Gebruiksaanwijzing /service van het product 42H-B van de fabrikant Hearth and Home Technologies
Ga naar pagina of 36
Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 • Rev J 1 1/08 1 Owner ’ s Manual Installation and Operation Models: Dakota 42-B Dakota 42H-B DO NOT DISCARD THIS MANUAL CAUTION • Important operating and maintenance instructions included.
2 Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 • Rev J 1 1/08 Read this manual before installing or operating this appliance.
Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 • Rev J 1 1/08 3 T able of Contents 1 Listing and Code Approvals A. Appliance Certi fi cation . . . . . . . . . . . . . . . . . . . . . . . . . 4 B. Glass Speci fi cations .
4 Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 • Rev J 1 1/08 1 1 Listing and Code Appro vals A. Appliance Certi fi cation This product is listed to ANSI standards .
Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 • Rev J 1 1/08 5 A. Design and Installation Considerations Check building codes prior to installation. • Installation MUST comply with local, regional, state and national codes and regulations.
6 Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 • Rev J 1 1/08 B. T ools and Supplies Needed Before beginning the installation be sure that the following tools and building supplies are available.
Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 • Rev J 1 1/08 7 B A G E Note: If this surface is inside the building’s warm air envelope... ...then this surface must be an exterior wall system. C D F F C D G F E 57-3/4 in.
8 Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 • Rev J 1 1/08 Fireplace Structure Mantel B A If A is: Then B mus t be at least: in. 6 - 36 26 mm 152 - 914 660 in. 36 or more 18 mm 914 or more 4 5 7 84 in. (2134 mm) minimum height Addi tio nal Structure or Sidewall Roof or Overhang 12 in.
Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 • Rev J 1 1/08 9 FP = FIREPLACE OPENING X = AIR SUPP L Y IN LET = AREA WHERE FIREPLACE IS NOT PERMITTED O N P R Q FP (Se.
10 Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 • Rev J 1 1/08 5 5 Appliance Preparation Sharp Edges • Wear protective gloves and safety glasses during installation. CAUTION A. Remove Logs and Shipping Cover Remove locking screw at the top of the doors (shown in Fig- ure 5.
Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 • Rev J 1 1/08 1 1 A. Fuel Conversion Before making gas connections ensure appliance being in- stalled is compatible with the available gas type.
12 Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 • Rev J 1 1/08 W ARNING Fire Risk Explosion Risk • Gas build-up during line purge may ignite. • Purge should be performed by quali fi ed technician. • Ensure adequate ventilation.
Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 • Rev J 1 1/08 13 E. V alve Access W asher Figure 6.1 Lift Out Doors Figure 6.3 Loosen Refractory Retaining Strip Figure 6.4 Remove V alve Access Panel Figure 6.5 Remove Exterior V alve Access Panel Figure 6.
14 Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 • Rev J 1 1/08 Batt er y po l a r i t y m us t b e c o r rec t o r m o dul e da m a g e w i l l occur . CAUTION A. Intelli fi re Ignition System Wiring • This appliance is equipped with an Intelli fi re control valve which operates on a 3 volt system.
Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 • Rev J 1 1/08 15 A. Mantel Projections Figure 8.1 shows the minimum vertical dimension of appliance mantels or other combustible projections above the top front edge of the appliance.
16 Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 • Rev J 1 1/08 Sealant Material 0 in. 0 in. 0 in. Upper front can be covered with non-combustible material or removed and replaced with non- combustible material. Finish wall material may be combustible, top & sides.
Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 • Rev J 1 1/08 17 A. Clean the Appliance Clean/vacuum any sawdust that may have accumulated in- side the fi rebox or underneath in the control cavity . Shock Risk Fire Risk Use ONL Y optional accessories approved for this appliance.
18 Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 • Rev J 1 1/08 Figure 9.6 Front Left Log (SRV722) Figure 9.5 Front Log (SRV727) • Place front left log between locating bars so it rests against log left side log and on top of front log.
Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 • Rev J 1 1/08 19 Handle glass with care. • Inspect the glass for cracks, chips or scratches. • Do NOT strike, slam or scratch glass. • Do NOT operate appliance with glass door removed, cracked, broken or scratched.
20 Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 • Rev J 1 1/08 Improper installation, adjustment, alteration, service or maintenance can cause injury or property damage. Refer to the owner ’s information manual provided with this appliance.
Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 • Rev J 1 1/08 21 B. Lighting the Appliance Intelli fi re Ignition Final Inspection by _________________________________ 1. T urn off wall switch. 2. This appliance is equipped with an igni- tion device which automatically lights the burner .
22 Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 • Rev J 1 1/08 Note: This applianc e should be run three to four hour s on the initial star t-up. T ur n it of f and let it co ol co mpletely . Remove and clean the glass.
Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 • Rev J 1 1/08 23 With proper installation, operation and maintenance your gas appliance will provide years of trouble-free service.
24 Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 • Rev J 1 1/08 Although the frequency of appliance servicing and maintenance will depend on use and the type of installation, a quali fi ed service technician should perform an appliance check-up at the beginning of each heating season.
Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 • Rev J 1 1/08 25 A. V alve Service and Replacement Figure 12.3 Loosen Refractory Retaining Strip Figure 12.2 Lift Out Doors Figure 12.4 Remove V alve Access Panel Figure 12.
26 Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 • Rev J 1 1/08 Ground Wire Figure 12.8 Remove V alve from V alve Bracket • Using two 3/4 in. wrenches, disconnect the burner supply tube. • Remove the two screws securing the valve to the valve bracket.
Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 • Rev J 1 1/08 27 B. Maintenance and Service T asks: Inspect Maintenance T asks Doors, surrounds and fronts 1. Inspect for scratches and nicks that can lead to breakage when exposed to heat.
28 Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 • Rev J 1 1/08 A. Appliance Dimension Diagram Dimensions are actual appliance dimensions. Use for reference only . For framing dimensions and clearances refer to Sec- tion 3.
Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 • Rev J 1 1/08 29 B. Service Parts List 10/08 Service Parts Service Parts Diagram 42 in. Outdoor Gas Fireplace DAKOT A42-B, DAKOT A42H-B 25 21 27 16 17 18 24 20 22 29 28 23 19 4 7 6 14 10 15 14 13 12 11 8 3 2 5 1 9 26 Part number list on following page.
30 Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 • Rev J 1 1/08 10/08 Service Parts Service Parts Diagram 42 in. Outdoor Gas Fireplace 14 6 6 3 13 16 15 7 9 5 Post Serial #OD9287 (Kit is retro-fittable.
Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 • Rev J 1 1/08 31 10/08 Service Parts Service Parts List 42 in. Outdoor Gas Fireplace SRV720 SRV722 SRV723 SRV724 SR.
32 Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 • Rev J 1 1/08 This page intentionally left blank..
Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 • Rev J 1 1/08 33 This page intentionally left blank..
34 Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 • Rev J 1 1/08 C. W arranty Hearth & Home T echnologies LIMITED W ARRANTY Hearth & Home T echnologies (“HHT.
Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 • Rev J 1 1/08 35 This limited warranty does not extend to or include surface fi nish on the appliance or terminations, door gasketing, glass gasketing, glass discoloration, fi rebrick, pellet logs, kaowool or other ceramic insulating materials.
36 Heat & Glo LifeStyle Collection • Dakota 42-B/Dakota 42H-B • 4036-909 • Rev J 1 1/08 D. Contact Information - NOTES - DO NOT DISCARD THIS MANUAL CAUTION • Important operating and maintenance instructions included. • Leave this manual with party responsible for use and operation.
Een belangrijk punt na aankoop van elk apparaat Hearth and Home Technologies 42H-B (of zelfs voordat je het koopt) is om de handleiding te lezen. Dit moeten wij doen vanwege een paar simpele redenen:
Als u nog geen Hearth and Home Technologies 42H-B heb gekocht dan nu is een goed moment om kennis te maken met de basisgegevens van het product. Eerst kijk dan naar de eerste pagina\'s van de handleiding, die je hierboven vindt. Je moet daar de belangrijkste technische gegevens Hearth and Home Technologies 42H-B vinden. Op dit manier kan je controleren of het apparaat aan jouw behoeften voldoet. Op de volgende pagina's van de handleiding Hearth and Home Technologies 42H-B leer je over alle kenmerken van het product en krijg je informatie over de werking. De informatie die je over Hearth and Home Technologies 42H-B krijgt, zal je zeker helpen om een besluit over de aankoop te nemen.
In een situatie waarin je al een beziter van Hearth and Home Technologies 42H-B bent, maar toch heb je de instructies niet gelezen, moet je het doen voor de hierboven beschreven redenen. Je zult dan weten of je goed de alle beschikbare functies heb gebruikt, en of je fouten heb gemaakt die het leven van de Hearth and Home Technologies 42H-B kunnen verkorten.
Maar de belangrijkste taak van de handleiding is om de gebruiker bij het oplossen van problemen te helpen met Hearth and Home Technologies 42H-B . Bijna altijd, zal je daar het vinden Troubleshooting met de meest voorkomende storingen en defecten #MANUAl# samen met de instructies over hun opplosinge. Zelfs als je zelf niet kan om het probleem op te lossen, zal de instructie je de weg wijzen naar verdere andere procedure, bijv. door contact met de klantenservice of het dichtstbijzijnde servicecentrum.
