Gebruiksaanwijzing /service van het product Pump van de fabrikant Pentair
Ga naar pagina of 20
IMPOR T ANT SAFETY INSTRUCTIONS READ AND FOLLOW ALL INSTRUCTIONS SA VE THESE INSTRUCTIONS Installation and User's Guide SuperFlo ™ High Performance Pump.
© 2005 Pentair W ater Pool and Spa, Inc. All rights reserved. This document is subject to change without notice. 1620 Hawkins Ave., Sanford, NC 27330 • (919) 566-8000 10951 West Los Angeles A ve., Moorpark, CA 93021 • (805) 553-5000 T rademarks and Disclaimers : SuperFlo is a trademark of Pentair W ater Pool and Spa, Inc.
i SuperFlo Pump Installation and User ’ s Guide T able of Contents Important Safety Precautions .............................................................................................. i i Section 1: Introduction ..............................
ii SuperFlo Pump Installation and User ’ s Guide IMPORTANT SAFETY PRECAUTIONS Consumer Information and Safety The SuperFlo pumps are designed and manufactured to provide many years of safe and relia.
iii SuperFlo Pump Installation and User ’ s Guide IMPORTANT SAFETY PRECAUTIONS (continued) W ARNING — Do not operate the pump until you have read and understand clearly all the operating instructions and warning messages for all equipment that is a part of the pool circulating system.
iv SuperFlo Pump Installation and User ’ s Guide.
1 SuperFlo Pump Installation and User ’ s Guide Section 1 Introduction SuperFlo ™ High Performance Pump Overview The perfect choice for all types of pools, the SuperFlo was specifically designed to be your best choice for a variety of inground pools.
2 SuperFlo Pump Installation and User ’ s Guide General Features • Extremely quiet operation • Unionized fittings (1.5" and 2") for simple replacement • Cam and Ramp™ lid for easy .
3 SuperFlo Pump Installation and User ’ s Guide Section 2 Electrical Requirements This section describes how to wire the SuperFlo pump. Note: Before installing this product, read and follow all warning notices and instructions starting on page ii. Electrical Requirements and Wiring When pump is mounted permanently within 5 ft.
4 SuperFlo Pump Installation and User ’ s Guide Wiring Installation, cont.’d. 6. Permanently ground the motor using the green ground terminal located on the inside of the motor canopy or access plate, see Figure 1 . Use the correct wire size and type specified by National Electrical Code.
5 SuperFlo Pump Installation and User ’ s Guide Section 3 Maintenance This section describes how to maintain the SuperFlo pump. Cleaning the Pump Strainer Basket W ARNING — DO NOT open the strainer pot if pump fails to prime or if pump has been operating without water in the strainer pot.
6 SuperFlo Pump Installation and User ’ s Guide Cleaning the Pump Strainer Basket, cont’d. 9. Reinstall the lid by placing the clamp and the lid on the pot; see Figure 3 . a . Make sure the lid O-ring is properly placed. Seat the clamp and lid then turn clockwise until the handles are horizontal; see Figure 4 .
7 SuperFlo Pump Installation and User ’ s Guide Section 4 Servicing W ARNING — Risk of electrical shock or electrocution. This pool pump must be installed by a licensed or certified electrician or a qualified pool serviceman in accordance with the National Electrical Code and all applicable local codes and ordinances.
8 SuperFlo Pump Installation and User ’ s Guide Pump Disassembly , cont’d. h. To unscrew the impeller from the shaft, twist the impeller counter-clockwise. i . Remove the four bolts from the seal plate to the motor using a 3/8 inch wrench. j . Place the seal plate face down on a flat surface and tap out the ceramic seal.
9 SuperFlo Pump Installation and User ’ s Guide Section 5 Restart Instructions If the SuperFlo pump is installed below the water level of the pool, close return and suction lines prior to opening hair and lint pot on pump. Make sure to reopen valves prior to operating.
10 SuperFlo Pump Installation and User ’ s Guide Section 6 T roubleshooting Use the following troubleshooting information to resolve possible problems with your SuperFlo pump.
11 SuperFlo Pump Installation and User ’ s Guide Section 7 T echnical Data Illustrated Parts Item Part Description No. No. Item Part Description No. No. 1 075236 M O T OR S Q FL, 2 HPF , 2.5 A, 1 PHASE, 60 Hz, STD, 230V — (Almond) 1 075235 M O T OR S Q FL, 1.
12 SuperFlo Pump Installation and User ’ s Guide SAVE THESE INSTRUCTIONS Pump Curve PENT AIR POOL PRODUCTS, INC. PUMP PERFORMANCE CUR VE SUPERFLO ™ SERIES 0.00 10.00 20.00 30.00 40.00 50.00 60.00 70.00 80.00 90.00 100.00 0.0 20.0 40.0 60.0 80.0 100.
SF NOTES.
P/N 350096 Rev . B 4/28/06.
Een belangrijk punt na aankoop van elk apparaat Pentair Pump (of zelfs voordat je het koopt) is om de handleiding te lezen. Dit moeten wij doen vanwege een paar simpele redenen:
Als u nog geen Pentair Pump heb gekocht dan nu is een goed moment om kennis te maken met de basisgegevens van het product. Eerst kijk dan naar de eerste pagina\'s van de handleiding, die je hierboven vindt. Je moet daar de belangrijkste technische gegevens Pentair Pump vinden. Op dit manier kan je controleren of het apparaat aan jouw behoeften voldoet. Op de volgende pagina's van de handleiding Pentair Pump leer je over alle kenmerken van het product en krijg je informatie over de werking. De informatie die je over Pentair Pump krijgt, zal je zeker helpen om een besluit over de aankoop te nemen.
In een situatie waarin je al een beziter van Pentair Pump bent, maar toch heb je de instructies niet gelezen, moet je het doen voor de hierboven beschreven redenen. Je zult dan weten of je goed de alle beschikbare functies heb gebruikt, en of je fouten heb gemaakt die het leven van de Pentair Pump kunnen verkorten.
Maar de belangrijkste taak van de handleiding is om de gebruiker bij het oplossen van problemen te helpen met Pentair Pump . Bijna altijd, zal je daar het vinden Troubleshooting met de meest voorkomende storingen en defecten #MANUAl# samen met de instructies over hun opplosinge. Zelfs als je zelf niet kan om het probleem op te lossen, zal de instructie je de weg wijzen naar verdere andere procedure, bijv. door contact met de klantenservice of het dichtstbijzijnde servicecentrum.
