Handleiding Zebra Technologies P100iTM Printer

Samenvatting van de inhoud op de volgende paginas van de handleiding

Pagina 1

980590-001 Rev . A Zebra ® P100 i ™ Card Printer User’s Manual.
Pagina 2

Copyright Notice © 2007 ZIH Corp. This document contai ns information proprietar y t o Zebra T echnologies Corp oration. This document and th e information contained wit hin is Copyrighted by Zebra T.
Pagina 3

980590-001 Rev . A P100 i User ’s Manual 3 Contents 1 • Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 Description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Pagina 4

4 P100 i User ’s Manual 980590-001 Rev . A Content s 5 • Cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 41 Cleaning the System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Pagina 5

980590-001 Rev . A P100 i User ’s Manual 1 1 Introduction This manual contai ns installation and operation informati o n for the Zebra P100 i Ca rd Printer manufactured by Zebra T echnologies Corporati on. Description The P100 i provides full color dye subli mati on or monochrome therm al transfer single side printing on st andard 2.
Pagina 6

2 P100 i User ’s Manual 980590-001 Rev . A Introduction P100i Part Numbers P100 i Part Numbers The Part Number of a particul ar P100 i Printer is shown on a label affixed to the bottom of the printer; that Part Numbe r identifies the spec ific configuration for th at printer .
Pagina 7

Introduction Features, Controls, and Indica tors 980590-001 Rev . A P100 i User ’s Manual 3 Features, Controls, and Indicators The picture belo w points out some of the printe r’ s external features.
Pagina 8

4 P100 i User ’s Manual 980590-001 Rev . A Introduction Features, Cont ro ls, an d In dic ators LCD Display Panel The LCD Display Panel d isplays printe r status in formation. Messages also alert t he user of the need for action, and indicat e cert ain fault conditions.
Pagina 9

Introduction Features, Controls, and Indica tors 980590-001 Rev . A P100 i User ’s Manual 5 If your P100 i Printe r includes the Ethernet optio n, the rear of the printer will loo k like the figure below . For Ethern et connection, refe r to Appendix C , Connecting to a Network.
Pagina 10

6 P100 i User ’s Manual 980590-001 Rev . A Introduction Features, Cont ro ls, an d In dic ators LCD Panel Messages LCD Panel message s fall into thre e c ategories: • Operational Operational Me ssages are displayed during the Printer’ s normal operati on.
Pagina 11

Introduction Features, Controls, and Indica tors 980590-001 Rev . A P100 i User ’s Manual 7 Refer to Chapter 6 for T rou bl eshooting Pro c edures. W arnings (Printer will stil l operate) CLEAN PRIN.
Pagina 12

8 P100 i User ’s Manual 980590-001 Rev . A Introduction Icons Icons Throughout t his manual, dif ferent icons highlight important information, as fo llows: Note • Indicates information tha t emphasizes or supplements important points of the main text.
Pagina 13

980590-001 Rev . A P100 i User ’s Manual 9 2 Printer Installation Unp acking Y our Card Printer Y ou r P100 i Printer ships in a cardboa rd carton, protected by styrofoam inserts and a protective anti-static b ag. Keep all packaging ma terial in case you need to move or re -sh ip the pr int er .
Pagina 14

10 P100 i User ’s Manual 980590-001 Rev . A Printer Inst allation Installing the P100i Printer Inst alling the P100 i Printer 1. Place the printer in a locat ion that allows easy access to all sides. The printer shou ld never be operated while resting on its side or upside down 2.
Pagina 15

Printer Inst allation Installing the P100i Printer 980590-001 Rev . A P100 i User ’s Manual 1 1 3. Ensure that the prin ter ’ s power switch is i n the OFF (O) position .
Pagina 16

12 P100 i User ’s Manual 980590-001 Rev . A Printer Inst allation Installing the P100i Printer 5. If your printer has o nly the USB interface, attach the in cluded USB cable to your computer and the printer .
Pagina 17

Printer Inst allation Installing the P100i Printer 980590-001 Rev . A P100 i User ’s Manual 13 6. If your printer has t he optional Ethernet interface (as well as the USB interface), connec t either the USB cable to printer and computer o r the Ethernet cable to th e printer and the Ethernet network.
Pagina 18

14 P100 i User ’s Manual 980590-001 Rev . A Printer Inst allation Installing the Printer Driver Inst alling the Printer Driver T o install the P100 i Printer on W indow s 2000, W indows XP , W indow.
Pagina 19

Printer Inst allation Installing the Printer Driver 980590-001 Rev . A P100 i User ’s Manual 15 Print Driver Inst allation Install the P100 i Prin ter driver as follows: 1. Insert the P100 i User Documentation and Drivers CD into th e CD drive of the host computer .
Pagina 20

16 P100 i User ’s Manual 980590-001 Rev . A Printer Inst allation Installing the Printer Driver 4. The InstallShield Wizard will launch, and a progress window will be displ a yed. 5. Once the InstallShield W izard has been installed, the W elcome to InstallShiel d Wizard window will open.
Pagina 21

Printer Inst allation Installing the Printer Driver 980590-001 Rev . A P100 i User ’s Manual 17 The next two sections detai l USB Driver Install a tion and Ethernet Dri ver Installation respectively . USB Driver Inst allation 1. Select USB, and cli ck the Next button.
Pagina 22

18 P100 i User ’s Manual 980590-001 Rev . A Printer Inst allation Installing the Printer Driver 4. Select the appropriate Program Folde r, then click the N ext button. 5. The Install W izard will sh ow the progress of the installation. 6. Read the app ropriate information.
Pagina 23

Printer Inst allation Installing the Printer Driver 980590-001 Rev . A P100 i User ’s Manual 19 8. Driver installation is now co mp lete. Click the Finish button. 9. After installing the Driv er , restart your computer . When y ou apply power to the p rinter , the W indows New Hardware Fo un d wi zard wi ll fi nd the printer .
Pagina 24

20 P100 i User ’s Manual 980590-001 Rev . A Printer Inst allation Installing the Printer Driver 3. Most users should select the Comp lete setup type; then click the N ext button.
Pagina 25

Printer Inst allation Installing the Printer Driver 980590-001 Rev . A P100 i User ’s Manual 21 5. Select the appropriate Program Folde r, then click the N ext button.
Pagina 26

22 P100 i User ’s Manual 980590-001 Rev . A Printer Inst allation Setting Printer Driver Options Setting Printer Driver Options Y ou can change the defa ult setti ngs for the P100 i printe r driver . Change the options as follows: 1. Select S tart > Settings > Printers and Fa xes to bring up a listing of connected printers.
Pagina 27

Printer Inst allation Setting Printer Driver Options 980590-001 Rev . A P100 i User ’s Manual 23 4. On the Sharing ta b, you can choose to share t he printer over the network , and install additional drivers to accommodat e different operating systems.
Pagina 28

24 P100 i User ’s Manual 980590-001 Rev . A Printer Inst allation Setting Printer Driver Options 6. On the Color Management tab, you can add, remove, or change printer co lor profiles. 7. Use the Security tab to chan ge permissions for the P1 00 i Printer .
Pagina 29

Printer Inst allation Setting Printer Driver Options 980590-001 Rev . A P100 i User ’s Manual 25 8. On the Advanced tab, you can cho ose vari ous printer prop erties, install di fferent printer drivers, and change de fault printer setting s . 9. On the Device Settings tab, you can check the Firmware V ersion insta lled on the printer .
Pagina 30

26 P100 i User ’s Manual 980590-001 Rev . A Printer Inst allation Setting Printer Driver Options 10. Under the Devic e Settings tab, if you selec t Encoder Settings, a button “Properties” will open next to the Encoder Set tings. Click that Properties button, and the foll owi ng screen will appear .
Pagina 31

980590-001 Rev . A P100 i User ’s Manual 27 3 P100 i Printer Setup Printer Features The following sh ows an interior view of yo ur P100 i Printer . Lid Print Head Ribbon Cartridge Card Cleaning Cart.
Pagina 32

28 P100 i User ’s Manual 980590-001 Rev . A P100i Printer Setup Loading Ribbon Cartri dge Loading Ribbon Cartridge The P100 i Printer requires appr oved ribbon cartridges. The Resin Thermal T ransfer and Dye Sublimation ribbons are specifi cally designed fo r yo ur P100 i Printe r .
Pagina 33

P100i Printer Setup Loading Ribbon Cartri dge 980590-001 Rev . A P100 i User ’s Manual 29 3. Insert the ribb on cartridge with the c leaning ro ller facing down, so th e gears on the ends of the rollers fit i nto the appropriate slots.
Pagina 34

30 P100 i User ’s Manual 980590-001 Rev . A P100i Printer Setup Installing the Cleaning Cartridge Inst alling the Cleaning Cartridge The Cleaning Cartridge removes surface dust pa rt ic les a nd oi l from t he card surface , resu lti ng in better pr inting.
Pagina 35

P100i Printer Setup Installing the Cleaning Cartridge 980590-001 Rev . A P100 i User ’s Manual 31 3. Gently squeeze the clips and lift the Cl eaning Cartridge free of the printe r . 4. Lift the lid of the Cleanin g Cartridge. A new printer will have a Cleaning Roller with its protective wrapping.
Pagina 36

32 P100 i User ’s Manual 980590-001 Rev . A P100i Printer Setup Installing the Cleaning Cartridge 7. Place the C leaning Ro ller in the Cartridge, cl ose the lid, and insert it in place so the latches engag e. 8. Close the print er lid, and push down until you hear an audible cl ick .
Pagina 37

P100i Printer Setup Inserting Cards 980590-001 Rev . A P100 i User ’s Manual 33 Inserting Cards Cards are insert ed one at a time in to the slot on th e front of the P1 00 i . The card is printed on the top surface and ejected out through the same slot.
Pagina 38

34 P100 i User ’s Manual 980590-001 Rev . A P100i Printer Setup Printing a T est Card Printing a T est Card W ith Ribbon Cartridge and Card Cl ean ing Cartridge loaded, your P1 00 i Prin ter is ready t o print. T o check the operation of the prin ter , you should pri nt a test card.
Pagina 39

P100i Printer Setup Printing a T est Card 980590-001 Rev . A P100 i User ’s Manual 35 S toring Extra Cards and Cleaning Rollers The P100 i Printer includes a storage area where you can keep up to 100 extra cards (four groups of 2 5 cards) and up to three extra Cleaning Rollers.
Pagina 40

36 P100 i User ’s Manual 980590-001 Rev . A.
Pagina 41

980590-001 Rev . A P100 i User ’s Manual 37 4 P100 i Printer Operation Printing Printing with the P100 i Printer requires the W indows Prin ter Driver , you r card desi gn/issu ing software or p rinter command level programming through the printer interface.
Pagina 42

38 P100 i User ’s Manual 980590-001 Rev . A P100i Printer Operation Printing Creating a Sample Card Before you begi n a new printing session, print a sample card to ensure that t he cards will be printed correc tly .
Pagina 43

P100i Printer Ope ration Printing 980590-001 Rev . A P100 i User ’s Manual 39 Printing a Sample Card Once you comp leted creatin g your samp le card, you are ready to print. Ensure you r printer has a T rue Colours ™ Card Printer Ribbon Cartri dge i nstalled.
Pagina 44

40 P100 i User ’s Manual 980590-001 Rev . A.
Pagina 45

980590-001 Rev . A P100 i User ’s Manual 41 5 Cleaning Cleaning the System Y our P100 i Printer includes a simple cleaning system using Pre-Satura ted Cleaning Cards provided.
Pagina 46

42 P100 i User ’s Manual 980590-001 Rev . A Cleaning Cleaning the System How to Clean 1. Leave power on. 2. Press and hold the M ulti-Function Control But ton for 5 seconds. 3. When the clean ing cycle is initiated, the LCD message REMOVE RIBBON THEN CLOSE LID will display .
Pagina 47

Cleaning Cleaning the Printhead 980590-001 Rev . A P100 i User ’s Manual 43 Cleaning the Printhead Use of the cleaning cards will no rmal ly do an adequate jo b of cleaning the pri nter . However , a separate Printhead cleaning, using swabs, can remove more stubborn deposits when print anomalies persist.
Pagina 48

44 P100 i User ’s Manual 980590-001 Rev . A.
Pagina 49

980590-001 Rev . A P100 i User ’s Manual 45 6 Troubleshooting T roubleshooting Procedures LCD Panel W arnings and Error Messages * If the problem p ersists, co ntact T echnical Support; s ee App endi x D .
Pagina 50

46 P100 i User ’s Manual 980590-001 Rev . A T roubleshooting T roubleshooting Procedures * If the problem p ersists, co ntact T echnical Support; s ee App endi x D . ERROR MESSAGES (printer will not operate) Problem / Sympt om Description or Cause Possible So lution * CHECK RIBBON Ribbon may be improperly installed.
Pagina 51

T roubleshooting T roub leshooting Pr ocedures 980590-001 Rev . A P100 i User ’s Manual 47 Print Quality Issues This section will help you resolve print q uality problems The print q uality is dependent on several factors. The two most important factor s that will increase your prin t quality are cleanliness and card stock.
Pagina 52

48 P100 i User ’s Manual 980590-001 Rev . A T roubleshooting T roubleshooting Procedures Example • There are non-printi ng horizontal l i nes (white) on the card surfaces.
Pagina 53

T roubleshooting T roub leshooting Pr ocedures 980590-001 Rev . A P100 i User ’s Manual 49 Example • Printing shows very pal e or inconsistent results. Possible Cause: • Ribbon cartrid ge have been stored improp er ly or is damaged. Solution: • Change ribbon ca r t r i dg e and print again.
Pagina 54

50 P100 i User ’s Manual 980590-001 Rev . A T roubleshooting T roubleshooting Procedures Example • Printing shows blurry printed image. Possible Cause: • Ribbon cartridge may not be correctly positioned. Solutions: • Check that the ribb on is properly roll ed onto the ribbon cores of t he ca r t r i dg e , w i th no wrinkles.
Pagina 55

T roubleshooting T roub leshooting Pr ocedures 980590-001 Rev . A P100 i User ’s Manual 51 Example • No printing on the card. Possible Cause: • Ribbon c ar tridge may no t be install ed in the print er . Solution: • Check for ri bbon c a r t ri d g e in the printe r .
Pagina 56

52 P100 i User ’s Manual 980590-001 Rev . A T roubleshooting T roubleshooting the Ethernet Conn ection and Adapter T roubleshooting the Ethernet Connection and Adapter Ethernet Adapter St atus Indicator A bi-color Status Indicator displays the op erational status of the Ethernet Adapter .
Pagina 57

T roubleshooting T roubleshooting the Ethern et Co nnection and Adapter 980590-001 Rev . A P100 i User ’s Manual 53 3. If the LED is slowly flashing GREEN (1 time/sec), the Ethern et Adapt er is trying to print a job. If the job does not print, che ck the following: • V erify t hat the printer has media and ribb on.
Pagina 58

54 P100 i User ’s Manual 980590-001 Rev . A T roubleshooting T roubleshooting the Ethernet Conn ection and Adapter Network S tatus/Activity Indicator A bi-color Network Status/Activity LED indi cat es network speed, establis hed link, and network activit y .
Pagina 59

T roubleshooting T roubleshooting the Ethern et Co nnection and Adapter 980590-001 Rev . A P100 i User ’s Manual 55 Resetting to Fa ctory Default s T o reset the Ethernet Adapter config uration parameters to the factory defaults: 1. Press the Ethernet Reset Button, and h old it in while turning t he printer power ON ( | ).
Pagina 60

56 P100 i User ’s Manual 980590-001 Rev . A.
Pagina 61

980590-001 Rev . A P100 i User ’s Manual 57 7 Technical Specifications Printer S pecifications General • Load-N-Go TM drop-in ribb on cartridge • 1 6-digit LCD display • Driver for W indows 20.
Pagina 62

58 P100 i User ’s Manual 980590-001 Rev . A T echnical Specifications Printer S pecifications Ribbon Cartridges • Load-N-Go TM ribbon cartridge w ith inte grated card-cleaning roller • i Series .
Pagina 63

T echnical Specifications Card Dimensions 980590-001 Rev . A P100 i User ’s Manual 59 Card Dimensions ISO st andard dimensions for plain card ISO st andard dimensions for magnetic stripe card 980504-07-01 2.125 ± 0.002 in (53.98 ± 0.050 mm) Radius 0.
Pagina 64

60 P100 i User ’s Manual 980590-001 Rev . A T echnical Specifications Declarations of Conformity Declarations of Conformity For a formal certificate, please contact the Compliance Of fice at Zebra’ s Camarillo facility . EUROPE: Norway Only: This prod uct is also designed for IT power system with phase-to- phase voltage 230V .
Pagina 65

980590-001 Rev . A P100 i User ’s Manual 61 Appendix A Magnetic Encoder Introduction This section contains information on the additional operations of the P100 i Printers with a Magnetic Encoder . The magnetic encoder can be set for either high coercivity (H iC o) or lo w coe rc iv ity (LoCo).
Pagina 66

62 P100 i User ’s Manual 980590-001 Rev . A Magnetic Encoder Media Loading Orie ntation Media Loadin g Orient ation When loading cards with magnetic stripes int o th e card feed er , ensure th at the magne ti c stripe is toward the righ t side when facing the p rinter and down, as sho wn b elow .
Pagina 67

Magnetic En coder ISO S tandard Enc od ing 980590-001 Rev . A P100 i User ’s Manual 63 ISO S tandard Encoding *B i t s p e r i n c h † Except the “?” ch ara cter ‡ Including S tart, Stop, and LRC characte rs. Note that these three characters ar e automatically managed by the magne tic encoder according to the ISO Standard Norms.
Pagina 68

64 P100 i User ’s Manual 980590-001 Rev . A.
Pagina 69

980590-001 Rev . A P100 i User ’s Manual 65 Appendix B Smart Card Encoder Introduction This section contains information on the additional operations of a P100 i Printer equipped with optional contact and/ or contactless smart card encoders. Smart cards can have a b uilt-in microprocessor and/or memory .
Pagina 70

66 P100 i User ’s Manual 980590-001 Rev . A Smart Card Encoder Printing on Smart Cards Cont actless Smart cards For contactless smart-cards, o rientation is not a consideratio n (unless the card will be prin ted on; see belo w).
Pagina 71

980590-001 Rev . A P100 i User ’s Manual 67 Appendix C Connecting to a Network Card printers can be connect ed to an Ethernet network in three ways. Printer Sharing In printer sharing, the printer is connected loc ally to the host computer and configured to be shared to other client computer s.
Pagina 72

68 P100 i User ’s Manual 980590-001 Rev . A Connecting to a Network External Print Server External Print Server A stand alone device that acts as a server on the network specifically for receiving print jobs and passing t hem to the prin ter . Client comp uters connec t to the print server over a ne twork.
Pagina 73

980590-001 Rev . A P100 i User ’s Manual 69 Appendix D Worldwide Support For T echn ical Support or Repair Services, co ntact the appropriate facility listed below . North America - T echnical Support Zebra T echnologies Card Printer Solutions 1001 Flynn Road Camarillo, CA 93012-87 06 USA Phone: 1-80 0-51 1- 9909 email: techsupport@zebra .
Pagina 74

70 P100 i User ’s Manual 980590-001 Rev . A Worldwid e Support Europe, Middle East, and Africa - T echnical Supp ort Zebra T echnologies Ca rd Printer Solutions The V alley Centre, Gordon Road High W ycombe Buckinghamshire HP13 6EQ United Kingdom Phone: + 44 (0) 870 241 1527 e-mail: cardts@zebra.
Pagina 75

Worldwide Su pport 980590-001 Rev . A P100 i User ’s Manual 71 Latin America - Rep air Services (Please contact North America Repair Services.) Asia Pacific - T echnical Su pport and Repair Services.
Pagina 76

72 P100 i User ’s Manual 980590-001 Rev . A.

Lees een handleiding Zebra Technologies P100iTM - vermijd mogelijke problemen

Een belangrijk punt na aankoop van elk apparaat Zebra Technologies P100iTM (of zelfs voordat je het koopt) is om de handleiding te lezen. Dit moeten wij doen vanwege een paar simpele redenen:

om te weten hoe het apparaat juist te gebruiken
om te weten, hoe het product te onderhouden/het uitvoeren van periodieke keuringen Zebra Technologies P100iTM
om te weten hoe de mogelijke storingen te verwijderen Zebra Technologies P100iTM

Als u nog geen Zebra Technologies P100iTM heb gekocht dan nu is een goed moment om kennis te maken met de basisgegevens van het product. Eerst kijk dan naar de eerste pagina\'s van de handleiding, die je hierboven vindt. Je moet daar de belangrijkste technische gegevens Zebra Technologies P100iTM vinden. Op dit manier kan je controleren of het apparaat aan jouw behoeften voldoet. Op de volgende pagina's van de handleiding Zebra Technologies P100iTM leer je over alle kenmerken van het product en krijg je informatie over de werking. De informatie die je over Zebra Technologies P100iTM krijgt, zal je zeker helpen om een besluit over de aankoop te nemen.

In een situatie waarin je al een beziter van Zebra Technologies P100iTM bent, maar toch heb je de instructies niet gelezen, moet je het doen voor de hierboven beschreven redenen. Je zult dan weten of je goed de alle beschikbare functies heb gebruikt, en of je fouten heb gemaakt die het leven van de Zebra Technologies P100iTM kunnen verkorten.

Maar de belangrijkste taak van de handleiding is om de gebruiker bij het oplossen van problemen te helpen met Zebra Technologies P100iTM . Bijna altijd, zal je daar het vinden Troubleshooting met de meest voorkomende storingen en defecten #MANUAl# samen met de instructies over hun opplosinge. Zelfs als je zelf niet kan om het probleem op te lossen, zal de instructie je de weg wijzen naar verdere andere procedure, bijv. door contact met de klantenservice of het dichtstbijzijnde servicecentrum.

Zebra Technologies P100iTM handleiding

Deel URL

Vergelijkbare instructies

Deel URL

Vergelijkbare instructies

Samenvatting van de inhoud op de volgende paginas van de handleiding

Pagina 1

Pagina 2

Pagina 3

Pagina 4

Pagina 5

Pagina 6

Pagina 7

Pagina 8

Pagina 9

Pagina 10

Pagina 11

Pagina 12

Pagina 13

Pagina 14

Pagina 15

Pagina 16

Pagina 17

Pagina 18

Pagina 19

Pagina 20

Pagina 21

Pagina 22

Pagina 23

Pagina 24

Pagina 25

Pagina 26

Pagina 27

Pagina 28

Pagina 29

Pagina 30

Pagina 31

Pagina 32

Pagina 33

Pagina 34

Pagina 35

Pagina 36

Pagina 37

Pagina 38

Pagina 39

Pagina 40

Pagina 41

Pagina 42

Pagina 43

Pagina 44

Pagina 45

Pagina 46

Pagina 47

Pagina 48

Pagina 49

Pagina 50

Pagina 51

Pagina 52

Pagina 53

Pagina 54

Pagina 55

Pagina 56

Pagina 57

Pagina 58

Pagina 59

Pagina 60

Pagina 61

Pagina 62

Pagina 63

Pagina 64

Pagina 65

Pagina 66

Pagina 67

Pagina 68

Pagina 69

Pagina 70

Pagina 71

Pagina 72

Pagina 73

Pagina 74