Gebruiksaanwijzing /service van het product 2009 van de fabrikant Keating Of Chicago
Ga naar pagina of 25
1-800-K EA TI NG www .keatingofchicago.com Users Manual CU ST OM P AST A ® S Y S T E M E L EC TRIC SERIES 2 0 0 9 R EAD AN D SA VE TH I S MAN U AL F OR FUTUR E R E FE R E NCE. Keep this manual for training new personnel. S ECTION I: I NTR OD UCTION .
i T his operating, inst allation, and service manual should be given to the user . T he operator of the Custom Past a ™ System should be familiar with the functions and operation of the cooker . T his manual must be kept in a prominent, easily reac hable location near the Past a System.
1 I INTRODUCTION Instructions in this manual should be read thoroughly before attempting to operate this Keating Electric Pasta Cooker . All installation and service on Keating Equipment must be performed by qualified, certified, licensed and/or authorized installation or service personnel.
SAFETY PRECAUTIONS THIS SYMBOL W ARNS YOU THA T SERIOUS BURNS OR OTHER INJURIES MA Y RESUL T IF SAFETY INSTRUCTIONS ARE NOT FOLLOWED. • This service manual should be retained in a safe place for future reference.
3 II INST ALLA TION This Custom Pasta ™ System MUST be installed, inspected, calibrated and serviced by qualified and/or certified and/or licensed service personnel – you may void your Keating warranty if installation is not completed per current local, national and Keating specifications.
4 Push the fryer forward as far as it will go holding the fryer on approximately a 15° angle, and then drop the rear of the past a cooker into its proper position lowering it down gently so you do not deform the table or equipment stand. POSITIONING The past a cooker must be no closer than 6" from any combustible material.
5 In most cases the health department will not allow a direct connection between the cooker drain and the floor receptical. Contact your local health dep artment for specific information in your area.
6 thermostat calls for additional heat at st art up or occasionally when water is added. Follow cooking procedures below for your model. NOTE : Use of sodium chloride during the cooking process will have a detrimental ef fect on the cooker tank and will void the warranty .
7 4. Fill Pasta System vessel with water . See page 6 – Filling. UNDER NO CIRCUMST ANCES SHOULD THE P AST A SYSTEM BE LEFT UNA TTENDED DURING BOIL-OUT . TRAINED PERSONNEL MUST BE PRESENT DURING THE PROCEDURE TO PREVENT BOIL OVER OR T O TURN OFF THE POWER IF W A TER DROPS BELOW HEA T TRANSFER TUBES.
8 When the countdown has reached "00:00" the relay output contact s will open, the display will flash, and the audible alarm will sound. T o cancel the audible alarm, press any button. C. P AUSE FEA TURE T o pause a cycle in progress, press any button.
9 every calibration. Position near primary thermostat (center) bulb is recommended. 4. Pre-2000 model: If calibration of thermostat is found to be less than 15°F(9.44°C) off, simply loosen three dial plate retaining screws, rot ate dial plate to match thermometer reading and tighten screws.
V SER VICE DIAGNOSIS THE COOKER MUST BE DISCONNECTED FROM ITS POWER SOURCE OR SHUT DOWN A T THE BREAKER PRIOR TO SER VICE. AUTO-FILL SYSTEM The auto-fill system allows the automatic addition of water to the past a cooker during cooking or idle function.
11 COMMON PROBLEMS SOLUTIONS (FOLLOW IN SEQUENCE) W ater always filling 1. Clean sensors thoroughly with brush and vinegar . 2. Adjust the sensitivity of the B Board (for the top sensor) fully clockwise. 3. If filling persists, ground out the top sensor (if filling stops, replace sensor – Part #010212).
PROBLEM PROBABLE CAUSE SOLUTION Pasta Cooker has poor recovery or runs cold. a. Over-filling baskets. b.Thermostat out of calibration. c. Element is faulty . d. Thermostat is faulty . e. Contactor is faulty . a. Don’t overfill baskets. b. Calibrate thermostat.
VI P ARTS LIST 13 ITEM # DESCRIPTION QTY P ART # 1 INDICA TING LIGHT , AMBER - POWER ON 1 031624 2 TOGGLE SWITCH - MAIN ON-OFF 2 004499 3 INDICA TING LIGHT , GREEN - THERMOST A T HEA TING 2 009375 4 I.
14 P ARTS LIST FOR CUSTOM P AST A SYSTEM ™ ITEM DESCRIPTION MODELS P ART # 14 18 20 24 1 HEA TING ELEMENT 220V 6500W 14" ONL Y 018668 2 1 HEA TING ELEMENT 220V 6000W 18" & 20" ONL Y 004353 3 3 1 HEA TING ELEMENT 220V 6000W 24” ONL Y 004355 4 (SEE DET AIL - QUANTITIES ARE PER ELEMENT ) B.
15 VII WIRING DIAGRAMS 14" ELECTRIC P AST A 2-THERMOST A T WIRING DIAGRAM (WITHOUT TIMERS) (2).
14" ELECTRIC P AST A WITH DIGIT AL TIMERS WIRING DIAGRAM 16.
17 14" ELECTRIC P AST A WITH 138 TIMERS WIRING DIAGRAM (PRE-2000 SERIES) BLACK DIAL TIMER (NOT DIGIT AL).
18 14” ELECTRIC P AST A WITH BASKET -LIFT AND DIGIT AL TIMERS WIRING DIAGRAM.
19 18" & 20" ELECTRIC P AST A WITH 138 TIMERS WIRING DIAGRAM (PRE-2000 SERIES) BLACK DIAL TIMER (NOT DIGIT AL).
20 18" ELECTRIC P AST A 2-THERMOST A T WIRING DIAGRAM (WITHOUT TIMERS).
21 24” ELECTRIC P AST A WITH DIGIT AL TIMERS WIRING DIAGRAM.
.
K EA TI N G LI M ITE D WAR RANTY C AR D PLEASE C OM P LETE AN D MAIL A T ON CE–W AR RANTY IS N O T I N E FF ECT U NTI L C AR D IS R ETU R N E D. W AR RANTY CARD I S ALSO A V AI LAB LE T O C OM P LETE ON LI N E A T Y O U R CO NVE NIENCE .
Een belangrijk punt na aankoop van elk apparaat Keating Of Chicago 2009 (of zelfs voordat je het koopt) is om de handleiding te lezen. Dit moeten wij doen vanwege een paar simpele redenen:
Als u nog geen Keating Of Chicago 2009 heb gekocht dan nu is een goed moment om kennis te maken met de basisgegevens van het product. Eerst kijk dan naar de eerste pagina\'s van de handleiding, die je hierboven vindt. Je moet daar de belangrijkste technische gegevens Keating Of Chicago 2009 vinden. Op dit manier kan je controleren of het apparaat aan jouw behoeften voldoet. Op de volgende pagina's van de handleiding Keating Of Chicago 2009 leer je over alle kenmerken van het product en krijg je informatie over de werking. De informatie die je over Keating Of Chicago 2009 krijgt, zal je zeker helpen om een besluit over de aankoop te nemen.
In een situatie waarin je al een beziter van Keating Of Chicago 2009 bent, maar toch heb je de instructies niet gelezen, moet je het doen voor de hierboven beschreven redenen. Je zult dan weten of je goed de alle beschikbare functies heb gebruikt, en of je fouten heb gemaakt die het leven van de Keating Of Chicago 2009 kunnen verkorten.
Maar de belangrijkste taak van de handleiding is om de gebruiker bij het oplossen van problemen te helpen met Keating Of Chicago 2009 . Bijna altijd, zal je daar het vinden Troubleshooting met de meest voorkomende storingen en defecten #MANUAl# samen met de instructies over hun opplosinge. Zelfs als je zelf niet kan om het probleem op te lossen, zal de instructie je de weg wijzen naar verdere andere procedure, bijv. door contact met de klantenservice of het dichtstbijzijnde servicecentrum.
