Gebruiksaanwijzing /service van het product GWH-635-ES van de fabrikant Bosch Appliances
Ga naar pagina of 36
.
6 720 607 072 2 Index Index 1 Warn ing 2 2 Appli ance det ails 4 2.1 Featu res 4 2.2 GWH-6 35-ES S pecific ations (Te chnical data) 4 2.3 Dimens ions an d Minimu m installa tion cle arance s 6 2.4 Genera l rules to follow for safe o peration 7 2.5 Proper location for instal ling your heater 7 2.
6 720 607 072 Warning 3 What to do if you smell g as • Close gas valve . Open windows. • Do not try to l ight any appliance . • Do n ot t ouch any e lectrical switch; do not use any phone in your bui lding. • Immediately ca ll yo ur gas supplier fro m a ne ighbor’s phone.
6 720 607 072 4 Appliance de tails 2 Applia nce de tails 2.1 Features Parts • Touch Pad interf ace control • High po wer pre- mix comp act bu rner wi th low Nox emissions • Modulating Gas Valv e with constant gas: air ratio control • Modulating water valve for improved comfort and temperat ure control.
6 720 607 072 Appliance det ails 5 Combustio n • NOx ≤ 55 ppm • CO ≤ 250 ppm • CO 2 level set from fa ctory, see chapte r 9. Dimensio ns • Depth (in): 8 ½” (220 mm) • Width (in): 15 ¾ ” (400 mm) • Height (in): 23 ½ ” (600 mm) • Weight: 47 po unds (21 kg).
6 720 607 072 6 Appliance de tails 2.3 Dim ensions and Minimum installation clearances Fig. 4 Dimensions 1 Cover 2 On/Off s witch 3 Reset button 4 LCD d isplay 5 Program button 6 Tempe rature buttons Fig.
6 720 607 072 Appliance det ails 7 2.4 General rules to follow fo r safe operation B 1. You should follow these instructions when you install your heater. In the United States: T he installation must con form with l ocal codes or, in the absence of local codes, the National Fuel Gas Code ANSI Z223.
6 720 607 072 8 Appliance de tails 2.6 Clearances The GWH-6 35-ES is design certifie d for installation on a c ombustible wa ll ( see 2.7 Mou nting installatio n) provided the floor cover ing b elow t he heater is noncombustibl e.
6 720 607 072 Appliance det ails 9 construct ion, infiltration air is normally ad equate to provide air fo r combustion. • Appliances lo cated in confine d spaces: The con fined s pace m ust be pro vided wit h two permanent o penings, one com mencing within 1 2 inches (304.
6 720 607 072 10 Appliance de tails The applianc e should be located as close to the poin t of termination as p ossible. The maxim um vent length is 26 feet (8 m) with on e 90 de gree elbow .
6 720 607 072 Appliance det ails 11 Note: red uce 2½ ft for each 90° elbow used after the first one, r educe 1 ¼ ft for ea ch 45° elbow. Vent Safe ty System The GWH-635-ES will sh ut dow n if inadequate exhaust venting i s detected or a lack of combus tion air is provided to the uni t; see tro ubleshooting section on page 2 4.
6 720 607 072 12 Appliance de tails 2.9.1 Venting o ptions Installing this water heater as a room sealed (TWIN PIPE SYSTEM) is the recomme nded method. Contac t BBTNA or dealer for a vailable ve nt termin ation kits and vent materia ls for this water he ater.
6 720 607 072 Appliance det ails 13 Recommen ded exhaust v ent terminator position Fig. 16 * Subj ect to loc al codes and an ticipate d snow lev el ** Oth er equipm ent that operat es with a m echan ical air i nlet may r equire greater dis tances, r eferenc e manu facturer's instruct ions Ref.
6 720 607 072 14 Appliance de tails Supporting t he exhaust v ent system Fig. 17 Horizontal side w all venting in stallation (combustion air piping not be ing shown) Fig.
6 720 607 072 Appliance det ails 15 Fig. 20 Vertical vent ing ins tallation - Masonry Chimney (c ombustion air piping not being shown) A conden sate drain tu be must be attached to the exhaust c ollar o f the heater for all vent type applicati ons, see page, s ee page 11.
6 720 607 072 16 Appliance de tails FOR NA TU R AL GAS Maximum Cap acity of pipe in Cu bic Feet of Gas pe r Hour for Ga s Pressure of 0.5 Psig or less and a Pressure drop of 0.3 in Wate r Column (0.75 mbar).(Based on a 0.60 Specific Gravity Gas) B tu numbers give n in thousands.
6 720 607 072 Appliance det ails 17 2.11 Gas line sizing B It is strongly recomm ended that th e Nat ural G as pip e be Black Iron p ipe the entire distance from the outside met er to th e inlet of the gas co nnection. ¾” Black Iron pip e up to 20 fee t (6 .
6 720 607 072 18 Appliance de tails HIGH ALTIT UDE OPERATI ON 2.13 W ater connections When faci ng the hea ter, the ¾ ” cold wat er inlet i s on the bottom right a nd the hot wate r outlet is on the bottom left. Install the heater c entrally i n the b uilding i f possible and make hot water piping r uns as short as possible.
6 720 607 072 Appliance det ails 19 2.14 Electrical connections The GWH -635-ES requires a n electrical po wer supply from a 120VAC 60Hz circuit and must be properly grounded. A means for swi tching off the 120VA C p ower supply must be prov ided. The he ater is w ired as shown in the wiring diagram (chapter 6, Fig.
6 720 607 072 20 Appliance de tails When the heater is i n ope ration you will hear i ts pow er vent f an a nd burne r opera ting. Up on turni ng of f the hot water flow t he power v ent fan will c ontinue to op erate for up to 60 s econds to exhaust a ll flue gases.
6 720 607 072 Operation in structions 21 3 Opera tion in structi ons Fig. 27 1 On/O ff switch 2 Reset button 3 Prog ram Key 4 Incre asing tem perature selector 5 Decre asing tem peratur e selec tor 6 LCD d isplay 3.1 Power On B T o s tart t he a ppliance switch the butto n to position ( I ).
6 720 607 072 22 Operation i nstructions Setting the water temperatu re The desired temperature of the hot water ca n be adjusted on the front control panel of the he ater.
6 720 607 072 Operation in structions 23 3.3 Use of remote control accessory Fig. 31 Remote control The wireless re mote control a ccessory and the temperature selector b uttons on the front o f the wa ter heater op erate identic ally. Contact your dist ributor or BBTNA to order if the remote control accessory is preferred.
6 720 607 072 24 Maintenance and service 4 Mainte nance and ser vice The unit should be checked once a year by a gas technician. If re pairs are needed, t he re pairs should be done by a ga s technician To remove front cover B Remove plastic dec als on f ront p anel ( Page 5, Fig.
6 720 607 072 Troubleshooti ng 25 • Cold w ater i s mix ing wi th th e hot water outlet (crossover) Test by following 4th bullet under BURNER S DO NOT IGNITE WHEN HOT WATER IS TURNED ON.
6 720 607 072 26 Troubleshoot ing Display Caus e Solution E9 Temperature limiter opened circuit (overheat). Trips at 220F (104C). Check connections.* Check heat exchanger condition.* EA No ioniz ation during sa fety time (safety time out). Note: appliance makes 3 ignition attempts before entering error mode “EA”.
6 720 607 072 Electrical d iagram 27 6 Elect rical dia gram Fig. 37 Electrical sch eme 1 Intlet w ater temp eratur e sensor 2 Ionizat ion sens or 3 Water flow sen sor 4 Over h eat prote ction 5 Tempe .
6 720 607 072 28 GWH-635-E S Functional sc heme 7 GWH -635-ES Functio nal sch eme Fig. 38 Functional schem e.
6 720 607 072 Interior compon ents diag ram and parts lis t 29 8 Inter ior com ponents diagra m and p arts lis t 8.1 Interior components Fig. 39 Components 1 Cover 2 On/O ff switch 3 Reset button 4 LC.
6 720 607 072 30 Interior co mponents diag ram and parts li st 8.2 Co mponents diagram Fig. 41 Components Dia gram.
6 720 607 072 Interior compon ents diag ram and parts lis t 31 8.3 Parts list Item Description Referenc e 1 Front cover 8 7 05 42 1 83 7 2 Shield 8 705 506 66 1 3 Heat exc hanger 8 705 406 285 4 Heat .
6 720 607 072 32 Special adj ustment for mea suring and ad justing CO2 l evels 9 Special adjus tment for mea suring and adjus ting CO 2 levels The CO 2 c an only be adju sted by a certified gas technician w ith a calibrate d CO 2 analyzer.
6 720 607 072 Special ad justment for measuring and a djusting CO2 levels 33 D. Returni ng to Service: 1. Return slot ted cover to origi nal position. 2. Reinstall Torx cover. 3. Remove CO 2 analyzer probe an d reinstall flathea d screw in exha ust collar.
6 720 607 072 34 Protecting t he environment 10 Prot ecting the enviro nmen t Packing The packing b ox m ay be fully recycled as confirm ed by the recycling symbol . Components Many parts i n the h eater can be fully recycled in the e nd of the product life.
6 720 607 072 Fifteen Y ear Limited Warra nty 35 11 Fiftee n Yea r Limited Warr anty General BOSCH PRO w ater h eaters are warranted by t he Manufactu rer (B OSCH) through BBT North America.
Replac ement P arts a vailable fro m: VU L C AN O T ermod omésticos S.A . Estrada de Caci a 38 0 1 - 856 Aveiro - P O RTUG AL Recycled pa per © 200 5 B BT NO RTH AM E R I CA , W aitsfield , V T all rights re serve d BBT NORTH AMERICA Bosch Group Bosch Water Heating 340 Mad River Park Waitsfield, VT 05673 Phone 866-330-2730 Fax (802) 426-6924 www.
Een belangrijk punt na aankoop van elk apparaat Bosch Appliances GWH-635-ES (of zelfs voordat je het koopt) is om de handleiding te lezen. Dit moeten wij doen vanwege een paar simpele redenen:
Als u nog geen Bosch Appliances GWH-635-ES heb gekocht dan nu is een goed moment om kennis te maken met de basisgegevens van het product. Eerst kijk dan naar de eerste pagina\'s van de handleiding, die je hierboven vindt. Je moet daar de belangrijkste technische gegevens Bosch Appliances GWH-635-ES vinden. Op dit manier kan je controleren of het apparaat aan jouw behoeften voldoet. Op de volgende pagina's van de handleiding Bosch Appliances GWH-635-ES leer je over alle kenmerken van het product en krijg je informatie over de werking. De informatie die je over Bosch Appliances GWH-635-ES krijgt, zal je zeker helpen om een besluit over de aankoop te nemen.
In een situatie waarin je al een beziter van Bosch Appliances GWH-635-ES bent, maar toch heb je de instructies niet gelezen, moet je het doen voor de hierboven beschreven redenen. Je zult dan weten of je goed de alle beschikbare functies heb gebruikt, en of je fouten heb gemaakt die het leven van de Bosch Appliances GWH-635-ES kunnen verkorten.
Maar de belangrijkste taak van de handleiding is om de gebruiker bij het oplossen van problemen te helpen met Bosch Appliances GWH-635-ES . Bijna altijd, zal je daar het vinden Troubleshooting met de meest voorkomende storingen en defecten #MANUAl# samen met de instructies over hun opplosinge. Zelfs als je zelf niet kan om het probleem op te lossen, zal de instructie je de weg wijzen naar verdere andere procedure, bijv. door contact met de klantenservice of het dichtstbijzijnde servicecentrum.
