MORE THAN 10 FT . CIRCULA TING PUMP METHOD (MORE THAN 10 FEET) This method is used when the hot water heater tank is more than ten feet away from the stove or the stove is on a higher level than the hot water heater tank.
17.
MIP-1273 Harman Stove Company warrants its central heat products to be free from defects in material or workmanship, in normal use and service, for a period of 5 years from the date of sales invoice and for mechanical and electrical failures, in normal use and service, for a period of 1 year from the date of sales invoice.
Een belangrijk punt na aankoop van elk apparaat Harman Stove Company SF-150 SF-250 (of zelfs voordat je het koopt) is om de handleiding te lezen. Dit moeten wij doen vanwege een paar simpele redenen:
Als u nog geen Harman Stove Company SF-150 SF-250 heb gekocht dan nu is een goed moment om kennis te maken met de basisgegevens van het product. Eerst kijk dan naar de eerste pagina\'s van de handleiding, die je hierboven vindt. Je moet daar de belangrijkste technische gegevens Harman Stove Company SF-150 SF-250 vinden. Op dit manier kan je controleren of het apparaat aan jouw behoeften voldoet. Op de volgende pagina's van de handleiding Harman Stove Company SF-150 SF-250 leer je over alle kenmerken van het product en krijg je informatie over de werking. De informatie die je over Harman Stove Company SF-150 SF-250 krijgt, zal je zeker helpen om een besluit over de aankoop te nemen.
In een situatie waarin je al een beziter van Harman Stove Company SF-150 SF-250 bent, maar toch heb je de instructies niet gelezen, moet je het doen voor de hierboven beschreven redenen. Je zult dan weten of je goed de alle beschikbare functies heb gebruikt, en of je fouten heb gemaakt die het leven van de Harman Stove Company SF-150 SF-250 kunnen verkorten.
Maar de belangrijkste taak van de handleiding is om de gebruiker bij het oplossen van problemen te helpen met Harman Stove Company SF-150 SF-250 . Bijna altijd, zal je daar het vinden Troubleshooting met de meest voorkomende storingen en defecten #MANUAl# samen met de instructies over hun opplosinge. Zelfs als je zelf niet kan om het probleem op te lossen, zal de instructie je de weg wijzen naar verdere andere procedure, bijv. door contact met de klantenservice of het dichtstbijzijnde servicecentrum.
