Gebruiksaanwijzing /service van het product Victory 9 van de fabrikant Pride Mobility
Ga naar pagina of 52
*INFMANU3629* Including Models: Victory 9, Victory 9 PS, and Victory 10 VICT OR Y SERIES.
Copyright © 2012 Pride Mobility Products Corp. INFMANU3629/Rev I/February 2012 SAFETY GUIDELINES NOTE: This owner’s manual is compiled from the la test specifications and product information avail- able at the time of publication. We reserve the right to m ake changes as they become necessary.
Victory Series www.pridemobility.com 3 CONTENTS I. INTRODUCTION ....................................................................................................................... 4 II. SAFETY ......................................................
4 www.pridemobility.com Victory Series I. INTRODUCTION SAFETY Welcome to Pride Mobility Products Corporation (Pride). The pro duct you have purchased combines state-of the-art components with safety , comfort, and styling in mind. We are confident the design features will provide you with the conveni ences you expect during your daily activities.
Victory Series www.pridemobility.com 5 II. SAFETY PRODUCT SAFETY SYMBOLS The symbols below are used on the scooter to id entify warnings, mandatory actions, and prohibited actions. It is very important for you to read and understand them completely. Pinch/Crush points created during a ssembly.
6 www.pridemobility.com Victory Series II. SAFETY Maximum seating weight. Place unit on level ground and stand to on e side when changing from drive m ode to freewheel mode or freewheel mode to drive mode. Locked and in drive mode. Unlocked and in freewheel mode.
Victory Series www.pridemobility.com 7 II. SAFETY Do not use a cell phone, walkie/talkie, laptop, or other radio transmitter while operating. Avoid exposure to rain, snow, ice, sa lt, or standi ng water whenever possible. Maintain and store in a clean and dry condition.
8 www.pridemobility.com Victory Series II. SAFETY Battery charger for indoor use only. Disposal and recycling - Contact your aut horized Pride Provider for information on proper disposal and recycling of your Pride product and its packaging. Contains Lead.
Victory Series www.pridemobility.com 9 II. SAFETY GENERAL MANDATORY! Do not operate your new scoot er for the first time without comp letely reading and understanding this owner’s manual. Your scooter is a state-of-the-art life-enhancement device designed to in crease mobility.
10 www.pridemobility.com Victory Series II. SAFETY Perform the following inspecti ons prior to us ing your scooter: Check for proper tire infl ation. Maintain but do not exceed the ps i/bar/kPa air pressu re rating indicated on each tire if equippe d with pneumatic tires.
Victory Series www.pridemobility.com 11 II. SAFETY When climbing an incline, try to keep your scooter movi ng. If you must stop, star t up again slowly, and then accelerate cautiously. When drivi ng down an incline, do so by setting the speed adjustment dial to the slowest setting and driving in the forward direction onl y.
12 www.pridemobility.com Victory Series II. SAFETY Figure 2. Increa sed Stability Driving Posi tion Figure 1. Normal Driving Position CORNERING INFORMATION Excessively high cornering speeds can create the possibility of tipping.
Victory Series www.pridemobility.com 13 II. SAFETY PUBLIC STREETS AND ROADWAYS WARNING! You should not operate your scoot er on public streets and roadways. Be aware that it may be difficult for traffic to see you when you are seated on your scooter. Obey all local pedestrian traffic rules.
14 www.pridemobility.com Victory Series II. SAFETY FREEWHEEL MODE Your scooter is equipped with a manual freewheel lever that, when engaged, allows the scooter to be pushed. For more information about how to place your scooter into and out of freewheel mode, see III.
Victory Series www.pridemobility.com 15 II. SAFETY LIFT/ELEVATION PRODUCTS If you will be transporting your scoot er during travel, you may find it n ecessary to use a vehicle-mounted lift system or elevation product to aid in transportation.
16 www.pridemobility.com Victory Series II. SAFETY MOTOR VEHICLE TRANSPORT Pride recommends that you do not remain seated in y our scooter while traveling in a motor vehicle. The scooter should be stowed in the trunk of a car or in th e back of a truck or van with the batteries removed and properly secured.
Victory Series www.pridemobility.com 17 II. SAFETY POSITIONING BELTS Your authorized Pride Provider, ther apist(s), and other heal thcare professionals ar e responsible for deter- mining your requirement for a positioning belt in order to operate your scooter safely.
18 www.pridemobility.com Victory Series II. SAFETY WARNING! The addition of accessories or components to the electrically-powered mobility vehicle can increa se the susceptibility of the vehicle to EMI. Do not modify your scooter in any way not authorized by Pride.
Victory Series www.pridemobility.com 19 *POWER SEAT SWITCH *HAZARD LIGHTS SWITCH HORN BUTTON III. YOUR SCOOTER TILLER CONSOLE The tiller console houses al l of the controls needed to drive you r scoot.
20 www.pridemobility.com Victory Series III. YOUR SCOOTER Status LED The status LED alerts you to electr ical problems that may occur with the scooter. The LED remains con- stantly lit while your scooter is on. If your scooter develops an elect rical problem, the stat us LED will flash a code.
Victory Series www.pridemobility.com 21 III. YOUR SCOOTER Throttle Control Lever This lever allows you to control the forward speed and the reverse speed of your scooter up to the maximum speed you preset with the speed adju stment dial.
22 www.pridemobility.com Victory Series III. YOUR SCOOTER REAR SECTION The batteries, anti-tip wheels, moto r/transaxle assembly, main circuit breaker (reset button), and the man- ual freewheel lever are located on the rear section of your scooter. See figure 7 .
Victory Series www.pridemobility.com 23 MAIN CIRCUIT BR EAKER III. YOUR SCOOTER Main Circuit Breaker (Reset Button) When the voltage in the batter ies becomes low or your scooter is heavily stra ined because of excessive loads, the main circuit breaker may trip to protect the motor and electronics from damage.
24 www.pridemobility.com Victory Series IV. BATTERIES AND CHARGING BATTERIES A ND CHARGING Your scooter requires two l ong-lasting, 12-volt, deep-cyc le batteries that are seal ed and maintenance free. They are recharged by an off-board charging system.
Victory Series www.pridemobility.com 25 IV. BATTERIES AND CHARGING Follow these easy steps to change your batteries safely: 1. Position the front of your scooter close to a stan- dard electrical outlet. 2. Remove the key from the key switch. 3. Make sure that the ma nual freewheel lever is in the drive position.
26 www.pridemobility.com Victory Series IV. BATTERIES AND CHARGING How often must I charge the batteries? Two major factors must be considered when deciding how often to charge your scooter’s batteries: All day scooter use on a daily basis. Infrequent or sporadic scooter use.
Victory Series www.pridemobility.com 27 IV. BATTERIES AND CHARGING How do I change a battery in my scooter? Your scooter requires two 12-volt, d eep cycle, U-1 (31-36 Ah ) batteries that are s ealed and maintenance free. Only sealed, non-spillable ba tteries that meet DOT CRF 173.
28 www.pridemobility.com Victory Series BATTERY HARNESS CONNECTIONS IV. BATTERIES AND CHARGING Why do my new batteries seem weak? Deep-cycle batteries employ a differen t chemical technology than that used in car batteries, nickel-cad- mium batteries (nicads), and other common battery types.
Victory Series www.pridemobility.com 29 Follow these steps to properly break in your scooter’s new batteries for maximum effi ciency and service life: 1. Fully recharge any new battery prior to its initial use. This charging cycle brings the battery up to about 88 % of its peak performance level.
30 www.pridemobility.com Victory Series V. OPERATION BEFORE GETTING ONTO YOUR SCOOTER Have you fully charged the batterie s? See IV. “Batteries and Charging.” Is the manual freewheel le ver in the drive (rearwar d) position? Neve r leave the manual freewheel lever pushed forward unless you are ma nually pushing your scooter.
Victory Series www.pridemobility.com 31 V. OPERATION To stop, slowly release the throttle control lever. The electronic brakes will automatically engage, bringing your scooter to a stop. NOTE: Your scooter’s reverse speed is slower than that of the forwar d speed yo u preset with the speed adjustment dial.
32 www.pridemobility.com Victory Series TILLER ANGLE ADJUSTMENT WARNING! Remove the key from the key switch before adjusting the tiller or the seat. Never attempt to adjust the tiller or the seat while the scooter is in motion. Your scooter is equipped wi th an adjustable pivoting tiller.
Victory Series www.pridemobility.com 33 VI. COMFORT ADJUSTMENTS Figure 18. Seat Height Adjustment LOWER SEAT POST SEAT HEIGHT ADJUSTMENT BOLT NUT LOCATING HOLE UPPER SEAT POST Figure 17. Seat Pos ition Adjustments SEAT ROTATION ADJUSTMENT The seat rotation lever will secure the seat into sev- eral positions.
34 www.pridemobility.com Victory Series VI. COMFORT ADJUSTMENTS POWER SEAT ADJUSTMENT Your scooter may be equippe d with a power seat. The pow er seat actuator is designed to raise or lower the seat with minimal effort on the part of the operator. Th e power s eat switch is lo cated on the tiller console.
Victory Series www.pridemobility.com 35 VII. DISASSEMBLY AND ASSEMBLY DISASSEMBLY You can disassemble the scooter into several pieces: the seat, the front section, the rear section, the battery shroud (if eq uipped), the basket, and the batteries or battery boxes.
36 www.pridemobility.com Victory Series VII. DISASSEMBLY AND ASSEMBLY Frame Separation 1. Arrange the front wheel( s) in a straight for- ward-facing position.
Victory Series www.pridemobility.com 37 Any electromechanical device occasionally requires some troubleshooti ng. However, most of the prob- lems that may arise can usually be solved with a bi t of thought and common sense.
38 www.pridemobility.com Victory Series VIII. BASIC TROUBLESHOOTING What if my scooter does not move wh en I engage the throttle control lever? When the manual freewheel lever is pushed forward, the brakes are disengaged and all power to the motor/transaxle assembly is cut.
Victory Series www.pridemobility.com 39 IX. CARE AND MAINTENANCE Your scooter requires a mi nimal amount of care and ma intenance. If you do not feel confident in your ability to perform the maintenan ce listed below, you ma y schedule inspection a nd maintenance at your authorized Pride Provi der.
40 www.pridemobility.com Victory Series IX. CARE AND MAINTENANCE WHEEL REPLACEMENT If your scooter is equipped with pneumatic tires and you have a flat ti re, you can have th e tube replaced. If your scooter is equipped with a solid tire insert, either the solid insert or the entir e wheel must be replaced depending on th e model.
Victory Series www.pridemobility.com 41 IX. CARE AND MAINTENANCE FUSE REPLACEMENT In the event a fuse should cease to work: 1. Remove the fuse by pulling it out of its slot. 2. Examine the fuse to be sure it is blown. See figures 24 and 24A . 3. Insert a new fuse of the same rating.
42 www.pridemobility.com Victory Series APPENDIX I - SPECIFICATIONS 1 Varies with user weight, terrain ty pe, battery amp-hour (Ah), bat tery ch arge, battery conditio n, and tire condi- tion. This specification can be subj ect to a variance of (+ or -) 10%.
Victory Series www.pridemobility.com 43 APPENDIX I - SPECIFICATIONS 22.25 in. (56.5 cm) 3-Wheel: 45.25 in. (115 cm) 4-Wheel: 47 in. (119.38 cm) 3 in. (7.62 cm) 35.75 in. (90.8 cm) 54 in. (137.16 cm) 4-Wheel T urning Radius 42 in. (106.68 cm) 3-Wheel T urning Radius 18 in.
44 www.pridemobility.com Victory Series APPENDIX I - SPECIFICATIONS 1 Varies with user weight, terrain ty pe, battery amp-hour (Ah), bat tery ch arge, battery conditio n, and tire condi- tion. This specification can be subj ect to a variance of (+ or -) 10%.
Victory Series www.pridemobility.com 45 APPENDIX I - SPECIFICATIONS Figure 26. Victory 9 Dimensions 3-wheel: 22.125 in. (56.2 cm) 4-wheel: 22.5 in. (57.15 cm) 18 in. (45.72 cm) 17 in. (43.18 cm) 3-Wheel: 43.5 in. (110.5 cm) 4-Wheel: 45.5 in. (115.57 cm) 51.
46 www.pridemobility.com Victory Series 1 Varies with user weight, terrain ty pe, battery amp-hour (Ah), bat tery ch arge, battery condition, and tire condi- tion. This specification can be subj ect to a variance of (+ or -) 10%. 2 Tested in accordance with ANSI/RESNA, WC Vol 2, S ection 4 & ISO 7176-4 s tandards.
Victory Series www.pridemobility.com 47 APPENDIX I - SPECIFICATIONS Figure 27. Victo ry 9 PS Dimensions 22.125 in. (56.2 cm) 43.5 in. (110.5 cm) 3-wheel: 2 in. (5 cm) 40.25 (102.24 cm) 14.5 in. (36.83 cm) 17.25 - 23.25 in. (43.8 - 59.1 cm) 40.25 in. (102.
48 www.pridemobility.com Victory Series NOTES.
Victory Series www.pridemobility.com 49 NOTES.
50 www.pridemobility.com Victory Series NOTES.
Copyright © 2012 Pride Mobility Products Corp. INFMANU3629/Rev I/February 2012 SAFETY GUIDELINES NOTE: This owner’s manual is compiled from the la test specifications and product information avail- able at the time of publication. We reserve the right to m ake changes as they become necessary.
*INFMANU3629* Including Models: Victory 9, Victory 9 PS, and Victory 10 VICT OR Y SERIES.
Een belangrijk punt na aankoop van elk apparaat Pride Mobility Victory 9 (of zelfs voordat je het koopt) is om de handleiding te lezen. Dit moeten wij doen vanwege een paar simpele redenen:
Als u nog geen Pride Mobility Victory 9 heb gekocht dan nu is een goed moment om kennis te maken met de basisgegevens van het product. Eerst kijk dan naar de eerste pagina\'s van de handleiding, die je hierboven vindt. Je moet daar de belangrijkste technische gegevens Pride Mobility Victory 9 vinden. Op dit manier kan je controleren of het apparaat aan jouw behoeften voldoet. Op de volgende pagina's van de handleiding Pride Mobility Victory 9 leer je over alle kenmerken van het product en krijg je informatie over de werking. De informatie die je over Pride Mobility Victory 9 krijgt, zal je zeker helpen om een besluit over de aankoop te nemen.
In een situatie waarin je al een beziter van Pride Mobility Victory 9 bent, maar toch heb je de instructies niet gelezen, moet je het doen voor de hierboven beschreven redenen. Je zult dan weten of je goed de alle beschikbare functies heb gebruikt, en of je fouten heb gemaakt die het leven van de Pride Mobility Victory 9 kunnen verkorten.
Maar de belangrijkste taak van de handleiding is om de gebruiker bij het oplossen van problemen te helpen met Pride Mobility Victory 9 . Bijna altijd, zal je daar het vinden Troubleshooting met de meest voorkomende storingen en defecten #MANUAl# samen met de instructies over hun opplosinge. Zelfs als je zelf niet kan om het probleem op te lossen, zal de instructie je de weg wijzen naar verdere andere procedure, bijv. door contact met de klantenservice of het dichtstbijzijnde servicecentrum.
