Gebruiksaanwijzing /service van het product BBQ10900 van de fabrikant Cal Flame
Ga naar pagina of 32
.
Copyright 2010 LMS, Inc. All rights re- served. Duplication without writ ten consent is strictly prohibited. Cal Flame ® is a registered trademark. Due to continuous improvement programs, all models, operation, and/or specications are subject to change without prior notice.
Safety Instructions 1 Hibachi Grill L TR50001096, Rev . A w ww . c a l a m e b b q . c o m Placement and Location The Cal Flame hibachi grill is designed for outdoor use only. Never locate this appliance in an enclosed room, under a sealed • overhead structure, or in any type of enclosed area such as a ga- rage, shed, or breez eway .
2 Safety Instructions Hibachi Grill L TR50001096, Rev . A w ww . c a l a m e b b q . c o m Before you start cooking, clean the entire grill thoroughly wi th hot, • soapy water . This is necessary to r emove r esidual solvents, oil and grease used in the manufacturing process.
Safety Instructions 3 Hibachi Grill L TR50001096, Rev . A w ww . c a l a m e b b q . c o m Do not heat any unopened glass or metal container of food on • the hibachi grill. Pressure ma y build up and cause the container to burst, possibly resulting in serious personal injury or damage to the grill.
4 Installation / Assembl y Hibachi Grill L TR50001096, Rev . A w ww . c a l a m e b b q . c o m Most cities and counties require permits for exterior construction.
Installation / Assembl y 5 Hibachi Grill L TR50001096, Rev . A w ww . c a l a m e b b q . c o m Cabinet Cut-out Dimensions Y our Cal Flame hibachi grill is designed for easy installation into a non-combustible enclosure. The supporting deck or counter must be at and level.
6 Installation / Assembl y Hibachi Grill L TR50001096, Rev . A w ww . c a l a m e b b q . c o m LP Gas Tank Requirements For plumbed-in LP instal lation, use a con vertible regulator and set it for LP gas. Maximum line pressur e for plumbed-in propane is 14” WC (3.
Installation / Assembl y 7 Hibachi Grill L TR50001096, Rev . A w ww . c a l a m e b b q . c o m The maximum fuel capacity is 20 lbs. of propane, or 5 gallons. Full cyl- inder weight should be approximately 38 lbs. (43.7 lbs. nominal water capacity .
8 Installation / Assembl y Hibachi Grill L TR50001096, Rev . A w ww . c a l a m e b b q . c o m Natural Gas Requirements Always check the r ating plate to make sure the gas supply y ou are hooking up to is the gas type the grill is manuf actured for .
Installation / Assembl y 9 Hibachi Grill L TR50001096, Rev . A w ww . c a l a m e b b q . c o m Leak Testing Procedure Perf orm a leak test at least once a year whether the gas supply cylinder has been disconnected or not.
10 Installation / Assembl y Hibachi Grill L TR50001096, Rev . A w ww . c a l a m e b b q . c o m Installing the Grill in a Barbecue Island You may need a second person to help you to avoid damag- ing the grill or your barbecue island.
Installation / Assembl y 11 Hibachi Grill L TR50001096, Rev . A w ww . c a l a m e b b q . c o m Griddle Placement If you need to remov e the griddle for cleaning or maintenance, you need to replace it as shown below . The griddle is positioned at a slight incline to allow grease to run off to the drain.
12 Using Y our Grill Hibachi Grill L TR50001096, Rev . A w ww . c a l a m e b b q . c o m Read all instructions before you operate your hibachi grill. W e recommend you wash your entire grill with soap and water prior to lighting it for the rst time.
Using Y our Grill 13 Hibachi Grill L TR50001096, Rev . A w ww . c a l a m e b b q . c o m Basic Grill Operation Before lighting, make sure al l burner controls are off . Do not attempt to light the burners if the smell of gas is present. Check the connection with a soap and water solution after attaching the hose.
14 Using Y our Grill Hibachi Grill L TR50001096, Rev . A w ww . c a l a m e b b q . c o m Electronically Lighting the Grill Lift the cover . 1. K eep your face as f ar awa y from the burners as possible. 2. Rapidly rotate the burner knob counter clockwise past the light 3.
Using Y our Grill 15 Hibachi Grill L TR50001096, Rev . A w ww . c a l a m e b b q . c o m Manually Lighting the Grill WARNING: Do not use standard matches or cigarette lighters to perform match lighting pr ocedures. Serious burns can occur and lighters can explode.
16 Cleaning and Maintenance Hibachi Grill L TR50001096, Rev . A w ww . c a l a m e b b q . c o m Cleaning and Maintenance T o ensure safe and proper maintenance, we recommend you follow these directions caref ully . Clean internal parts of the grill regularly as determined by the amount of use and foods cook ed.
Cleaning and Maintenance 17 Hibachi Grill L TR50001096, Rev . A w ww . c a l a m e b b q . c o m Cleaning Products and Materials Avoid using these common cleaning products and materials – they will damage the surface of your stainless steel.
18 Cleaning and Maintenance Hibachi Grill L TR50001096, Rev . A w ww . c a l a m e b b q . c o m Clean 1. Thoroughly clean stains, food, and grime using a sponge or damp cloth with warm water and a mild dish soap. Use Fantastik or F or- mula 409 to remove hea vier soil.
Cleaning and Maintenance 19 Hibachi Grill L TR50001096, Rev . A w ww . c a l a m e b b q . c o m Rust Removal It is a common misconception that stainless steel does not rust. It does not stain, corrode, or rust as easily as ordinary steel (it stains less ), but it is not stain-proof .
20 Cleaning and Maintenance Hibachi Grill L TR50001096, Rev . A w ww . c a l a m e b b q . c o m Use a wire brush to clean the outer surface of each burner to remove food residue and dirt. Clean any clogged ports with a stiff wire such as an opened paper clip.
Appendix 21 Hibachi Grill L TR50001096, Rev . A w ww . c a l a m e b b q . c o m Appendix Removing and Replacing Burners Disconnect or shut off the gas line connect to the grill. W ait until 1. the grill and burners are cool. Remov e the cover and 2.
22 Appendix Hibachi Grill L TR50001096, Rev . A w ww . c a l a m e b b q . c o m Troubleshooting Problem: Smell of gas is present Solution: Check for loose connections in the gas line. P erform a leak test following the pr ocedure described in this man - ual.
Appendix 23 Hibachi Grill L TR50001096, Rev . A w ww . c a l a m e b b q . c o m Problem: Plugged orice Solution: Unplug the orice as follows: Remov e griddle and grease tr ay .
24 Appendix Hibachi Grill L TR50001096, Rev . A w ww . c a l a m e b b q . c o m Problem: Yellow Flame Solution: Once the entire burner is operating, check the ame color to be sure that it is mostly blue. Some yellow at the tips may be present due to impurities in the fuel.
Appendix 25 Hibachi Grill L TR50001096, Rev . A w ww . c a l a m e b b q . c o m All Cal Flame grills are manufactured as standard liquid propane (LP) grills and can be con verted to burn natural gas (NG). There are two steps required to conv ert a grill from LP to NG.
26 Appendix Hibachi Grill L TR50001096, Rev . A w ww . c a l a m e b b q . c o m Step 1: Switching the regulator behind the grill The regulator in the image below has been removed from a grill to illus- trate this procedure. Remov e the LP gas line.
Appendix 27 Hibachi Grill L TR50001096, Rev . A w ww . c a l a m e b b q . c o m Step 2: Changing the burner orices Remov e the griddle from the 1. grill. Remov e the cotter pins from 2. the end of the burners. The cotter pins are accessible from underneath the grill in the back in the accessory cabinet.
28 Appendix Hibachi Grill L TR50001096, Rev . A w ww . c a l a m e b b q . c o m Warranty LMS warrants the hibachi grill and associated hardw are from defects in material and workmanship f or a period of one year from the original date of purchase.
Appendix 29 Hibachi Grill L TR50001096, Rev . A w ww . c a l a m e b b q . c o m Warranty Limitations This warr anty is v oid if the hibachi grill has been subject to negligence, alteration, misuse, repairs, dings, dents, scratches, or incorrect and / or prohibited applications, as specied in the owner ’ s manual.
Customer Service For customer service, contact the authorized selling dealer immediately . If you need additional information or assistance, please contact the LMS Customer Relations Department at 1462 E. Ninth St. , Pomona CA 91766 or call (800) 225-7727 .
Een belangrijk punt na aankoop van elk apparaat Cal Flame BBQ10900 (of zelfs voordat je het koopt) is om de handleiding te lezen. Dit moeten wij doen vanwege een paar simpele redenen:
Als u nog geen Cal Flame BBQ10900 heb gekocht dan nu is een goed moment om kennis te maken met de basisgegevens van het product. Eerst kijk dan naar de eerste pagina\'s van de handleiding, die je hierboven vindt. Je moet daar de belangrijkste technische gegevens Cal Flame BBQ10900 vinden. Op dit manier kan je controleren of het apparaat aan jouw behoeften voldoet. Op de volgende pagina's van de handleiding Cal Flame BBQ10900 leer je over alle kenmerken van het product en krijg je informatie over de werking. De informatie die je over Cal Flame BBQ10900 krijgt, zal je zeker helpen om een besluit over de aankoop te nemen.
In een situatie waarin je al een beziter van Cal Flame BBQ10900 bent, maar toch heb je de instructies niet gelezen, moet je het doen voor de hierboven beschreven redenen. Je zult dan weten of je goed de alle beschikbare functies heb gebruikt, en of je fouten heb gemaakt die het leven van de Cal Flame BBQ10900 kunnen verkorten.
Maar de belangrijkste taak van de handleiding is om de gebruiker bij het oplossen van problemen te helpen met Cal Flame BBQ10900 . Bijna altijd, zal je daar het vinden Troubleshooting met de meest voorkomende storingen en defecten #MANUAl# samen met de instructies over hun opplosinge. Zelfs als je zelf niet kan om het probleem op te lossen, zal de instructie je de weg wijzen naar verdere andere procedure, bijv. door contact met de klantenservice of het dichtstbijzijnde servicecentrum.
