Gebruiksaanwijzing /service van het product E63-NG1 van de fabrikant Waterford Appliances
Ga naar pagina of 24
FIREPLACE PRODUCTS INTERNATIONAL LTD. 6988 Venture St., Delta, BC Canada, V4G 1H4 WARNING: If the information in these instructions are not followed exactly , a fire or explosion may result causing property damage , personal injury or loss of life.
2 Waterford E63-1 EMERALD Freestanding Gas Stove To the New Owner: Congratulations! You are the owner of a state-of-the-art EMERALD Gas Stove by Waterford Irish Stoves. The Waterford Gas Series of hand crafted appliances has been designed to provide you with all the warmth and charm of a woodstove, at the flick of a switch.
Waterford E63-1 EMERALD Freestanding Gas Stove 3 T ABLE OF CONTENTS Page Page Operating Instructions Operating Instructions ........................................................ 1 5 Lighting Instructions ............................................
4 Waterford E63-1 EMERALD Freestanding Gas Stove This is a copy of the label that accompanies each EMERALD Freestanding Gas Stove. We have printed a copy of the contents here for your review. The safety label is located on the inside of the drop down pedestal door.
Waterford E63-1 EMERALD Freestanding Gas Stove 5 Copy of the Safety Label for the E63-LP1 Propane SAFETY LABEL For the State of Massachusetts, installation and repair must be done by a plumber or gasfitter licensed in the Commonwealth of Massachusetts.
6 Waterford E63-1 EMERALD Freestanding Gas Stove 12) Under no circumstances should this appli- ance be modified. Parts that have to be removed for servicing should be replaced prior to operating this appliance. 13) Installation and any repairs to this appliance should be done by a qualified service per- son.
Waterford E63-1 EMERALD Freestanding Gas Stove 7 OPTIONAL F AN INST ALLA TION Fan Kit Contains: Qty. Description 1 Fan Speed Controller with nut, and knob. 1 Fan Assembly c/w green wire attached 1 power cord 1 Plastic locking grommet 1) Remove the Top Control Panel Assembly by removing the three screws.
8 Waterford E63-1 EMERALD Freestanding Gas Stove Vent Terminations Installation into Existing Woodstove Flue System 1) Clean existing Chimney system. 2) Run an approved 4" flex liner or "B" vent into existing chimney. DRAFT HOOD This heater has a draft hood built in.
Waterford E63-1 EMERALD Freestanding Gas Stove 9 INST ALLA TION System Data - E63-1 (with 38,000 Btu) For 0 to 2000 feet altitude Burner Inlet Orifice Sizes: Natural Gas Propane Burner #32 #50 *Above 2000 ft. see National Fuel Code Orifice Chart. Max.
10 Waterford E63-1 EMERALD Freestanding Gas Stove INST ALLA TION 2) Loosen the "IN" (# 7) and/or "OUT" (# 6) pressure tap(s), turning counterclockwise with a 1/8" wide flat screwdriver. 3) Attach manometer to "IN" and/or "OUT" pressure tap(s) using a 5/16" ID hose.
Waterford E63-1 EMERALD Freestanding Gas Stove 11 Reduction Kit to Lower Btu Rating for Emerald E65-1 Gas S tove Natural Gas - Kit #: 260-920 Propane - Kit # 260-922 T HIS CONVERSION MUST BE DONE BY A QUALIFIED GAS FITTER IF IN DOUBT DO NOT DO THIS CONVERSION !! 4 ) Carefully remove the logs, embers and rock- wool.
12 Waterford E63-1 EMERALD Freestanding Gas Stove OPTIONAL DOOR GRILL INST ALLA TION Door Grill Kit Contains: Qty. Description 1 Front Door Grill 4 Screws 4 Grill Clips 1) Open the front door. Open the right side door and there is a cutout in the heat shield through which can be seen a wing nut threaded on to a stud attached to the front door.
Waterford E63-1 EMERALD Freestanding Gas Stove 13 OPTIONAL REMOTE CONTROL Use the Waterford Remote Control Kit approved for this unit. Use of other systems may void your warranty. The remote control kit comes with a hand held transmitter, a receiver and a wall mounting plate.
14 Waterford E63-1 EMERALD Freestanding Gas Stove WIRING DIAGRAM INST ALLA TION FINAL CHECK Before leaving this unit with the customer, the installer must ensure that the appliance is firing correctly. This includes: 1) Clocking the appliance to ensure the cor- rect firing rate (rate noted on label) at 15 minutes.
Waterford E63-1 EMERALD Freestanding Gas Stove 15 OPERA TING INSTRUCTIONS 3) Wait five minutes to allow gas, that may have accumulated in the main burner com- partment, to escape. If you smell gas, follow the instructions on the front of this manual. If you don't smell gas continue on to the next step.
16 Waterford E63-1 EMERALD Freestanding Gas Stove NORMAL OPERA TING SOUNDS OF GAS APPLIANCES It is possible that you will hear some sounds from your gas appliance. This is perfectly normal due to the fact that there are various gauges and types of steel used within your appliance.
Waterford E63-1 EMERALD Freestanding Gas Stove 17 LOG REPLACEMENT The unit should never be used with broken logs. Turn off the gas valve and allow the unit to cool before opening door to carefully remove the logs. The pilot light generates enough heat to burn someone.
18 Waterford E63-1 EMERALD Freestanding Gas Stove MAINTENANCE REMOVING VAL VE If your valve requires maintenance or replace- ment, use the following instructions: Note: Always close off the gas supply before removing the valve. 1) If optional fan is installed, disconnect pow- er source to stove.
Waterford E63-1 EMERALD Freestanding Gas Stove 19 MAINTENANCE 10) Remove all 8 screws holding the burner tray assembly in place. 11) Carefully lift the burner tray assembly out. 12) To replace the burner tray assembly, simply reverse these instructions.
20 Waterford E63-1 EMERALD Freestanding Gas Stove PARTS LIST MAIN ASSEMBL Y 1 ) W400141** Emerald Right Door 2 ) 904-258 Door Magnet 3 ) 948-134 Door Stop 4 ) 44351 Black Butt Hinge 5 ) W842001** Emer.
Waterford E63-1 EMERALD Freestanding Gas Stove 21 BURNER & LOG ASSEMBL Y 52) 910-190 Piezo Igniter with Nut 56) 908-672 Control Panel Decal 57) 490-061 Switch Plate 251-524/P Valve Assembly S.I.T. - Natural Gas 251-526/P Valve Assembly S.I.T. - Propane 261-969 Propane Conversion Kit 60) 910-378 Valve S.
22 Waterford E63-1 EMERALD Freestanding Gas Stove _____________________________________________________________________________________ ____________________________________________________________ ___.
Waterford E63-1 EMERALD Freestanding Gas Stove 23 W ARRANTY Waterford Fireplace Products are designed with reliability and simplicity in mind. In addition, our internal Quality Assurance Team carefully inspects each unit thoroughly before it leaves our facility.
Installer: Please complete the following information Dealer Name & Address: ______________________________________________ __________________________________________________________________ Instal.
Een belangrijk punt na aankoop van elk apparaat Waterford Appliances E63-NG1 (of zelfs voordat je het koopt) is om de handleiding te lezen. Dit moeten wij doen vanwege een paar simpele redenen:
Als u nog geen Waterford Appliances E63-NG1 heb gekocht dan nu is een goed moment om kennis te maken met de basisgegevens van het product. Eerst kijk dan naar de eerste pagina\'s van de handleiding, die je hierboven vindt. Je moet daar de belangrijkste technische gegevens Waterford Appliances E63-NG1 vinden. Op dit manier kan je controleren of het apparaat aan jouw behoeften voldoet. Op de volgende pagina's van de handleiding Waterford Appliances E63-NG1 leer je over alle kenmerken van het product en krijg je informatie over de werking. De informatie die je over Waterford Appliances E63-NG1 krijgt, zal je zeker helpen om een besluit over de aankoop te nemen.
In een situatie waarin je al een beziter van Waterford Appliances E63-NG1 bent, maar toch heb je de instructies niet gelezen, moet je het doen voor de hierboven beschreven redenen. Je zult dan weten of je goed de alle beschikbare functies heb gebruikt, en of je fouten heb gemaakt die het leven van de Waterford Appliances E63-NG1 kunnen verkorten.
Maar de belangrijkste taak van de handleiding is om de gebruiker bij het oplossen van problemen te helpen met Waterford Appliances E63-NG1 . Bijna altijd, zal je daar het vinden Troubleshooting met de meest voorkomende storingen en defecten #MANUAl# samen met de instructies over hun opplosinge. Zelfs als je zelf niet kan om het probleem op te lossen, zal de instructie je de weg wijzen naar verdere andere procedure, bijv. door contact met de klantenservice of het dichtstbijzijnde servicecentrum.
