Gebruiksaanwijzing /service van het product SV715 van de fabrikant Kohler
Ga naar pagina of 20
O WNER ' S M ANUAL V ERTICAL C RANKSHAFT C OURAGE SV710-740 C OURAGE PRO SV810-840.
2 Safety Precautions Electrical Shock! Never touch electrical wires or components while the engine is running. They can be sources of electrical shock. CAUTION Electrical Shock can cause injury . Do not touch wires while engine is running. Rotating Parts can cause severe injury .
3 Accidental Starts can cause severe injury or death. Disconnect and ground spark plug leads before servicing. W ARNING Carbon Monoxide can cause severe nausea, fainting or death. W ARNING W ARNING Explosive Gas can cause fi res and severe acid burns.
4 Oil Filter Air Cleaner Access Door Handle Recti fi er-Regulator Fuel Pump Identi fi cation Plate Oil Recommendations Using the proper type and weight of oil in the crankcase is extremely important. So is checking oil daily and changing oil regularly .
5 General Recommendations Purchase gasoline in small quantities and store in clean, approved containers. A container with a capacity of 2 gallons or less with a pouring spout is recommended. Such a container is easier to handle and helps eliminate spillage during refueling.
6 Operating Instructions Also read the operating instructions of the equipment this engine powers. Pre-Start Checklist • Check oil level. Add oil if low . Do not over fi ll. • Check fuel level. Add fuel if low . • Check cooling air intake areas and external surfaces of engine.
7 Maintenance Instructions Maintenance, repair , or replacement of the emission control devices and systems, which are being done at the customers expense, may be performed by any non-road engine repair establishment or individual. W arranty repairs must be performed by an authorized Kohler service outlet.
8 Figure 5. Dipstick Styles. Figure 8. Oil Drain Plug. 3. Remove the oil fi ll cap/dipstick; wipe oil o ff . For engines with a press-on style dipstick: Reinsert the dipstick into the tube and press all the w ay down.
9 Change the oil and oil fi lter as follows. 1. The drain plug is located on the starter side of the oil pan. See Figure 8. Clean the area around the oil drain plug and the oil fi ll cap/dipstick. 2. Remove the drain plug and the oil fi ll cap/ dipstick.
10 Service Paper Element Check the paper element every 50 hours of operation, (more o en under extremely dusty or dirty conditions). Clean or replace the element as necessary . Replace the air cleaner element annually , or every 100 hours . 1. Open the door on the blower housing to access the air cleaner element.
11 NOTE: Operating the engine with a blocked grass screen, dirty or plugged cooling fi ns, and/or cooling shrouds removed, will cause engine damage due to overheating. Ignition System These engines use an electronic Capacitive Discharge (CD) ignition system.
12 Low Idle Mixture Screw Idle Speed (RPM) Adjustment Screw Fuel Solenoid If, a er checking the items listed above, the engine is hard to start, runs roughly , or stalls at low idle speed, it may be necessary to adjust or service the carburetor .
13 The system requires an additional procedure for se ing the idle speed. If speed adjustments are required proceed as follows. 1. Make any necessary speed or control adjustments following the appropriate instructions covered in this section. 2. Move the thro le control to the idle position.
14 Courage ® SV710-740 Speci fi cations Model: ...................................................................................SV710 ............................... ..SV715 ...........................SV720 Bore: ..................................
15 COURAGE ® SV710-740 ENGINE LIMITED W ARRANTY Kohler Co. warrants to the original retail consumer that each new COURAGE ® engine sold by Kohler Co.
16 Courage PRO ™ SV810-840 Speci fi cations Model: ...................................................................................SV810 .......................................................................SV820 Bore: .........................
17 COURAGE PRO TM SV810-840 ENGINE LIMITED W ARRANTY Kohler Co. warrants to the original retail consumer that each new COURAGE PRO ™ engine sold by Kohler Co.
18 Continued on next page. KOHLER CO. FEDERAL AND CALIFORNIA EMISSION CONTROL SYSTEMS LIMITED W ARRANTY SMALL OFF-ROAD ENGINES The U.S. Environmental Protection Agency (EPA), the California Air Resources Board (CARB), and Kohler Co.
19 • Fuel lines, fuel line fi ings and clamps (if equipped) • Air fi lter, fuel fi lter , and spark plugs (only • Spark advance module (if equipped) to fi rst scheduled replacement point.
REVISED: 6/09 LITHO IN U.S.A. FORM NO.: 32 590 01-B ISSUED: 9/05 ENGINE DIVISION, KOHLER CO., KOHLER, WISCONSIN 53044 FOR SALES AND SER VICE INFORMA TION IN U.
Een belangrijk punt na aankoop van elk apparaat Kohler SV715 (of zelfs voordat je het koopt) is om de handleiding te lezen. Dit moeten wij doen vanwege een paar simpele redenen:
Als u nog geen Kohler SV715 heb gekocht dan nu is een goed moment om kennis te maken met de basisgegevens van het product. Eerst kijk dan naar de eerste pagina\'s van de handleiding, die je hierboven vindt. Je moet daar de belangrijkste technische gegevens Kohler SV715 vinden. Op dit manier kan je controleren of het apparaat aan jouw behoeften voldoet. Op de volgende pagina's van de handleiding Kohler SV715 leer je over alle kenmerken van het product en krijg je informatie over de werking. De informatie die je over Kohler SV715 krijgt, zal je zeker helpen om een besluit over de aankoop te nemen.
In een situatie waarin je al een beziter van Kohler SV715 bent, maar toch heb je de instructies niet gelezen, moet je het doen voor de hierboven beschreven redenen. Je zult dan weten of je goed de alle beschikbare functies heb gebruikt, en of je fouten heb gemaakt die het leven van de Kohler SV715 kunnen verkorten.
Maar de belangrijkste taak van de handleiding is om de gebruiker bij het oplossen van problemen te helpen met Kohler SV715 . Bijna altijd, zal je daar het vinden Troubleshooting met de meest voorkomende storingen en defecten #MANUAl# samen met de instructies over hun opplosinge. Zelfs als je zelf niet kan om het probleem op te lossen, zal de instructie je de weg wijzen naar verdere andere procedure, bijv. door contact met de klantenservice of het dichtstbijzijnde servicecentrum.
