Gebruiksaanwijzing /service van het product 172787 van de fabrikant Poulan Pro
Ga naar pagina of 28
172787 Re v . 7 05.15.03 BY Printed in U .S.A. SELF-PR OPELLED R O T AR Y LA WN MO WER.
2 Saf ety Rules .......................................... 2-3 Assembly ...............................................4-8 Operation ............................................. 9-17 Maintenance ...................................... 18-21 Ser vice and Adjustments .
3 II. SLOPE OPERA TION Slopes are a major f actor related to slip and f all accidents which can result in se vere injury . All slopes require e xtra cau- tion. If you f eel uneasy on a slope , do not mow it. DO: • Mow across the f ace of slopes: ne v er up and down.
4 CA UTION: Do not oper ate this lawn mow er without the discharge guard or an entire approv ed gr ass catcher in place. These guards are f or your protection and are required by the American National Standards Institute and Consumer Prod- ucts Saf ety Com mis sion.
5 3 POSITION “QUICK” HANDLES • Raise low er handle section to operating position and squeeze the bottom ends of low er handle towards each other until the pin in handle can be inser ted into one of the three height adjustment holes.
6 Hinge brac ket F or med tabs Rear door Grass catcher frame HINGE BRA CKET MOUNTED DOOR PIV O T PIN MOUNTED AS SEM BLE GRASS CA TCHER (REAR DISCHARGE MO WERS ONL Y) IMPORT ANT: If y our model la wn mower is mulcher ready , the mulcher plate or plug must be remo ved bef ore using mower as a bagger .
7 Star t here Hem Upper tubular fr ame Upper tubular frame Vinyl bindings Low er frame CA UTION: Under normal usage, the catcher material is subject to de te ri o ra tion and wear and should, theref ore, be check ed frequently f or replacement.
8 SP ARK PLUG BOO T On some models a spark plug boot is pack ed loose in the par ts bag. If your model has the boot, install on spark plug wire and reconnect spark plug wire to spark plug. T O PRE P ARE BA TTER Y (ELECTRIC ST AR T MODELS ONL Y) NO TE: Y our battery must be charged bef ore you can star t y our lawn mo wer .
9 MODELS WITH ENGINE MOUNTED SPEED CONTROL The engine speed is controlled by a le ver located at the carburetor on the engine . HIGH or F AST position is for starting en gine, normal cutting and better grass bag ging. LO W or SLOW position is f or light cutting, trimming and fuel economy .
10 FOR MULCHING MO WERS ONL Y Most mulching mo wers are shipped ready to be used as a mulcher . “REAR DISCHARGE ONL Y” MO WERS Some models hav e a seperate mulcher plug, other models hav e the mulcher plug built into the rear door .
11 MULCHER PLUG BUIL T INT O REAR DOOR “SIDE DISCHARGE ONL Y” MO WERS MULCHER PLA TE TYPE T o conv er t to bagging or discharging, mulcher plate must be remo v ed from un- derside of lawn mo wer . • Remov e the f our (4) scre ws and lock nuts securing the mulcher plate to the mow er .
12 “COMBI-CUT” MO WERS Y our la wn mower w as shipped ready to be used as a mulcher . T o conv er t to bagging or discharging: REAR BA GGING • Open rear door and remov e mulcher plate. Store mulcher plate in a saf e place. • Y ou can no w install grass catcher .
13 Open mulcher door Discharge defl ector “MUL TI-CUT” MO WERS Y our la wn mower w as shipped ready to be used as a mulcher . Some models hav e a seperate mulcher plug, other models ha v e the mulcher plug b uilt into the rear door .
14 DRIVE CONTR OL FRONT WHEEL DRIVE • Self-propelling is controlled by holding the operator presence control bar do wn to the handle and pushing the drive control le ver f orward until it clicks; then releasing the le ver . • F orward motion will stop when the op- erator presence control bar is released.
15 T O OPERA TE DRIVE SYSTEM • With engine running, select ground speed by mo ving speed control le v er to desired position. • T o star t forw ard motion, pull dr iv e control bar back against handle . • T o stop forw ard motion, release drive control bar .
16 Recoil star ter handle (side mount type) Recoil star ter handle (center mount type) Operator presence control bar “V ARI-SPEED” ADJUSTMENT Ov er time, the drive control system ma y become “loose”, resulting in decreased speed. There is a thumbscre w on the un der side of the drive control housing to increase tension on the drive cab le.
17 MULCHING MO WING TIPS (MULCHING MO WERS ONL Y) IMPORT ANT : F or best perf or mance, keep mo wer housing free of b uilt-up grass and tr ash. See “CLEANING” in the Maintenance sec tion of this manual.
18 MAINTENANCE GENERAL RECOMMEND A TIONS The warr anty on this lawn mo wer does not cov er items that ha ve been subjected to op- erator ab use or negligence. T o receive full v alue from the war ranty , operator m ust main- tain mow er as instr ucted in this manual.
19 LA WN MO WER Alwa ys obser ve saf ety rules when perform- ing any main te nance. TIRES • K eep tires free of gasoline, oil, or insect control chemi cals which can har m rub- ber . • A v oid stumps, stones , deep ruts, shar p objects and other hazards that ma y cause tire damage.
20 REAR WHEEL GEAR DRIVE ONL Y : • If you remo ve the driv e pinions, wipe clean with dr y cloth. Re as sem ble dry . Do not lubricate. Do not use oil or grease. NO TE: The pinion gears, on both sides of the mow er , are the same , how ev er , they must be installed cor rect ly .
21 SER VICE AND ADJUSTMENTS CA UTION: Before perf orming any ser vice or adjustments: • Release operator presence control bar . • Make sure the b lade and all moving parts hav e com plete ly stopped. • Disconnect spark plug wire from spar k plug and place wire where it can not come in contact with spark plug.
22 3 POSITION “EURO” OR “EZ” The handle on your la wn mow er has three (3) height positions - adjust to height that suits you. • Remov e knob and carriage bolt on one side of the low er handle.
23 T O REMO VE / REPLA CE DRIVE BEL T FRONT WHEEL GEAR DRIVE • Remov e drive co v er . Remov e belt from gearcase pulley b y pushing down on pul- ley and rolling belt off it. • T ur n lawn mo wer on its side with air fi lter and carburetor up . • Remov e blade .
24 ENGINE CARBURET OR The carburetor has been preset at the f ac- tor y and ad just ment should not be neces- sar y . Howe v er , minor ad just ment may be required to compensate f or diff erences in fuel, temperature , altitude or load. • The air fi lter must be assemb led to the car bu re tor when r unning engine.
25 ST ORA GE Immediately prepare your la wn mo wer f or storage at the end of the season or if the unit will not be used f or 30 da ys or more. CA UTION: Nev er store the lawn mo wer with gaso line in the tank inside a build ing where fumes ma y reach an open fl ame or spark.
26 3 POSITION “EZ” 3 POSITION “QUICK” Handle ad just ment brac k et Knob Bolt • Use fresh fuel ne xt season. NO TE: Fuel stabilizer is an acceptable alter nativ e in min i miz ing the f or mation of fuel gum deposits during stor age. Add stabilizer to gasoline in fuel tank or stor age container .
27 Does not start 1. Dir ty air fi lter . 1. Clean/replace air fi lter . 2. Out of fuel. 2. Fill fuel tank. 3. Stale fuel. 3. Drain fuel tank and refi ll tank with fresh, clean gasoline. 4. W ater in fuel. 4. Drain fuel tank and refi ll tank with fresh, clean gasoline.
Hard to push 1. Grass is too high or wheel 1. Raise cutting height. height is too low . 2. Rear of lawn mo wer 2. Raise rear of lawn mo wer housing or cutting blade housing one (1) setting dragging in grass . higher . 3. Grass catcher too full. 3. Empty gr ass catcher .
Een belangrijk punt na aankoop van elk apparaat Poulan Pro 172787 (of zelfs voordat je het koopt) is om de handleiding te lezen. Dit moeten wij doen vanwege een paar simpele redenen:
Als u nog geen Poulan Pro 172787 heb gekocht dan nu is een goed moment om kennis te maken met de basisgegevens van het product. Eerst kijk dan naar de eerste pagina\'s van de handleiding, die je hierboven vindt. Je moet daar de belangrijkste technische gegevens Poulan Pro 172787 vinden. Op dit manier kan je controleren of het apparaat aan jouw behoeften voldoet. Op de volgende pagina's van de handleiding Poulan Pro 172787 leer je over alle kenmerken van het product en krijg je informatie over de werking. De informatie die je over Poulan Pro 172787 krijgt, zal je zeker helpen om een besluit over de aankoop te nemen.
In een situatie waarin je al een beziter van Poulan Pro 172787 bent, maar toch heb je de instructies niet gelezen, moet je het doen voor de hierboven beschreven redenen. Je zult dan weten of je goed de alle beschikbare functies heb gebruikt, en of je fouten heb gemaakt die het leven van de Poulan Pro 172787 kunnen verkorten.
Maar de belangrijkste taak van de handleiding is om de gebruiker bij het oplossen van problemen te helpen met Poulan Pro 172787 . Bijna altijd, zal je daar het vinden Troubleshooting met de meest voorkomende storingen en defecten #MANUAl# samen met de instructies over hun opplosinge. Zelfs als je zelf niet kan om het probleem op te lossen, zal de instructie je de weg wijzen naar verdere andere procedure, bijv. door contact met de klantenservice of het dichtstbijzijnde servicecentrum.
