Gebruiksaanwijzing /service van het product RESDELUX van de fabrikant Nortec
Ga naar pagina of 22
RESDELUX Steam Humidifiers Installation, Operation, Maintenance and Troubleshooting Guide IMPORTANT: READ AND SAVE THESE INSTRUCTIONS . This guide to be left with equipment owner.
Table Of Contents INSTALLATION 1 RECEIVING & UNPACKING EQUIPMENT ................................1 PRE-INSTALLATION CHECKPOINT ...................................1 HUMIDIFIER CONFIGURATION ......................................1 LOCATION & MOUNTING .
PRINCIPLE OF OPERATION .....................................1 2 FILL RATE ...............................................1 2 DRAIN TIME ..............................................1 2 RATED AMPERS ...........................................1 2 SHORT CYCLING .
INSTALLATION RECEIVING & UNPACKING EQUIPMENT 1. Check packing slip to ensure ALL material has been delivered. 2. All material shortages are to be reported to NORTEC within 48 hours from receipt of goods. NORTEC assumes no responsibility for any material shortages beyond this period.
5. Make sure humidifier is level. 6. DO NOT mount humidifier on hot surfaces. 7. DO NOT mount humidifiers in an area where freezing may occur. 8. DO NOT mount humidifiers on a vibrating surface. 10. DO NOT mount the humidifier to a duct or plenum. STEAM DISTRIBUTOR NOZZLE (in duct location) 1.
STEAM HOSE INSTALLATION 1. The length of the steam hose must not exceed 4’ (1.2m). 2. It must not be restricted in any way (i.e. - a kink resulting from a short radius bend). 3. Avoid condensate traps in the hose, see Figure #8. 4. Use wall clips (p/n 158-5001) to support the steam and condensate hoses and maintain 1” clearance from the wall.
4. Put the power leads from the blower pack through this opening as you position the blower pack on top of the RESDELUX humidifier 5. Push the blower pack forward until the locating tabs on the bottom of the blower pack with slots in the top of the RESDELUX push forward to engage.
NOTE: Improper wiring could damage the blower pack or RESDELUX PCB. 9. Remove the front door and service cover from the RESDELUX humidifier. 10. Connect the power leads for the blower pack to terminal P7 on the RESDELUX control board located next to the capacity adjustment potentiometer.
.
current) across terminals 1 and 2 on the low voltage control terminal. Caution: This is the “common” wire from the transformer that is connected to the ground.
valves operation. Green and yellow lights flash during this time. If there is no call for humidity, the humidifier is standing by and green light flashes. When control loop is closed, the green light is steady on and the humidifier starts its operation.
(Life varies from 500 to 2000 operating hours, as illustrated in Figure #16.) The RESDELUX control board constantly monitors unit performance and will shut down the humidifier and alert the customer to change the cylinder. The yellow light will flash 4 times in sequence.
3. This color-coding must be adhered to when replacing cylinder plugs on pins. 4. The electrode plug with the orange wire always goes on the single pin surrounded by a plastic shoulder. 5. Ensure that cylinder plugs fit snugly on the pins. 6. If a cylinder plug becomes loose the cylinder harness must be replaced (P/N 158-1305 see parts list).
TROUBLESHOOTING PLEASE READ THIS SECTION BEFORE REFERENCING SPECIFIC DIAGNOSTIC MESSAGES. 1. Ensure the installation detail conforms with the recommendations contained in the Installation section of this manual. 2. Understanding the Principle of Operation is an asset when troubleshooting.
PROCEDURES AND TERMS USED IN DIAGNOSING PRINCIPLE OF OPERATION The conductivity of the water within the cylinder must be controlled in order for the humidifier to function properly. The fill and drain rates must be maintained. Filling too quickly can cause over-amping and automatic shutdown or blown fuses.
-1 3-.
-1 4-.
SPARE PARTS LIST AND EXPLODED VIEW - RESDELUX -1 5- Item Number Part Number Description 1 151-9002 Cylinder type 202 2 158-1820 Steam distributor kit 3 153-5062 Steam distributor 4 158-1830 Steam blow.
1 2 5 3 7 6 9 10 19 11 12 14 15 20 13e 4 21c 18 16 17 8 22 23 24 21b 21a 13a 13d 13b 13c 11 b 14a 11 a 8a 12a -1 6-.
PERIODIC MAINTENANCE CHECKLIST PREVENTIVE MAINTENANCE AND SERVICE CHECK LIST FOR NORTEC’S RESDELUX Customer ______________________________________________________________ Address ___________________.
LIMITED WARRANTY Walter Meier Inc. and/or Walter Meier Ltd. (hereinafter collectively referred to as THE COMPANY), warrant for a period of two years from date of shipment, that THE COMPANY’s manufac.
Model #: Serial #: Cylinder #: Cylinder Last Replaced: _________________________ MTH/DAY/YR _________________________ MTH/DAY/YR _________________________ MTH/DAY/YR E6518 Walter Meier (Climate USA) Inc. 826 Proctor Avenue, Ogdensburg, New York 13669 Walter Meier (Climate Canada) Ltd.
Een belangrijk punt na aankoop van elk apparaat Nortec RESDELUX (of zelfs voordat je het koopt) is om de handleiding te lezen. Dit moeten wij doen vanwege een paar simpele redenen:
Als u nog geen Nortec RESDELUX heb gekocht dan nu is een goed moment om kennis te maken met de basisgegevens van het product. Eerst kijk dan naar de eerste pagina\'s van de handleiding, die je hierboven vindt. Je moet daar de belangrijkste technische gegevens Nortec RESDELUX vinden. Op dit manier kan je controleren of het apparaat aan jouw behoeften voldoet. Op de volgende pagina's van de handleiding Nortec RESDELUX leer je over alle kenmerken van het product en krijg je informatie over de werking. De informatie die je over Nortec RESDELUX krijgt, zal je zeker helpen om een besluit over de aankoop te nemen.
In een situatie waarin je al een beziter van Nortec RESDELUX bent, maar toch heb je de instructies niet gelezen, moet je het doen voor de hierboven beschreven redenen. Je zult dan weten of je goed de alle beschikbare functies heb gebruikt, en of je fouten heb gemaakt die het leven van de Nortec RESDELUX kunnen verkorten.
Maar de belangrijkste taak van de handleiding is om de gebruiker bij het oplossen van problemen te helpen met Nortec RESDELUX . Bijna altijd, zal je daar het vinden Troubleshooting met de meest voorkomende storingen en defecten #MANUAl# samen met de instructies over hun opplosinge. Zelfs als je zelf niet kan om het probleem op te lossen, zal de instructie je de weg wijzen naar verdere andere procedure, bijv. door contact met de klantenservice of het dichtstbijzijnde servicecentrum.
