Gebruiksaanwijzing /service van het product Quality Refrigeration van de fabrikant Traulsen
Ga naar pagina of 16
This T raulsen unit is built to our highest quality standards. We build our refrigerators, freezers and heated cabinets this way as a matter of pride. This philosophy has made T raulsen the leader in commercial refrig- eration since 1938.
T ABLE OF CONTENTS The serial tag is a permanently affixed sticker on which is recorded vital electrical and refrigeration data about your T raulsen product, as well as the model and serial number .
III. c - INST ALLING LEGS OR CASTERS: 6” high stainless steel legs are supplied standard for all T raulsen reach-in and pass-thru units. Casters in lieu of legs are available as an optional accessory for the same models. These are shipped from the factory packed inside a cardboard box which is strapped to one of the shelves.
III. f - INST ALLING THE CONDENSA TE EV AP (cont’d): holes on the exterior bottom towards the rear of the cabinet. Then, using the four (4) screws provided, at- tach the mounting rails to the cabinet bottom (the end flange is to be up and be facing towards the cabinet rear).
IV . a - CLEANING THE CONDENSER (cont’d): two screws located on both sides at the bottom of the louver assembly (see figure 6). Once the screws are removed, the panel can be pivoted upwards allowing full access to the front facing condenser (see figure 7 ) .
V . a - ADJUSTING THE SHEL VES: For shelves mounted on pins, first select the desired location and remove the white plastic covers in the interior back and sides by rotating them counter-clock- wise. Remove the shelf pins by rotating them counter- clockwise.
-6- VII. SPECIAL TY PRODUCTS - PROOFER/PROOFER RET ARDER MODELS VII. a - INST ALLA TION: MECHANICAL CONNECTION: For plumbing, connect water supply to inlet strainer as marked on top of cabi- net. This connection should be made with a 3/8” male NPT connector .
-7- VII. SPECIAL TY PRODUCTS - PROOFER/PROOFER RET ARDER MODELS (cont’d) VII. c - OPERA TING THE DIAL HUMIDIST A T (cont’d): When the desired temperature and humidity settings are achieved, the white mode indicating lights will go OFF and you are now ready to proof your product.
-8- VII. SPECIAL TY PRODUCTS - PROOFER/PROOFER RET ARDER MODELS (cont’d) VII. d - RET ARDER OPERA TION (cont’d): MANUAL OPERA TION - The T raulsen proofer retarder can also be used in either PROOF or RET ARD mode, regardless of what the 24-hour timer is set for .
-9- VIII. SPECIAL TY PRODUCTS - EVEN-THA W MODELS VIII. a - APPLICA TION OVER VIEW : The Even-Thaw is designed to thaw product at safe temperatures. By keeping the cabinet temperature from rising above 40 o F , the Even-Thaw inputs small amounts of heat while moving large volumes of air around the product.
-10- IX. SPECIAL TY PRODUCTS - FISH FILE MODELS IX. a - FISH FILE APPLICA TION: T raulsen fish file models are specifically designed for the storage of fresh fish or poultry in a moist refriger- ated environment, packed in crushed ice, thereby pre- venting dehydration and bacteria growth.
-1 1- X. SPECIAL TY PRODUCTS - BLAST FREEZER MODELS X. a - BLAST FREEZER APPLICA TION: The roll-in blast freezer models were specifically de- signed for batch processing, where quick freezing is required to help prolong product shelf life.
XI. TROUBLE SHOOTING GUIDE FIND YOUR PROBLEM HERE REMEDY 1. Condensing unit fails to start. a. Check if cord & plug has been disconnected. 2. Condensing unit operates for a. Are doors closing properly? prolonged periods or continuously . b. Dirty condenser or filter .
-13- XII. W ARRANTY INFORMA TION ST ANDARD DOMESTIC W ARRANTY TRAULSEN & CO., INC. warrants new equipment to the original purchaser , when installed within the United States against defective material and workmanship for one (1) year from the date of original installation, not to exceed 15 months from date of shipment.
XIII. INDEX -14- A Auto Function 7 B Back Flow Prevention Device 6 Batch 1 1 Blast Chiller 1 1 Blast Freeze Mode 1 1 Blast Freezer 1 1 Blower ON/OFF Switch 8 Blower Power Switch 8 C Cleaning 5, 6 Cast.
T raulsen & Co., Inc. 4401 Blue Mound Road Fort Worth, TX 76106 Phone: (800) 825-8220 Fax-Svce: (817) 740-6757 Website: www .traulsen.com HOURS OF OPERA TION: Monday thru Friday 7:30 am - 4:30 pm .
Een belangrijk punt na aankoop van elk apparaat Traulsen Traulsen Quality Refrigeration (of zelfs voordat je het koopt) is om de handleiding te lezen. Dit moeten wij doen vanwege een paar simpele redenen:
Als u nog geen Traulsen Traulsen Quality Refrigeration heb gekocht dan nu is een goed moment om kennis te maken met de basisgegevens van het product. Eerst kijk dan naar de eerste pagina\'s van de handleiding, die je hierboven vindt. Je moet daar de belangrijkste technische gegevens Traulsen Traulsen Quality Refrigeration vinden. Op dit manier kan je controleren of het apparaat aan jouw behoeften voldoet. Op de volgende pagina's van de handleiding Traulsen Traulsen Quality Refrigeration leer je over alle kenmerken van het product en krijg je informatie over de werking. De informatie die je over Traulsen Traulsen Quality Refrigeration krijgt, zal je zeker helpen om een besluit over de aankoop te nemen.
In een situatie waarin je al een beziter van Traulsen Traulsen Quality Refrigeration bent, maar toch heb je de instructies niet gelezen, moet je het doen voor de hierboven beschreven redenen. Je zult dan weten of je goed de alle beschikbare functies heb gebruikt, en of je fouten heb gemaakt die het leven van de Traulsen Traulsen Quality Refrigeration kunnen verkorten.
Maar de belangrijkste taak van de handleiding is om de gebruiker bij het oplossen van problemen te helpen met Traulsen Traulsen Quality Refrigeration . Bijna altijd, zal je daar het vinden Troubleshooting met de meest voorkomende storingen en defecten #MANUAl# samen met de instructies over hun opplosinge. Zelfs als je zelf niet kan om het probleem op te lossen, zal de instructie je de weg wijzen naar verdere andere procedure, bijv. door contact met de klantenservice of het dichtstbijzijnde servicecentrum.
