Gebruiksaanwijzing /service van het product BBQ11955P van de fabrikant Cal Flame
Ga naar pagina of 36
.
Copyright 2011 LMS, Inc. All rights re- served. Duplication without writ ten consent is strictly prohibited. Cal Flame ® is a registered trademark. Due to continuous improvement programs, all models, operation, and/or specications are subject to change without prior notice.
Safety Instructions 1 Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m Placement and Location The Cal Flame Power Burner is designed for outdoor use only. Never locate this appliance in an enclosed room, under a sealed • overhead structure, or in any type of enclosed area such as a ga- rage, shed, or breez eway .
2 Safety Instructions Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m Operation Do not use the Power Burner f or oth • er than its intended use. Never use the Power Burner if the drip pan is not in place. The drip • pan should be pushed all the w ay in under the P ower Burner .
Safety Instructions 3 Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m garments while using your Power Burner . F abric may ignite and result in personal injury . When using the P ower Burner , do not touch the grate or immediate • surroundings as these areas become extremely hot and can cause burns.
4 Installation / Assembl y Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m Most cities and counties require permits for exterior construction.
Installation / Assembl y 5 Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m Cabinet Cut-out Dimensions Y our Cal Flame P ower Burner is designed for easy installation into a non-combustible enclosure. The supporting deck or counter must be at and level.
6 Installation / Assembl y Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m LP Gas Tank Requirements For plumbed-in LP installation, use a convertible regulator and set it for LP gas. Maximum line pressure for plumbed-in propane is 14” WC (3.
Installation / Assembl y 7 Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m The maximum fuel capacity is 20 lbs. of propane, or 5 gallons. Full cyl- inder weight should be approximately 38 lbs. (43.7 lbs. nominal water capacity .
8 Installation / Assembl y Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m Natural Gas Requirements Always check the rating plate to make sure the gas supply you are hooking up to is the gas type the P ower Burner is manufactured f or .
Installation / Assembl y 9 Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m Leak Testing Procedure Perf orm a leak test at least once a year whether the gas supply cylinder has been disconnected or not.
10 Installation / Assembl y Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m Placing the Power Burner in a Built-in Enclosure You may need a second person to help you to avoid damag- ing the Power Burner or your enclosure.
Using Y our Grill 11 Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m Read all instructions before you operate your Power Burner. W e recommend you w ash the Power Burner thoroughly with soap and water prior to lighting it for the rst time.
12 Using Y our Grill Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m Basic Operation Before lighting, make sure all burner controls are off . Do not at- tempt to light the burners if the smell of gas is present. Check the connection with a soap and w ater solution after attaching the hose.
Using Y our Grill 13 Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m Lighting the Power Burner Electronic Ignition Lift the cover . 1. K eep your face as f ar awa y from the burners as possible. 2. T urn the burner knob counter clockwise past the light position 3.
14 Using Y our Grill Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m Power Burner Lid W e strongly recommend you remove the lid for your P ower Burner before each use. The P ower Burner lid is attached to the unit by two hinges on each side.
Using Y our Grill 15 Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m Using the Wok Ring If you have a wok, you can use it wi th the P ower B urner .
16 Cleaning and Maintenance Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m Cleaning and Maintenance Removing and Replacing Burners The burner has three pieces plus a wok ring. If y ou remo ve the burner for cleaning, make sure to clean each piece and replace them in proper order .
Cleaning and Maintenance 17 Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m Replacement Set the burner body in place, 1. making sure the stud in prop- erly seated and the burner body is at and level. Set the burner ring on the 2.
18 Cleaning and Maintenance Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m T o ensure safe and proper maintenance, we recommend you follow these directions caref ully . Clean internal parts of the Power Burner regularly as determined by the amount of use and foods cooked.
Cleaning and Maintenance 19 Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m Caution Do not use WD-40 or Sheila Shine near food or on food preparation surfaces as it is a health hazard. This includes the interior of the Power Burner and the gr ate.
20 Cleaning and Maintenance Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m Clean 1. Thoroughly clean stains, food, and grime using a sponge or damp cloth with warm water and a mild dish soap. Use Fantastik or F or- mula 409 to remove hea vier soil.
Cleaning and Maintenance 21 Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m Rust Removal It is a common misconception that stainless steel does not rust. It does not stain, corrode, or rust as easily as ordinary steel (it stains less ), but it is not stain-proof .
22 Cleaning and Maintenance Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m from the P ower Burner by carefully lifting each burner up and away from the gas v alve orice. Use a wire brush to clean the outer surface of each burner to remove food residue and dirt.
Appendix 23 Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m Troubleshooting Problem: Smell of gas is present Solution: Check for loose connections in the gas line. Perform a leak test following the procedure on page 9. Problem: Burner does not ignite Solution: Use the following procedure with the gure below .
24 Appendix Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m Problem: Plugged orice Solution: Unplug the orice as follows: Remov e grate and gr ease tray . • Remov e the burner ring and the outer burner . • Carefully lift the center burner up and away from • the gas orice.
Appendix 25 Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m Problem: Misalignment of Igniter on Burner Solution: Check for proper position of the electrode tip , which • should be pointing forward towar ds the front of the burner and free of grease to allow proper sparking.
26 Appendix Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m All Cal Flame gas appliances are manufactur ed to operate with standard liquid propane (LP and can be converted to burn natural gas (NG). There are two steps required to con vert from LP to NG.
Appendix 27 Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m Step 1: Switching the regulator The regulator in the image below has been removed to illustrate this pro- cedure. Remov e the LP gas line. 1. Remov e the cap tting from the 2.
28 Appendix Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m Step 2: Changing the burner orices Remov e the grate, burner ring, 1. and burner from the Power Burn- er . Locate the gas orices. They will 2. be directly behind the gas v alves.
Appendix 29 Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m Apply a small amount of pipe compound to the orice threads. 4. Screw in the orice until it is nger tight. 5. Tighten the orice with the 6mm wrench. 6. Repeat the abo ve steps for the remaining burners.
30 Appendix Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m Limited Warranty LMS w arrants the P ower Burner and associated hardwar e fr om defects in material and workmanship f or a period of one year from the original date of purchase.
Appendix 31 Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m This warranty is void if the barbecue gril l has been subject to negligence, alteration, misuse, repairs, dings, dents, scratches, or incorrect and / or prohibited applications, as specied in the owner’s manual.
32 Appendix Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m Legal Remedies This limited warranty gives you specic legal rights. Y ou may have other rights, which may v ary from state to state. Customer Service For customer service, contact the authorized selling dealer immediately .
Appendix 33 Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m.
L TR50001100, Rev . A 4/26/11 California Proposition 65 Warning: Chemicals known to the State of California to cause cancer , birth defects or other reproductive harm are found in and/or created by the combustion of natural gas, propane, butane and other fuels.
Een belangrijk punt na aankoop van elk apparaat Cal Flame BBQ11955P (of zelfs voordat je het koopt) is om de handleiding te lezen. Dit moeten wij doen vanwege een paar simpele redenen:
Als u nog geen Cal Flame BBQ11955P heb gekocht dan nu is een goed moment om kennis te maken met de basisgegevens van het product. Eerst kijk dan naar de eerste pagina\'s van de handleiding, die je hierboven vindt. Je moet daar de belangrijkste technische gegevens Cal Flame BBQ11955P vinden. Op dit manier kan je controleren of het apparaat aan jouw behoeften voldoet. Op de volgende pagina's van de handleiding Cal Flame BBQ11955P leer je over alle kenmerken van het product en krijg je informatie over de werking. De informatie die je over Cal Flame BBQ11955P krijgt, zal je zeker helpen om een besluit over de aankoop te nemen.
In een situatie waarin je al een beziter van Cal Flame BBQ11955P bent, maar toch heb je de instructies niet gelezen, moet je het doen voor de hierboven beschreven redenen. Je zult dan weten of je goed de alle beschikbare functies heb gebruikt, en of je fouten heb gemaakt die het leven van de Cal Flame BBQ11955P kunnen verkorten.
Maar de belangrijkste taak van de handleiding is om de gebruiker bij het oplossen van problemen te helpen met Cal Flame BBQ11955P . Bijna altijd, zal je daar het vinden Troubleshooting met de meest voorkomende storingen en defecten #MANUAl# samen met de instructies over hun opplosinge. Zelfs als je zelf niet kan om het probleem op te lossen, zal de instructie je de weg wijzen naar verdere andere procedure, bijv. door contact met de klantenservice of het dichtstbijzijnde servicecentrum.
