Gebruiksaanwijzing /service van het product 5660(I) van de fabrikant United States Stove
Ga naar pagina of 40
1 Report #: 215 ‐ S ‐ 32 ‐ 4 and 215 ‐ S ‐ 33 ‐ 4 Installation and Operating Manual Models 5660( I ) Safety Notice Please read this en tire manual before installation and use of this pellet fuel ‐ bu rning room heater.
2 TABLE OF CONTENTS Topic Page(s) Introduction 3 Safety Information .
3 Introduction The entire family of United States Stove Company thanks you for pur chasing your new pellet burning room hea ter.
4 SAFETY INFORMATION Be sure to read the entire owner’s manual prior to installing and operating this Pellet heater.
5 SAFETY INFORMATION ‐ continued Keep foreign objects out of the hopper. Contact your local building officials to obtain .
6 SPECIFICATIONS Heating Specifications: Burn Rate: *43,900 btu’s per hour or 5.1 lbs. of fuel per hour Hopper Capacity: 55 lbs. *Dependent upon quality and heating value of pellet fuel.
7 DIMENSIONS ‐ continued The minimum installation dimensions, of the insert opening, are: 32” (813mm) wide x 22 ‐ 3/4” (578mm) high x 12 ‐ 1/4” (311mm) deep.
8 OPERATING INSTRUCTIONS Check and Fill the Fuel Hopper with Pellets: This Pellet Stove is available as a freestanding unit or as a fireplace insert.
9 OPERATING INSTRUCTIONS ‐ continued When the pellets have ignited and flame has been established, the start ‐ up cycle will end; this procedur e takes between 8 and 12 minutes.
10 OPERATING INSTRUCTIONS ‐ continued Control Board Functions: MODE Button: The MODE button allows you to switch operating mode on your Pellet Stove Room Heater.
11 OPERATING INSTRUCTIONS ‐ continued the Auger feed rate will help keep the flames from extinguishi ng on the minimum heat level setting.
12 THERMOSTAT INSTALLATION Optional thermostats are available for use with your pellet stove. A thermostat can help you maintain a constant room temperature.
13 USA 6” CANADA 8” USA 6” CANADA 8” CLEARANCES TO COMBUSTIBLES INSTALL ALL VENTS AT CLEARANCES SPECIFIED BY THE VENT MANUFACT URER! .
14 INSTALLING YOUR ROOM HEATER You have already made the important decision of choosing your U.
15 INSTALLING YOUR ROOM HEATER ‐ continued HORIZONTAL EXHAUST VENT INSTALLATION 1. Locate your pellet stove in a location .
16 INSTALLING YOUR ROOM HEATER ‐ continued HORIZONTAL EXHAUST VENT INSTALLATION .
17 INSTALLING YOUR ROOM HEATER ‐ continued FREESTANDING INTERIOR VERTICAL INSTALLATION 1. Locate your Pellet Stove Room Heater .
18 INSTALLING YOUR ROOM HEATER ‐ continued FREESTANDING EXTERIOR VERTICAL INSTALLATION 1. Locate your Pellet Stove Room Heater i.
19 .
20 INSTALLING YOUR ROOM HEATER ‐ continued SELKIRK DIRECT ‐ TEMP VENT SYSTEM FOR PELLET STOVE HEATERS Images courtesy of Selk.
21 INSTALLING YOUR ROOM HEATER ‐ continued SELKIRK DIRECT ‐ TEMP VENT SYSTEM FOR PELLET STOVE HEATERS Images courtesy of Selk.
22 INSTALLING YOUR ROOM HEATER ‐ continued SELKIRK DIRECT ‐ TEMP VENT SYSTEM FOR PELLET STOVE HEATERS Images courtesy of S.
23 INSTALLING YOUR ROOM HEATER ‐ continued SELKIRK DIRECT ‐ TEMP VENT SYSTEM FOR PELLET STOVE HEATERS Images courtesy of .
24 MOBILE HOME INSTALLATION Mobile home installation shoul d be done in accordance with the Manufactured Home and Safety Stan dard (HUD), CFR 3280, Part 24.
25 INSERT PELLET STOVE INSTALLATION U.S. Stove Pellet Burning Room Heaters are also available as an insert into existing masonry of factory ‐ built fireplaces.
26 INSERT PELLET STOVE INSTALLATION ‐ continued Step 3: Sh roud Top: Facing the back of the unit take the top shroud side piece and fasten, as shown, with 4 screws provided.
27 INSERT PELLET STOVE INSTALLATION ‐ continued Minimum Clearance to Combustibles and Floor Protection .
28 Installation into a Masonry Fireplace: 1. Your chimney must be inspected by a certified chimney sweep or installer to determine its structural condition.
29 VENT TERMINATION LOCATIONS Figure 22 .
30 MAINTENANCE FAILURE TO CLEAN AND MAINTAIN THIS UNIT AS INDICATED MAY RESULT IN POOR PERFORMANCE AND HAZARDOUS SITUATIONS. CLEAN THE HEATER FREQUENTLY AS ACCUMULATION OF SOOT, CREOSOTE OR FLYASH MAY OCCUR.
31 MAINTENANCE ‐ continued Ash Removal ‐ Freestanding Unit: If left neglected ashes will eventually fill the ash pan. Remove the ashes per iodically to avoid unnecessary ash build up.
32 MAINTENANCE ‐ continued Cleaning Heat Exchanger Tubes – Your Pellet Stove Room Heat er is designed with a built in heat exc hanger tube cleaner.
33 MAINTENANCE ‐ continued Chimney/Vent System Cleaning: 1. Soot Formation – When wood products are burned slowly they produce tar and other organic vapors which combine with expelled moisture to form soot.
34 TROUBLE SHOOTING See figure 26, page 31, for component locations . The heater will not light: Check that the heater is plugged in and that the wall outlet has power.
35 TROUBLE SHOOTING ‐ continued The auger motor does not function normally. If the auger shaft does not turn but the motors armature tries to spin then this is a sign your auger is jammed.
36 TROUBLE SHOOTING ‐ continued Door Glass has soot buildup at a fast rate and flame is lazy with black tips.
37 WIRING DIAGRAM .
38 REPLACEMENT PARTS Contact your authorized U.S. Stove Pellet Burning Room Heater dealer to obtain any of these parts.
39 LIMITED WARRANTY United States Stove Company warrants to the original purchaser its Pellet Heaters against premature failure of any component du e to workmanship, quality, or materials as follows: TIME PERIOD: Firebox / Firepot ................
40 .
Een belangrijk punt na aankoop van elk apparaat United States Stove 5660(I) (of zelfs voordat je het koopt) is om de handleiding te lezen. Dit moeten wij doen vanwege een paar simpele redenen:
Als u nog geen United States Stove 5660(I) heb gekocht dan nu is een goed moment om kennis te maken met de basisgegevens van het product. Eerst kijk dan naar de eerste pagina\'s van de handleiding, die je hierboven vindt. Je moet daar de belangrijkste technische gegevens United States Stove 5660(I) vinden. Op dit manier kan je controleren of het apparaat aan jouw behoeften voldoet. Op de volgende pagina's van de handleiding United States Stove 5660(I) leer je over alle kenmerken van het product en krijg je informatie over de werking. De informatie die je over United States Stove 5660(I) krijgt, zal je zeker helpen om een besluit over de aankoop te nemen.
In een situatie waarin je al een beziter van United States Stove 5660(I) bent, maar toch heb je de instructies niet gelezen, moet je het doen voor de hierboven beschreven redenen. Je zult dan weten of je goed de alle beschikbare functies heb gebruikt, en of je fouten heb gemaakt die het leven van de United States Stove 5660(I) kunnen verkorten.
Maar de belangrijkste taak van de handleiding is om de gebruiker bij het oplossen van problemen te helpen met United States Stove 5660(I) . Bijna altijd, zal je daar het vinden Troubleshooting met de meest voorkomende storingen en defecten #MANUAl# samen met de instructies over hun opplosinge. Zelfs als je zelf niet kan om het probleem op te lossen, zal de instructie je de weg wijzen naar verdere andere procedure, bijv. door contact met de klantenservice of het dichtstbijzijnde servicecentrum.
