Gebruiksaanwijzing /service van het product (V)T32EN-A Series, (V)T32EP-A Series van de fabrikant Desa
Ga naar pagina of 38
NA TURAL GAS “TUDOR” MODELS (V)T32EN-A SERIES PR OP ANE/LP GAS “TUDOR” MODELS (V)T32EP-A SERIES *Aftermarket: Completion of sale, not for purpose of resale, from the manufacturer . DIRECT -VENT FIREPLA CE O WNER’S OPERA TION AND INST ALLA TION MANU AL FOR YOUR SAFETY WHA T TO DO IF YOU SMELL GAS • Do not try to light any appliance.
2 www .desatech.com 1 16647-01A Propane/LP and Natural Gas: Propane/LP and natural gases are odorless. An odor-making agent is added to the gas. The odor helps you detect a gas leak. However, the odor added to the gas can fade. Gas may be present even though no odor exists.
3 3 www .desatech.com 1 16647-01A 5. This fireplace reaches high temperatures. Keep children and adults away from hot surfaces to avoid burns or clothing igni- tion. Fire place will rem ain hot for a time afte r sh utdown . Allo w surfaces to cool before touching.
4 www .desatech.com 1 16647-01A PR ODUCT FEATURES These are a few facts that can help you understand and enjoy your direct-vent fireplace: • The venting system may be routed to the outside of your home in several ways. It may vent through the roof (vertical) or it may vent to an outside/ exte rior wa ll (horizo ntal ).
5 5 www .desatech.com 1 16647-01A CLEARANCES Mi nim um cle ara nce s to co mbu sti ble s f or th e fire pla ce ar e as fo ll ows : *Back and sides 0"/mm Perpendicular walls 6" (152 mm) Floo.
6 www .desatech.com 1 16647-01A Fixed Closed O p en ab l e Fixed Closed Openable V V V V V V V V X X V X G G J F B B K N H I A N E L D B M A C B V V A G G B TERMINA TION CAP AIR SUPPL Y INLET GAS METER RESTRICTED AREA (TERMINA TION PROHIBITED) A = clearance above grade, veranda, porch, deck, or balcony [*12 inches (30.
7 7 www .desatech.com 1 16647-01A VEN TI NG INST ALLA TION INSTR UCTIONS NOTICE: Read these instructions completely before attempting installation. These models are tested and approved for use with DESA (direct- vent) pipe components and terminations.
8 www .desatech.com 1 16647-01A (Framing Detail) 10 3 / 4 " (273 mm) 10 3 / 4 " Inside Framing (273 mm) 10 3 / 4 " (273 mm) 8 1 / 2 " (216 mm) V ent Opening Combustible W all V e n.
9 9 www .desatech.com 1 16647-01A 7. Combustible Exterior Wall Only: Slide the wall firestop over the vent pipe before connecting horizontal run to vent cap (see Figure 12). 8. Ca ref ull y mo ve fir e pl ace , wi th ve nt ass emb ly att ach ed, to w ar d wa ll an d ins ert ve nt pip e int o hor izo nta l ter min ati on.
10 www .desatech.com 1 16647-01A V ertical (V) Required V ertical (V) V ertical Pipe Horizontal (H) *43 3 / 4 " min. None 30" max. 53 3 / 4 " min. 1 ft. 48" max. 65 3 / 4 " min. 2 ft. 60" max. 77 3 / 4 " min. 3 ft. 84" max.
1 1 1 1 www .desatech.com 1 16647-01A SNORKEL TERMINA TION INST ALLA TION Recommended Applications: • Installations requiring a vertical rise on building exterior • Any installation using snorkel .
12 www .desatech.com 1 16647-01A INS TALLA TION FOR VERTICAL TER MINAT ION No te: V er ti cal re str ict or mus t b e i nst all ed in all ve rti cal in sta lla tio ns.
13 13 www .desatech.com 1 16647-01A VENTING INST ALLA TION INSTR UCTIONS Continued Flat Ceiling Installation 1. Cut a 10 3 / 4 " squ are hole in th e cei li ng us ing the loca tin g ho le as a c ent er poi nt .
14 www .desatech.com 1 16647-01A VENTING INST ALLA TION INSTR UCTIONS Continued VENTING INST ALLA TION INSTRUCTIONS Installation for V ertical T ermination (Cont.
15 15 www .desatech.com 1 16647-01A VENTING INST ALLA TION INSTR UCTIONS Continued HIGH AL TITUDE INST ALLA TION Y our DESA direct-vent fireplace has been tested and approved for elevations from 0-2000 feet (USA) and elevations from 0-4500 feet (Canada) .
16 www .desatech.com 1 16647-01A V a r ia b le F a n S w it c h W h it e W h ite B la c k G r e e n O n 1 10 / 1 1 5 V . A .C . Blow er Moto r B la c k B l a c k B l a c k O f f 5. Mo unt spe ed c ont rol box t o swit ch brac ket by pla ci ng the pla st ic control shaft forwa rd through the opening in the switch brack et (see Figure 26).
17 17 www .desatech.com 1 16647-01A FIREPLACE INST ALLA TION Installing Optional Blower Accessory (Cont.) FIREPLA CE INST ALLA TION Continued Thermodisc Figure 28 - Blower Model BKT Air Flow Direction.
18 www .desatech.com 1 16647-01A INST ALLING GAS PIPING TO FIREPLACE LOCA TION W ARNING: A qualified service person must con- nect fireplace to gas supply . Follow all local codes. CAUTION: For propane/LP units, never connect fireplace directly to the propane/LP supply .
19 19 www .desatech.com 1 16647-01A CHECKING GAS CONNECTIONS W ARNING: T est all gas piping and connections, internal and external to unit, for leaks after installing or servicing. Correct all leaks at once. W A R N IN G : N e v er u s e a n o pe n fl am e t o c h e c k f or a l ea k .
20 www .desatech.com 1 16647-01A FIREPLA CE INST ALLA TION Continued FIREPLACE INST ALLA TION Checking Gas Connections (Cont.) Removing/Replacing Glass Door Figure 36 - Removing Louver Panel Louver Panel Spring Latch Pressure T esting Fireplace Gas Connections 1.
21 21 www .desatech.com 1 16647-01A FIREPLA CE INST ALLA TION Continued FIREPLACE INST ALLA TION Installing Optional Brick Liner Model BL32D Installing Logs, Lava Rock and Glowing Embers INS TALLI NG OP TIONA L BRI CK LI NER MODEL BL32D WARNING: If fireplace has been running, turn off and unplug fireplace.
22 www .desatech.com 1 16647-01A FIREPLA CE INST ALLA TION Continued FIREPLACE INST ALLA TION Installing Optional Brick Liner Models BL36DA(SA) and BL36DHA(SA) Wall Switch Installation Optional Remote Control Installation 2. Rest log #2 (large front log) on the pins on the front part of the grate (see Figure 41).
23 23 www .desatech.com 1 16647-01A Figure 46 - Installing the WRC Remote Receiver Fireplace Receptacle Remote Control Receiver Extension Cord Ignition Module Plug Figure 47 - Installing Battery into .
24 www .desatech.com 1 16647-01A F ig ur e 4 8 - T ur ni n g E q u i p m e n t S h u t o f f V al v e t o t h e O F F P o s i t i o n Equipment Shutoff V alve Pilot Adjustment Screw LIGHTING INSTRUCTIONS NOTICE: During initial operation of new heater , burn- ing logs will give off a paper-burning smell.
25 25 www .desatech.com 1 16647-01A BURNER FLAME P A TTERN Burner flames will be steady; not lifting or floating. Flame patterns will be different from unit to unit and will vary depending on instal - lation type and weather conditions. If the vent configuration is installed incorrectly , the flames will lift or "ghost".
26 www .desatech.com 1 16647-01A Use only the tempered glass door replacement intended for this fireplace (see Replacement Parts , page 29 for detail on ordering). No substitutions may be made. See Removing/Replacing Glass Door , page 20 for instructions for replacing glass door .
27 27 www .desatech.com 1 16647-01A TROUBLESHOOTING TR OUBLESHOO TING Note: Before troubleshooting the system, make sure the gas shutoff valve is ON. T h e t wo m os t co mm on c au se s of a m al fu nc ti on in g ga s ap pl ia nc e ar e: 1. Loose wiring connections 2.
28 www .desatech.com 1 16647-01A TR OUBLESHOO TING Continued W ARNING: If you smell gas • Shut off gas supply . • Do not try to light any appliance. • Do n ot t ou ch a ny e le ct ri ca l sw it ch ; do n ot u se a ny p ho ne i n yo ur b ui ld in g.
29 29 www .desatech.com 1 16647-01A SER VICE HINTS When Gas Pressure Is T oo Low • pilot will not stay lit • burners will have delayed ignition • fireplace will not produce specified heat • propane/LP gas supply might be low (propane/LP units only) Y ou may feel your gas pressure is too low .
30 www .desatech.com 1 16647-01A ILLUSTRA TED P ARTS BREAKDOWN Models (V)T32EN-A, (V)T32ENB-A, (V)T32ENR-A, (V)T32ENRB-A (V)T32EP-A, (V)T32EPB-A, (V)T32EPR-A, (V)T32EPRB-A ILL USTRA TED P ARTS BREAKDO.
31 31 www .desatech.com 1 16647-01A P ARTS LIST Models (V)T32EN-A, (V)T32ENB-A, (V)T32ENR-A, (V)T32ENRB-A (V)T32EP-A, (V)T32EPB-A, (V)T32EPR-A, (V)T32EPRB-A P ARTS LIST This list contains replaceable parts used in your fireplace. When ordering parts, follow the instructions listed under Replacement Parts on page 29 of this manual.
32 www .desatech.com 1 16647-01A ILLUSTRA TED P ARTS BREAKDOWN Models (V)T32EN-A, (V)T32ENB-A, (V)T32ENR-A (V)T32ENRB-A, (V)T32EP-A, (V)T32EPB-A, (V)T32EPR-A, (V)T32EPRB-A IG N P V GND P V /M V T R T .
33 33 www .desatech.com 1 16647-01A KEY P ART NO. NUMBER DESCRIPTION QTY . 1 1 1 102 Screw #8-32 x 3/8 PPH Zinc 2 2 1 1 105 Screw #10 x 1/2 Zinc 9 3 108886-01 Base Grate Assembly 1 4 108891-01 Burner .
34 www .desatech.com 1 16647-01A ACCESSORIES MANUAL BLOWER KIT - BK Ma nua l var iab le co nt rol bl owe r acc ess ory provides better heat distri- bution. Complete installation and operation instructions included in this manual. THERMOST A TICALL Y - CONTROLLED BLOWER KIT - BKT Provides better heat distribution.
35 35 www .desatech.com 1 16647-01A 1. Where will the product be used? � Living/Family Room � Office/W arehouse � Utility Shed/Outbuilding � Garage � Bedroom � Bathroom � Other 2. If you bought this product yourself, did you plan to purchase this type of product before going into the store? � Y es � No 3.
36 www .desatech.com 1 16647-01A 2701 Industrial Drive P .O. Box 90004 Bowling Green, KY 42102-9004 Postage Required T APE T APE.
37 37 www .desatech.com 1 16647-01A NO TES ________________________________________________________________________________________________ ____________________________________________________________.
Model Serial No. Date Purchased LIMITED WARRANTY DIRECT -VENT FIREPLA CE DESA warrants this product to be free from defects in materials and components for two (2) years from the date of first purchase, provided that the product has been properly installed, operated and maintained in accordance with all applicable instructions.
Een belangrijk punt na aankoop van elk apparaat Desa (V)T32EN-A Series, (V)T32EP-A Series (of zelfs voordat je het koopt) is om de handleiding te lezen. Dit moeten wij doen vanwege een paar simpele redenen:
Als u nog geen Desa (V)T32EN-A Series, (V)T32EP-A Series heb gekocht dan nu is een goed moment om kennis te maken met de basisgegevens van het product. Eerst kijk dan naar de eerste pagina\'s van de handleiding, die je hierboven vindt. Je moet daar de belangrijkste technische gegevens Desa (V)T32EN-A Series, (V)T32EP-A Series vinden. Op dit manier kan je controleren of het apparaat aan jouw behoeften voldoet. Op de volgende pagina's van de handleiding Desa (V)T32EN-A Series, (V)T32EP-A Series leer je over alle kenmerken van het product en krijg je informatie over de werking. De informatie die je over Desa (V)T32EN-A Series, (V)T32EP-A Series krijgt, zal je zeker helpen om een besluit over de aankoop te nemen.
In een situatie waarin je al een beziter van Desa (V)T32EN-A Series, (V)T32EP-A Series bent, maar toch heb je de instructies niet gelezen, moet je het doen voor de hierboven beschreven redenen. Je zult dan weten of je goed de alle beschikbare functies heb gebruikt, en of je fouten heb gemaakt die het leven van de Desa (V)T32EN-A Series, (V)T32EP-A Series kunnen verkorten.
Maar de belangrijkste taak van de handleiding is om de gebruiker bij het oplossen van problemen te helpen met Desa (V)T32EN-A Series, (V)T32EP-A Series . Bijna altijd, zal je daar het vinden Troubleshooting met de meest voorkomende storingen en defecten #MANUAl# samen met de instructies over hun opplosinge. Zelfs als je zelf niet kan om het probleem op te lossen, zal de instructie je de weg wijzen naar verdere andere procedure, bijv. door contact met de klantenservice of het dichtstbijzijnde servicecentrum.
