Gebruiksaanwijzing /service van het product 453 van de fabrikant Norcold
Ga naar pagina of 23
INSTALLATION AN D OPERATING INSTRUCTIONS 442 443 452 4 53 482 483 462 4 63 Part No .: 61 8484B (9 5-09) These refri g erators are desi g ned to operate on the followin g ener gy sources: LP GAS OPERATION - 11.0 inch es Propane & 12 volt DC contro l volta g e ( 15.
Safety Precautions Read this manual and b ecome thoroughly acquain ted with it before installing or starting the refrigerator. The following safety precautio ns and recommendation s contained h erein are for your protection. Improper installation, adjustment, or operation can cause injury or property damage.
Safety Precautions - continued Electrical Circuits - AC and DC • The 120 volt AC circuit must be properly grounded. Never cut or remove the round grou nding prong f rom the re friger ator’s AC co rd. Do not us e a two- prong adapter . Do not use an extension cord to connect to t he approved AC recept acle.
General Instructions - All Model s The refri g erators described in thi s manual are de- si g ned for built-in ins tallations and re q uire cut out di- mensions as i ndicated on pa g e . The refri g erators must be plac ed on a solid and level floor awa y from heat g eneratin g sources.
VENTILATION REQUIREMENTS WARNING: Carbon Monoxide can cause nausea, fainting, or deat h. Inadequat e ven- tilation or partial blockage of the refrigera- tor’s flue can result in increased car bon monoxide emissions when operating in the gas mode.
Optimum Installation - Fi gure 1 The optimum instal lation is illustrated in Fi g ure 1. 1. Area above refri g erator blocked ( baffled ) off to preven t trap pin g of hot a ir ab ove th e refri g erat o r . 2 . 0 -1/ 4 in ch cl ear ance at th e t op of the r e f r i g erator.
Side Wall Clearance - Figure 4 1. Fi g ure 4 il lustrates the re q uirement to minimize the clearance at the sides of the refri g erator. The clearance is not to exceed 1/2 inch. Side clearances in ex cess of 1/2 inch must be either filled wi th Fiber g las battin g or blocked with pan- elin g , etc.
INSTALLATION INSTRUCTIONS Certification and Code Requi rements The refri g erators described herein are certif ied un- der the lates t edition of ANS I Z21.19 Standards b y the American Gas A ssociation ( A.G.A. ) for installa- tion in mobi le home or recreational vehicle and ap- proval b y the Canadian Gas Association ( CGA ) .
Gas Connection The refri g erators are desi g ned to operate on pro- pane g as at a suppl y pressure of 11 inches water column. A pressure re g ulator is re q uired between the refri g erator and the main g as tank. Do not connect the refrigerator dir ectly to the main propane tank without a pressur e regulator.
suppl y connects to the terminal bloc k at the rear of the refri g erator ( See Fi g ure 9 on pa g e 8 ) . The 12 volt DC should enter the refri g erator’s encl osure near the refri g erator’s terminal block . The 12 volt DC connects at ( 2 ) one q uarter inch q uick connects.
Check O ut - Flame Fail ure Safe ty Devi ce Before placin g the refri g erator into operation, the g as safet y device must be tested ( see Operatin g In- structions on pa g e 13 ) . The purpose of the g as safet y device is to prev ent the escape of unbur ned g as from the burner if the burner flame is extin- g uished.
4 Remove the lower door b y openin g it sli g htl y and pullin g the top of the door awa y from the refri g erator. Allow enou g h room so the door can be li fted up and off of the bottom hi n g e pin shoulder ( See Fi g ure 18 ) . Be sure to save the hin g e plates alon g with the spacer used in the middle hin g e bracket, for reassembl y late r.
ALIG NMENT OF THE DOORS 12. Ali g n the upper door with the lower so that there is a parallel g ap between the doors and around the frame. Ad j ust the doors to the cabi- net so the g askets seal but do not bind. Ti g hten the screws holdin g the hin g e brackets in place.
Lighting and Start Up Procedures WARNING: DO NOT HOLD GAS VALVE (D) IN MORE THAN 30 SE CONDS. IF FLAME IS NOT INDICATED WITHIN THIS TIME, TURN GAS TO OFF, WAIT 2 MINUTES AND RETRY. CONTINUING T O HOLD GAS VALVE IN WILL CAUSE GAS BUILD-UP IN THE BURNE R AREA AND CAN RESULT IN AN EXPLOSION WHICH CAN CAUSE P E RSONAL INJURY OR DEATH.
OPERATING AND USER INSTRUCTIONS THIS APPLIANCE HAS BEEN DE SIGNED FOR STORAG E OF F OODS, S TORAGE O F FROZEN FOODS , AND M AKING ICE WH EN INS TALL ED AS DIRECTED BY THIS MANUAL. Location of Controls Figure 18 illustrates the location of the 400 Series refrigerator’s operating controls.
tem not only s upplies power to the refrigerator, but to other DC components in the vehicle. DC electric operation is not as efficient as LP Gas or AC el ectric operation, and should therefore be used only when the other modes are unavail able (for example; while in transit - 4 to 6 hours).
Leveling Comfortab le vehicle leveling is well within the re- frigera tor’s oper ating re quiremen ts of 3 de grees off lev el sid e-t o-sid e and 6 degr ees of f leve l fron t-to- back (loo king at t he fr ont of the re frigerator ). Co n- tinu ed op erati on out side of the se limi ts ca n resu lt in irreparab le damage t o the cooling system.
is not bei ng used for storage. Keep the r efrig- erator area clear and free from combustible materials, gasol ine, and other fl ammable va- pors and liquids.
Trouble Shooting SYMPT OM Refrigerator does not operate in AC Mode Possible Causes * Mode Selection swi tch may be set to "OFF" or "G AS". * Temperature Selector set too low. * Refrigerator’s power cord may not be se- curely p lugged in .
FAILURE OF REFRIGERATION Failure of refrigeration does not necessarily indicate that the cooli ng system is defectiv e. Other factors governing its operation must be checked. If the refrigerator is operating on gas and a loss of cooling i s noticed, switc h the refrigerator to AC elec- tric operation.
2 1.
2 2.
LIMITED WARRANTY NORCOLD SERVICE CENTER P O BOX 42 48 SIDN EY OH 45365- 4248 This Limited Warranty is giv en by NORCOLD ("Company") to the original consumer-purchaser of any new refrigeratin.
Een belangrijk punt na aankoop van elk apparaat Norcold 453 (of zelfs voordat je het koopt) is om de handleiding te lezen. Dit moeten wij doen vanwege een paar simpele redenen:
Als u nog geen Norcold 453 heb gekocht dan nu is een goed moment om kennis te maken met de basisgegevens van het product. Eerst kijk dan naar de eerste pagina\'s van de handleiding, die je hierboven vindt. Je moet daar de belangrijkste technische gegevens Norcold 453 vinden. Op dit manier kan je controleren of het apparaat aan jouw behoeften voldoet. Op de volgende pagina's van de handleiding Norcold 453 leer je over alle kenmerken van het product en krijg je informatie over de werking. De informatie die je over Norcold 453 krijgt, zal je zeker helpen om een besluit over de aankoop te nemen.
In een situatie waarin je al een beziter van Norcold 453 bent, maar toch heb je de instructies niet gelezen, moet je het doen voor de hierboven beschreven redenen. Je zult dan weten of je goed de alle beschikbare functies heb gebruikt, en of je fouten heb gemaakt die het leven van de Norcold 453 kunnen verkorten.
Maar de belangrijkste taak van de handleiding is om de gebruiker bij het oplossen van problemen te helpen met Norcold 453 . Bijna altijd, zal je daar het vinden Troubleshooting met de meest voorkomende storingen en defecten #MANUAl# samen met de instructies over hun opplosinge. Zelfs als je zelf niet kan om het probleem op te lossen, zal de instructie je de weg wijzen naar verdere andere procedure, bijv. door contact met de klantenservice of het dichtstbijzijnde servicecentrum.
