Gebruiksaanwijzing /service van het product Compressor van de fabrikant Invacare
Ga naar pagina of 40
User: Befo re using the product , read this manual and save for future reference. Dealer: This m anual must be given to the end user. For more inform ation reg arding Inva care pro ducts, parts, and serv ices, please v isit www .
WARNING HomeFill ™ II Compresso r 2 Part No 1100873 WARNIN G DO NOT OPERATE THIS EQUIPMENT WITHOUT FIRST READING AND UNDERS TANDING THIS MANUAL. IF Y OU ARE UNAB LE TO UNDERSTAND THE DANGERS, WA.
TABLE OF CONTENTS TABLE OF CONTEN TS HomeFill ™ II Compresso r 3 Part No 1100873 SPE CI AL NO TES ...... ....... .... ...... ...... ....... ...... ..... 4 TYP IC AL PRO DU CT ....... ...... .... ...... ....... ...... ..... 5 PARA ME TE RS ...... ...
SPECIAL NOTES HomeFill ™ II Compresso r 4 Part No 1100873 SPECIA L NO TES Check all parts for shipping damage. In case of damage, DO NOT use. Contact Inv acare for further instruction. Signal words ar e used in this manual and apply to hazards or unsafe practices whi ch could result i n personal injury or property d amage.
Part No 1100873 5 HomeFill ™ II Compresso r TYPICAL PRODUCT PARA METERS TYPICAL PRODUC T PARAME TERS - CO MPRESSOR Regulato ry Listing : Double Insulated P roduct ETL Certified Complying w ith UL73 and UL1097 (U S) ETL Certified Complying w ith CAN/CSA C22.
HomeFill ™ II Compresso r 6 Part No 1100873 LABE L LOCA TIO N DEALER IN FORMATION NOTE: Invacare recomme nds leaving a full cylinder o f o xygen with the patient after setting up the HomeFill II compressor .
HOMEFILL II INFORMATION HomeFill ™ II Compresso r 7 Part No 1100873 HOMEF ILL II INF ORMATION HomeFill I I is an accessory device to t he oxygen concentrator that enables the patient to refill custom portable oxyg en cylinders for personal use.
SECTION 1—IMPORTANT SAFETY INSTRUCTIONS Part No 1100873 8 HomeFill ™ II Compresso r SECTI ON 1— IMPO RTANT SAFETY INSTRU CTIO NS WARNING SECTION 1 - IMPORTANT SAFETY INSTRUCTIONS contains important info rmation for the safe operation an d use of this product.
SECTION 1—IMPORTANT SAFETY INSTRUCTIONS HomeFill ™ II Compresso r 9 Part No 1100873 DO NOT allo w oil from y our hands or other sources to come into contact with the compressor couplin g or bottle fittings. These substances may become flam mable in the presence of oxygen and cause injury .
SECTION 1—IMPORTANT SAFETY INSTRUCTIONS Part No 1100873 10 HomeFill ™ II Compresso r DO NOT store filled oxygen cylinders near a furnace, hot w ater tank, in the trunk of a car or other high temperatur e area. Storage in areas such as thi s c an result in bu rsting of the cylinder or fire.
SECTION 1—IMPORTANT SAFETY INSTRUCTIONS HomeFill ™ II Compresso r 11 Part No 1 100873 If any leakage of the o xygen cylinder i s detected DO NOT attempt to use the c ylinder .
SECTION 2—INITIAL SETUP Part No 1100873 12 HomeFill ™ II Compresso r SECTI ON 2— INITI AL SETU P NOTE: Dealers Only - Refer to Dealer Informat ion on page 6 before performing this pr ocedure.
SECTION 2—INITIAL SETUP HomeFill ™ II Compresso r 13 Part No 1 100873 Transporting the C ompressor WARNING NEVER transport a compressor with a cyli nder connected to or stored on the compressor, otherwise injury or damage can occur.
SECTION 2—INITIAL SETUP Part No 1100873 14 HomeFill ™ II Compresso r 4. Plug the opposite end of the power cord i nto the w all outlet. FIGURE 2.2 Installing the Power Cord Connecti ng the C ompressor t o the Conc entrator NOTE: For this procedur e, refer to F I GURE 2.
SECTION 2—INITIAL SETUP HomeFill ™ II Compresso r 15 Part No 1 100873 FIGURE 2.3 Connecting the Compressor to the Concentrator.
SECTION 3—CHECKLIST AND CYLINDER INSPECTION Part No 1100873 16 HomeFill ™ II Compresso r SECTI ON 3— CHECK LIST A ND CYLIND ER IN SPECTIO N Compres sor Op eration C hecklist Each time the HomeFi.
SECTION 3—CHECKLIST AND CYLINDER INSPECTION HomeFill ™ II Compresso r 17 Part No 1 100873 FIGURE 3.1 Cylinder Prefill Inspection DO NO T REMO VE THIS PRODUCT LABEL Not for Commer cial Resale Inv acare Corporation 2101 E.
SECTION 3—CHECKLIST AND CYLINDER INSPECTION Part No 1100873 18 HomeFill ™ II Compresso r The Hydrost atic Test ing Date Aluminum cyli nders MUST under go te sting ev ery fiv e y ears. WARNING DO NOT fill cylinders that have not been tested in the past five years.
Please Seal with Tape Before Mailing.
REGISTER YOUR PRODUCT! The benefits of registering: 1. Safeguard your investment. 2. Ensure long term maintenance and servicing of your purchase. 3. Receive updates with product information, maintenance tips, and industry news. 4. Invacare can contact you or your provider, if servicing is needed on your product.
1. Method of purchase: (check all that apply) ❏ Medicare ❏ Insurance ❏ Medicaid ❏ Other 2. This product was purchased for use by: (check one) ❏ Self ❏ Parent ❏ Spouse ❏ Other 3. Product was purchased for use at: ❏ Home ❏ Facility ❏ Other 4.
.
SECTION 4—COMPRESSOR OPERATION HomeFill ™ II Compresso r 23 Part No 1 100873 SECT ION 4—COMPR ES SOR OPER ATION Connectin g/Disconn ectin g the C ylinder to/from th e Comp ressor Conn ectin g t he Cyl inder to t he Comp re ss or WARNING NEVER use tools of any kind to con nect/disconnect the cylinder and the compressor.
SECTION 4—COMPRESSOR OPERATION Part No 1100873 24 HomeFill ™ II Compresso r CAUTION DO NOT connect the outlet (cannula) connection to the HomeFill II compressor, otherwise the conserving cylinder will not work properly.
SECTION 4—COMPRESSOR OPERATION HomeFill ™ II Compresso r 25 Part No 1 100873 8. Pull UP on the outer ri ng (sleev e) of the connec tor fillport while pushing DOWN on the cylinder/regulator assembly to couple the cylinder fillport into the connector fillport (FIGURE 4.
SECTION 4—COMPRESSOR OPERATION Part No 1100873 26 HomeFill ™ II Compresso r FIGURE 4.2 Connecting the Cylinder to the Compre s sor.
SECTION 4—COMPRESSOR OPERATION HomeFill ™ II Compresso r 27 Part No 1 100873 Disconnecti ng the Cy linder from the Compre ssor WARNING NEVER use tools of any kind to con nect/disconnect the cylinder and the compressor. Otherwise, severe injury and/or damage may occur.
SECTION 4—COMPRESSOR OPERATION Part No 1100873 28 HomeFill ™ II Compresso r 5. When the cylinder fillport is di sconnected from the connector fillport, release the outer ri ng (sleeve) o f the connector fillport and use two hands to r emove the cylinder from the compressor cradle.
SECTION 4—COMPRESSOR OPERATION HomeFill ™ II Compresso r 29 Part No 1 100873 Turni ng the Comp resso r On NOTE: For this procedur e, refer to FIGURE 4.5 on page 30. 1. Make sure the concentrato r i s On. Refer to the concentrator Owner ’ s Manual.
SECTION 4—COMPRESSOR OPERATION Part No 1100873 30 HomeFill ™ II Compresso r oxygen level r eaches 90%. If light does not go Off within 10 minutes, r efer to T r oubleshoot ing/ Cylin der Fill times on page 34. NOTE: If the A TTENTION (RED) light and audi ble alarm are on.
SECTION 4—COMPRESSOR OPERATION HomeFill ™ II Compresso r 31 Part No 1 100873 Settin g the Flow Knob to the Prescri bed Settin g NOTE: For this procedur e, refer to FIGURE 4.6. 1. Attach the nasal cannula to the outlet fitting of the cylinder . 2. T urn the flow knob to the L/min.
SECTION 5—INDICATOR LIGHTS Part No 1100873 32 HomeFill ™ II Compresso r SECTI ON 5— INDIC ATO R LIGHT S INDICATOR LIGHT COL OR COMPRESSOR STATUS EFFECT None Compressor is Off O 2 flowing to user.
SECTION 5—INDICATOR LIGHTS HomeFill ™ II Compresso r 33 Part No 1 100873 ATTENTION - RED (Audible Alarm) Compressor is On. Cylinder NOT filling Causes: Full cylinder a ttached when unit turned On .
SECTION 6—TROUBLESHOOTING/ CYLINDER FILL TIMES Part No 1100873 34 HomeFill ™ II Compresso r SECT ION 6—TROUBL ES HOOTIN G/ CYLIND ER FI LL TIM ES TROUBLESHOOTING PROBLEM SOLUTION No indicator lig hts on when compressor turned on. 1. Turn compressor Off.
SECTION 6—TROUBLESHOOTING/ CYLINDER FILL TIMES HomeFill ™ II Compresso r 35 Part No 1 100873 O 2 BELOW NORMAL (YELLOW) light stays On 1. Ensure the concentrator has warmed up for at least 20 minutes.If it has not been 20 minutes, turn the compressor Off until the concentrator warms up.
SECTION 6—TROUBLESHOOTING/ CYLINDER FILL TIMES Part No 1100873 36 HomeFill ™ II Compresso r NOTE: All filling times ar e approximate and may vary on envir onmental conditions. Regulator is On but O 2 is not being delivered 1. Refill cyl inder 2. Check that cannula is straight and not pinched.
SECTION 7—MAINTENANCE HomeFill ™ II Compresso r 37 Part No 1 100873 SECT ION 7—MAIN TENAN CE Clea ning the Compress or Filter WARNING Push the power switch to t he Off (O) position and unplug the compressor before cleaning. DO NOT operate the compress or without the filter installed.
LIMITED WARRANTY Part No 1100873 38 HomeFill ™ II Compresso r Cabi net WARNING Push the power switch to t he Off (O) position and unplug the compressor before cleaning. To avoid electrical shock , DO NOT remove cabinet. 1. Clean the cabinet with a mi ld household cleaner and non-abrasive cloth or spong e.
HomeFill ™ II Compresso r 39 Part No 1 100873 For Mod el Nos . IOH2M6 and IOH2M9, Invacare warrants the HomeFill II regulator (NOT i ncludi ng the cyli nder) to be f ree from defects in materi als a.
(INCLUDING, BU T NOT LIMITED TO, MODIFICATION THROUGH THE U SE OF UNA UTHORIZED PARTS OR ATTACHMENTS) OR TO PRODUCTS DAMAGED BY REASON OF REPAIRS MADE TO ANY C OMPONENT WITHOU T THE SPECIFIC CONSENT OF INVACAR E CORPORATION OR TO PRODUCTS DAMAG ED BY CIRCUM STANCES BEYOND INVACARE CORPOR ATION'S CONTROL.
Een belangrijk punt na aankoop van elk apparaat Invacare Compressor (of zelfs voordat je het koopt) is om de handleiding te lezen. Dit moeten wij doen vanwege een paar simpele redenen:
Als u nog geen Invacare Compressor heb gekocht dan nu is een goed moment om kennis te maken met de basisgegevens van het product. Eerst kijk dan naar de eerste pagina\'s van de handleiding, die je hierboven vindt. Je moet daar de belangrijkste technische gegevens Invacare Compressor vinden. Op dit manier kan je controleren of het apparaat aan jouw behoeften voldoet. Op de volgende pagina's van de handleiding Invacare Compressor leer je over alle kenmerken van het product en krijg je informatie over de werking. De informatie die je over Invacare Compressor krijgt, zal je zeker helpen om een besluit over de aankoop te nemen.
In een situatie waarin je al een beziter van Invacare Compressor bent, maar toch heb je de instructies niet gelezen, moet je het doen voor de hierboven beschreven redenen. Je zult dan weten of je goed de alle beschikbare functies heb gebruikt, en of je fouten heb gemaakt die het leven van de Invacare Compressor kunnen verkorten.
Maar de belangrijkste taak van de handleiding is om de gebruiker bij het oplossen van problemen te helpen met Invacare Compressor . Bijna altijd, zal je daar het vinden Troubleshooting met de meest voorkomende storingen en defecten #MANUAl# samen met de instructies over hun opplosinge. Zelfs als je zelf niet kan om het probleem op te lossen, zal de instructie je de weg wijzen naar verdere andere procedure, bijv. door contact met de klantenservice of het dichtstbijzijnde servicecentrum.
