Gebruiksaanwijzing /service van het product ML-136057 van de fabrikant Vulcan-Hart
Ga naar pagina of 20
INST ALLA TION & OPERA TION MANUAL For additional information on Vulcan-Hart or to locate an authorized parts and service provider in your area, visit our website at www .vulcanhart.com C24GA SERIES GAS CONVECTION STEAMERS VULCAN-HART DIVISION OF ITW FOOD EQUIPMENT GROUP, LLC WWW.
— 2 — C24GA SERIES GAS CONVECTION STEAMERS IMPORT ANT FOR YOUR SAFETY THIS MANUAL HAS BEEN PREP ARED FOR PERSONNEL QUALIFIED T O INST ALL GAS EQUIPMENT , WHO SHOULD PERFORM THE INITIAL FIELD ST ART -UP AND ADJUSTMENTS OF THE EQUIPMENT COVERED BY THIS MANUAL.
— 3 — C24GA SERIES GAS CONVECTION STEAMERS INTRODUCTION GENERAL Vulcan convection steamers are produced with quality workmanship and material. Proper installation, usage and maintenance will result in many years of satisfactory performance.
— 4 — C24GA SERIES GAS CONVECTION STEAMERS In Canada: 1. Local codes. 2. CAN/CSA-B149.1 Natural Gas Installation (latest edition). 3. CAN/CSA-B149.2 Propane Installation Code (latest edition), available from the Canadian Gas Association, 178 Rexdale Blvd.
— 5 — C24GA SERIES GAS CONVECTION STEAMERS PLUMBING CONNECTIONS Plumbing connections must comply with applicable sanitary, safety and plumbing codes. Water Requirements Proper water quality can improve the taste of the food prepared in the steamer, reduce liming in the steam generator and extend equipment life.
— 6 — C24GA SERIES GAS CONVECTION STEAMERS instructions provided with the filter system. At the time of installation you must register your steamer at www.
— 7 — C24GA SERIES GAS CONVECTION STEAMERS Air ˚ Pressure ˚ Adjust ˚ Screw On ˚ Side ˚ of ˚ Drip ˚ Cover Figure 1 The proper sizing and installation of the gas connection is important for the machine to operate within its design specifications.
— 8 — C24GA SERIES GAS CONVECTION STEAMERS FLEXIBLE GAS CONNECTORS BTU/hr . FLOW CAP ACITY 1, 2 LENGTH 3 LENGTH 3 End Fittings - (1) Quick Disconnect End Fittings - Both Threaded & (1) Threade.
— 9 — C24GA SERIES GAS CONVECTION STEAMERS FLUE GAS EXHAUST DO NOT obstruct the flow of flue gases from the flue located on the rear of the steamer. It is recommended that the flue gases be vented to the outside of the building through a ventilation system installed by qualified personnel.
— 10 — C24GA SERIES GAS CONVECTION STEAMERS ELECTRICAL CONNECTION Appliances equipped with a flexible electric supply cord are pro- vided with a three-prong grounding plug. It is imperative that this plug be con- nected into a properly grounded three- prong receptacle.
— 11 — C24GA SERIES GAS CONVECTION STEAMERS The steamer and its parts are hot. Use care when operating, clean- ing or servicing the steamer. The cooking compartment contains live steam. Stay clear when opening each door. LIGHTING AND SHUTDOWN INSTRUCTIONS Lighting 1 .
— 12 — C24GA SERIES GAS CONVECTION STEAMERS Refer to Steam Cooking with Vulcan Kettles and Steamers for suggested cooking times. Also refer to the Suggested Cooking Guideline in this manual. Size, weight, pan loading and product quality will affect cooking times and should be adjusted to your own requirements.
— 13 — C24GA SERIES GAS CONVECTION STEAMERS CLEANING Disconnect the electrical power to the machine and follow lockout / tagout procedures before cleaning. Cooking Compartment Drains Keep compartment drains running freely. Inspect compartment drains daily for blockage.
— 14 — C24GA SERIES GAS CONVECTION STEAMERS LEAVE COMPARTMENT DOORS OPEN Leave the compartment doors slightly open when the steamer is not in use. When the compartment is idle, never latch the door and apply pressure to the door gasket. Leaving the gasket under pressure can cause permanent deformation and reduce gasket life.
— 15 — C24GA SERIES GAS CONVECTION STEAMERS The steamer and its parts are hot. Use care when operating, clean- ing or servicing the steamer. Water Treatment System A water treatment system is recommended for steamers. Refer to your supplier’s manual for normal maintenance procedures for proper scale-free operation recommendations.
— 16 — C24GA SERIES GAS CONVECTION STEAMERS COOKING CHART The following table lists suggested cooking times and weights. These times, which will vary depending on initial product temperature, size, shape, etc., are approximate and should be adjusted to suit your operation.
— 17 — C24GA SERIES GAS CONVECTION STEAMERS PRODUCT Clams Frozen Fresh King Crab Frozen Claws Legs Lobster T ail, Frozen Lobster , Live, 10" – 12" Salmon Fillets, Frozen, 8 Oz.
— 18 — C24GA SERIES GAS CONVECTION STEAMERS PRODUCT Carrots Baby Whole, Frozen Crinkle Cut, Frozen Sliced, Fresh Cauliflower , Flowerettes Frozen Fresh Celery , 1" Diagonal Cut Corn Y ellow W.
— 19 — C24GA SERIES GAS CONVECTION STEAMERS TROUBLESHOOTING SYMPTOMS Unit not steaming Door leaks W ater accumulates in compartment W ater not being supplied to generator S team is exiting from un.
— 20 — C24GA SERIES GAS CONVECTION STEAMERS F-35423 Rev B. (10-07) PRINTED IN U.S.A ..
Een belangrijk punt na aankoop van elk apparaat Vulcan-Hart ML-136057 (of zelfs voordat je het koopt) is om de handleiding te lezen. Dit moeten wij doen vanwege een paar simpele redenen:
Als u nog geen Vulcan-Hart ML-136057 heb gekocht dan nu is een goed moment om kennis te maken met de basisgegevens van het product. Eerst kijk dan naar de eerste pagina\'s van de handleiding, die je hierboven vindt. Je moet daar de belangrijkste technische gegevens Vulcan-Hart ML-136057 vinden. Op dit manier kan je controleren of het apparaat aan jouw behoeften voldoet. Op de volgende pagina's van de handleiding Vulcan-Hart ML-136057 leer je over alle kenmerken van het product en krijg je informatie over de werking. De informatie die je over Vulcan-Hart ML-136057 krijgt, zal je zeker helpen om een besluit over de aankoop te nemen.
In een situatie waarin je al een beziter van Vulcan-Hart ML-136057 bent, maar toch heb je de instructies niet gelezen, moet je het doen voor de hierboven beschreven redenen. Je zult dan weten of je goed de alle beschikbare functies heb gebruikt, en of je fouten heb gemaakt die het leven van de Vulcan-Hart ML-136057 kunnen verkorten.
Maar de belangrijkste taak van de handleiding is om de gebruiker bij het oplossen van problemen te helpen met Vulcan-Hart ML-136057 . Bijna altijd, zal je daar het vinden Troubleshooting met de meest voorkomende storingen en defecten #MANUAl# samen met de instructies over hun opplosinge. Zelfs als je zelf niet kan om het probleem op te lossen, zal de instructie je de weg wijzen naar verdere andere procedure, bijv. door contact met de klantenservice of het dichtstbijzijnde servicecentrum.
