Gebruiksaanwijzing /service van het product PO1538D van de fabrikant Poulan Pro
Ga naar pagina of 44
D OWNER'S MANUAL MODEL NO. PO1538D 15 HP 38 Inch Lawn Tractor Assembly • Operation • Maintenance • Service and Adjustments • Storage • Troubleshooting • Repair Parts For Parts and Sewice, contact our authorized distributor: call 1-800o849-1297 For Technical Assistance: call 1-800-829-5886 Poutan 187570 3.
_ SAFETY RULES ASAFE OPERATION PRACTICES FOR RIDE-ON MOWERS,_ ,MPO ANT: TR,S cuTr,N'G- ACH,NE,S CAPABLE OF AMPUTATING HANDS AND FEET AND TF, VVING OBJECTS FA,LURE TO OBSERVE THE FOLLOWING SAFETY INSTRUCTIONS COULD RESULT IN SERIOUS INJURY OR DEATH.
SAFETY RULES &Safe Operation Practices for Ride-On Mowers Be sure the area is clear of other people before mowing. Stop machine if anyone enters the area. Never carry passengers or children even with the blades off. Do not mow in reverse unless absolutely necessary.
PRODUCT SPECIFICATIONS GASOLINE CAPACITY 1.25 GALLONS AND TYPE: UNLEADED REGULAR OIL TYPE (API-SF-SJ): SAE 30 (above 32°F) SAE 5W-30 (below 32°F) OIL CAPACITY: W/Filter 3.5 Pints W/O Filter 3.0 Pints SPARK PLUG: CHAMPION RC12YC GAP: .030") GROUND SPEED (MPH): FORWARD: tst 1.
UNASSEMBLED PARTS Steering Wheel Steering Wheel Insert I i Steering Wheel Adapter Steering Extension Shaft (1) Large Flat Washer (1) Hex Bolt 1/4-28 x 1-1/4 Steering Boot (1) Locknut 1/2-20 ® (1) Loc.
ASSEMBLY Your new tractor has been assembled at the factory with exception of those parts left unassembted for shipping purposes. To ensure safe and proper operation of your tractor all parts and hardware you assemble must be tightened securely. Use the correct tools as necessary to insure proper tightness.
ASSEMBLY HOW TO SET UP YOUR TRACTOR INSTALL SEAT (See Fig. 2) Adjust seat before tightening adjustment bolt. • Remove adjustment belt, lock washer and flat washer securing seat to cardboard packing and set aside for assembly of seat to tractor. • Pivot seat upward and remove from the cardboard pack- ing.
ASSEMBLY CHECKTIRE PRESSURE ,/CHECKLIST The tires on your tractor were overinflated at the factory for shipping purposes. Correct tire pressure is important for best cutting performance. • Reduce tire pressure to PSI shown in "PRODUCT SPECIFICATIONS" section of this manual.
OPERATION These symbols may appear on your tractor or in literature supplied with the product. Learn and understand their meaning. R N H L I'-,I REVERSE NEUTRAL HIGH LOW CHOKE FAST SLOW IGNITION .
OPERATION KNOWYOUR TRACTOR READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTOR Compare the illustrations with your tractor to familiarize yourself with the locations of various controls and adjustments. Save this manual for future reference.
OPERATION [_ The operation of any tractor can result in foreign objects thrown into the eyes, which | 1 can result in severe eye damage. Always wear safety glasses or eye shields while op- I erating your tractor or performing any adjustments or repairs.
OPERATION TO OPERATE MOWER (See Fig. 6) Your tractor is equipped with an operator presence sensing switch. Any attempt by the operator to leave the seat with the engine running and the attachment clutch engaged will shut off the engine. Select desired height of cut.
OPERATION CAUTION: Alcohol blended fuels (called gasohol or using ethanol or methanol) can attract moisture which leads to separation and formation of acids during stor- age. Acidic gas can damage the fuel system of an engine while in storage. To avoid engine problems, the fuel system should be emptied before storage of 30 days or longer.
MAINTENANCE .A,NTENANCESC. OO.E F,LL,. OA S AS YOU COMPLETE REGULAR SERV,CE ERV,OE OATES Check Brake Operati°n _ _ Check Tire Pressure Check Operator Presence and T Interlock Systems Check for Loose .
MAINTENANCE TRACTOR Always observe safety rules when performing any main- tenance. BRAKE OPERATION If tractor requires more than six (6) feet stopping distance at high speed in highest gear, then brake must be adjusted. (See "TO ADJUST BRAKE" in the Service and Adjustments section of this manual).
MAINTENANCE BATTERY Your tractor has a battery charging system which is sufficient for normal use. However, periodic charging of the battery with an automotive charger wilt extend its life. • Keep battery and terminals clean. Keep battery bolts tight.
MAINTENANCE CLEAN AIR SCREEN Air screen must be kept free of dirt and chaff to prevent engine damage from overheating. Clean with a wire brush or compressed air to remove dirt and stubborn dried gum fibers. ENGINE COOLING FINS (See Fig. 12) Remove any dust, dirt or oil from engine cooling fins to prevent engine damage-from overheating.
MAINTENANCE MUFFLER Inspect and replace corroded muffler and spark arrester (if equipped) as it could create a fire hazard and/or dam- age. SPARK PLUGS Replace spark plugs at the beginning of each mowing season or after every 100 hours of operation, whichever occurs first.
SERVICE AND ADJUSTMENTS WARNING: TO AVOID SERIOUS INJURY, BEFORE PERFORMING ANY SERVICE OR ADJUST- MENTS: Depress clutcWbrake pedal fully and set parking brake. Place gearshift lever in neutral (N) position. Place attachment clutch in "DISENGAGED" position.
SERVICE AND ADJUSTMENTS TO LEVEL MOWER HOUSING Adjust the mower while tractor is parked on level ground or driveway, Make sure tires are properly inflated (See "PRODUCT SPECIFICATIONS" section of this manual). If tires are over or underinflated, you will not properly adjust your mower.
SERVICE AND ADJUSTMENTS MANDREL ENGINE PULLEY PULLEY RETAINER SPRING IDLER PULLEYS MANDREL PULLEY FIG. 20 TO CHECK AND ADJUST BRAKE (See Fig. 21) Your tractor is equipped with an adjustable brake system which is mounted on the right side of the transaxle.
SERVICE AND ADJUSTMENTS TO REMOVE WHEEL FOR REPAIRS (See Fig. 23) Block up axle securely. Remove axle cover, retaining ring and washers to allow wheel removal (rear wheel contains a square key - Do not lose). • Repair tire and reassemble. On rear wheels only: align grooves in rear wheel hub and axle.
SERVICE AND ADJUSTMENTS ENGINE TO REPLACE HEADLIGHT BULB • Raise hood. Pull bulb holder out of the hole in the backside of the grill. • Replace bulb in holder and push bulb holder securely back into the hole in the backside of the grill. • Close hood.
STORAGE ENGINE Immediately prepare your tractor for storage at the end of the season or if the tractor will not be used for 30 days or more. WARNING: Never store the tractor with gasoline in the tank inside a building where fumes may reach an open flame orspark.
TROUBLESHOOTING POINTS PROBLEM Will not start Hard to start Engine will not turn over Engine clicks but will not start Loss of power Excessive vibration CAUSE 1. Out of fuel. 2. Engine not'_3HOKED" properly. 3. Engine flooded. 4. Bad spark plug.
TROUBLESHOOTING POINTS CAUSE PROBLEM Engine continues to run when operator leaves seat with attachment clutch engaged Poor cut - uneven Mower blades will not rotate Poor grass discharge Headlight(s) not working (if so equipped) Battery will not charge Engine "backfires" when turning engine "OFF" 1.
SCHEMATIC TRACTOR -- MODEL NUMBER PO1538D RED BLACK AMMETER OPTIONAL) _ED FUSE WHITE )G A_( IGNITION SWITCH i t '© 0_,-- i I _LUTCH/ER_,K_E (PEDAL UP) BLACK BL_CK f MEI-ER '(OPTIONAL) BLACK.
REPAIR PARTS TRACTOR - - MODEL NUMBER PO1538D ELECTRICAL t i I i I 42 i 41 22 i 26 27 / / I I 48 I 27 / I I I F /I I / I II I I I I I I 161 ...... / / / / / / / // 28.
REPAIR PARTS TRACTOR -- MODEL NUMBER PO1538D ELECTRICAL KEY PART NO. NO. DESCRIPTION 1 163465 Battery 2 74760412 Bolt Hex Hd 1/4-20unc X 3/4 8 176689 Box Battery 16 176138 Switch Interlock 21 175685 H.
REPAIR PARTS TRACTOR - - MODEL NUMBER PO1538D CHASSIS 212 3O 29 J 26 31 2O8 26 25 '209 12 53 28 55 54 57 10 35 205 34 38 O5 208 chassis-pl.lt 34 3O.
REPAIR PARTS TRACTOR - - MODEL NUMBER PO1538D CHASSIS KEY PART NO. NO. DESCRIPTION 1 174620 2 176554 3 17060612 5 155272 6 174643X014 8 155138 9 168347X011 10 72140608 11 174996 12 145660 13 172105X01.
REPAIR PARTS TRACTOR - - MODEL NUMBER PO1538D DRIVE 57 16 / I 52 30 250 I 113 51 77 6 32 250 25 15 / 26 26 5 18 35 36 37 120...-- "_ 34 29 i 26 27 drive-saddle_25 32.
REPAIR PARTS TRACTOR - - MODEL NUMBER PO1538D DRIVE KEY PART KEY PART NO. NO. DESCRIPTION NO. NO. 2 146682 3 123666X 4 12000028 5 121520X 6 17060512 7 162240 8 131679 10 76020416 11 105701X 12 1915121.
REPAIR PARTS TRACTOR - - MODEL NUMBER PO1538D STEERING J _39 L i 36 51 54 71 17 47 67 57 67 43 34.
REPAIR PARTS TRACTOR - - MODEL NUMBER PO1538D STEERING KEY PART NO. NO. DESCRIPTION 1 140044X428 2 175131 3 169840 4 169839 5 6266H 6 121748X 7 19272016 8 12000029 9 3366R 10 175121 11 10040600 12 739.
REPAIR PARTS TRACTOR ENGINE 2_ -- MODEL NUMBER PO1538D 3 81 13 4 78, 31 40 33 29 OPTIONAL EQUIPMENT I Spark Arrester 14 23 I 78 KEY PART NO. NO. DESCRIPTION 1 2 3 170551 Control TtVch Flag 17720408 Screw HexThd Cut 1/4-20 x 1/2 .
REPAIR PARTS TRACTOR - - MODEL NUMBER PO1538D SEAT KEY NO. 1 2 3 4 5 6 7 8 9 10 12 13 J I I I I I i -.----- 16 I 5 23 17 12 PART NO. 127426X 140551 71110616 19131610 145006 73800600 124181X 17000616 19131614 182493 121246X 121248X DESCRIPTION Seat Bracket Seat Pivot Bolt Hex 3/8 - 16 X 1 Washer 13/32 X 1 Xl0Ga.
REPAIR PARTS TRACTOR DECALS 8 7 12 - - MODEL NUMBER PO1538D 2 14 6 8 15 4 3 KEY PART NO. NO. DESCRIPTION 1 2 3 4 6 7 8 9 181251 187580 184768 170563 157140 158168 172200 158166 17 Decal, Clutch/Brake Eng/Fr Decal, Replacement Decal, Engine HP Decal Warning Decal, Fender Danger English Decal Ins Str Wh Decal, Fender 5 Sp.
REPAIR PARTS MOWER LIFT TRACTOR - - MODEL NUMBER PO1538D 5 6 13 2 13 31 32 19 20 KEY PART NO. NO. 1 159460 2 159471 3 105767X 4 12000002 5 19211621 6 120183X 7 109413X 8 124526X 11 139865 12 139866 13.
REPAIR PARTS TRACTOR - - MODEL NUMBER PO1538D MOWER DECK 11 21 68 9 29 27 8 4O.
REPAIR PARTS TRACTOR -- MODEL NUMBER PO1538D MOWER DECK KEY PART KEY PART NO. NO. DESCRIPTION NO. NO. 1 170280 Mower Housing Assembly 67 106932X 2 72140506 Bolt Carriage 5/16-18 x 3/4 68 144200 3 138017 Bracket Asm Ft.
LIMITED WARRANTY The Manufacturer warrants to the original consumer purchaser that this product as manufactured is free from defects in materi- als and workmanship.
SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION 4_ ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL 15 DEGREES MAX. WARNING: To avoid serious injury, operate your tractor up and down the face of slopes, never across the face. Do not mow slopes greater than 15 degrees.
Poulan.
Een belangrijk punt na aankoop van elk apparaat Poulan Pro PO1538D (of zelfs voordat je het koopt) is om de handleiding te lezen. Dit moeten wij doen vanwege een paar simpele redenen:
Als u nog geen Poulan Pro PO1538D heb gekocht dan nu is een goed moment om kennis te maken met de basisgegevens van het product. Eerst kijk dan naar de eerste pagina\'s van de handleiding, die je hierboven vindt. Je moet daar de belangrijkste technische gegevens Poulan Pro PO1538D vinden. Op dit manier kan je controleren of het apparaat aan jouw behoeften voldoet. Op de volgende pagina's van de handleiding Poulan Pro PO1538D leer je over alle kenmerken van het product en krijg je informatie over de werking. De informatie die je over Poulan Pro PO1538D krijgt, zal je zeker helpen om een besluit over de aankoop te nemen.
In een situatie waarin je al een beziter van Poulan Pro PO1538D bent, maar toch heb je de instructies niet gelezen, moet je het doen voor de hierboven beschreven redenen. Je zult dan weten of je goed de alle beschikbare functies heb gebruikt, en of je fouten heb gemaakt die het leven van de Poulan Pro PO1538D kunnen verkorten.
Maar de belangrijkste taak van de handleiding is om de gebruiker bij het oplossen van problemen te helpen met Poulan Pro PO1538D . Bijna altijd, zal je daar het vinden Troubleshooting met de meest voorkomende storingen en defecten #MANUAl# samen met de instructies over hun opplosinge. Zelfs als je zelf niet kan om het probleem op te lossen, zal de instructie je de weg wijzen naar verdere andere procedure, bijv. door contact met de klantenservice of het dichtstbijzijnde servicecentrum.
