Gebruiksaanwijzing /service van het product 8740 van de fabrikant Bloomfield
Ga naar pagina of 22
PRINTED IN UNITED ST A TES OF AMERICA WELLS BLOOMFIELD , LLC 2 ERIK CIRCLE, P . O. Box 280 V erdi, NV 89439 telephone: 775-689-5707 fax: 775-689-5976 www .
608 p/n 76467 8740 Tea B rewer Owners Manual NOTE: For your protection, please note that equipment in this shipment was carefully inspected and packaged by skilled personnel before leaving the factory. Upon acceptance of this shipment, the transportation company assumes full responsibility for its safe delivery.
This manual applies to the following Wells Bloomfield product: 8740 3 - 5 Gallon Tea Brewer MODEL DIMENSIONS VOLTS WATTS AMPS 1ø POWER SUPPLY CORD 8740 3 - 5 Gallon Iced Tea Brewer 34-1/4" high .
FEATURES AND OPERATING CONTROLS 2 Fig. 1 Model 8740 Features and Operating Controls 608 p/n 76467 8740 Tea B rewer Owners Manual.
PRECAUTIONS AND GENERAL INFORMATION 3 WARNING: Electric Shock Hazard All servicing requiring access to no n-in sulated components must be performed by qualified service personnel. Do not open any access pan els which requir e the use of tools. Failure to heed this warn- ing can result in electri cal shock.
INSTALLATION 4 READ THIS CAREFULL Y BEFORE ST ARTING THE I NST ALLA TION Unpack the unit. Inspect all component s for completeness and condition. Ensure that all packing materials have bee n remove d from the unit. Verify that the Spray Head Gasket and Spray Disk are prop erly installed.
INSTALLATION (continued) 5 WARNING SHOCK HAZARD Brewer must be properly grounded to prevent possible shock hazard . DO NOT assume a plumbing line will provide such a ground. Electrical shock will cause death or serio us inj ury. IMPORTANT: Supply power must match nameplate for voltage and phase.
OPERATION Fig. 4 Brewer Operation Diagram A. START-UP For initial start-up, or if the bre we r ha s n ot been used for an extended period of time: ♦ Be sure spray disk and brew gasket are prop erly installe d in the brew head. ♦ Be sure the water sup ply is properly conne cted and the water supply valve is turned ON .
OPERATION (continued) WATER HEATER Water temperature is sen s ed by a therm obulb inserted into the water tank. This temperature signal is fed to the mechanical thermostat. The temperature setpoint is adjustable. Heating element is energized by the thermostat.
BREWING TEA 8 A. PREPARATION Place one (1) genuin e Bloomfield paper filter into the brew ch ambe r. Add an amount of fresh tea leaves to the brew chamber ap propriate to the brew volume. NOTE: the brewer can bre w any volume between 3 and 5 gallon s, and is factory set for a 3 ga llons brew volume.
CLEANING INSTRUCTIONS PROCEDURE: Clean Tea Brewer PRECAUTIONS: Disconnect br ewer from electric power. Allow brewer to cool. FREQUENCY: Daily TOOLS: Mild Detergent, Clean Soft Cloth or Sponge Bristle Brush, Bottle Brush 1. Disconnect brewer from electric power.
TROUBLESHOOTING SUGGESTIONS SUGGESTED REMEDY Check power sup ply cord Check / reset cir cuit breaker Press switch to ON Set for desired temperature Allow to cool hi-limit will self- reset Examine wiri.
SERVICING INSTRUCTIONS CAUTION: SHOCK HAZARD Opening access panels on this brew may expose uninsulated electrical components. Disconnect brewer from electrical power before removing any panel. NOTE ; Time and temperature cont rols may be accessed without removing cabinet panels b y removing the appropriate hole plug from the top wrap.
SERVICING INSTRUCTIONS (continued) 12 TEMPERATURE ADJUSTMENT Energize brewer and allow unit to heat. When the READY TO BREW light first glows, read the temperature. Thermostat may be adjusted by removi ng the right b utton plug. Carefully check the water temperat ure at the outlet of the brew chamber.
SERVICING INSTRUCTIONS (continued) IMPORTANT: Water p ressure must be between 20 p.s.i and 90 p.s.i. flowing pressure. If water pressure exceeds this value, or if water pressure varies greatly, a pressure regulator must be installed in the water supply line.
SERVICING INSTRUCTIONS (continued) REPLACE SOLENOID Symptom: Automatic brewer will not flow water; or, automatic brewer drips continuou sly from bre w head. Unplug power co rd o r turn circuit breaker OFF . Turn OFF and disconnect water supply from brewer inl et fitting.
SERVICING INSTRUCTIONS (continued) 15 CAUTION: CHEMICAL BURN HAZARD Deliming chemical s are ca ustic. Wear appropriate protective gloves and goggles during this procedure. Never siphon deliming chemicals or soluti o ns by mouth. This operation should only be performed by qualified and experienced service personnel.
EXPLODED VIEW & PARTS LIST 16 608 p/n 76467 8740 Tea B rewer Owners Manual 42 1 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 2 18 19 20 21 22 24 23 25 26 27 28 29 31 32 33 34 35 36 37 38 39 40 41 43 44 B.
EXPLODED VIEW & PARTS LIST (continued) ITEM PART # DESCRIPTION 1 WRAP, TOP COVER 2 82186 SPRAY DISK 3 8043 -15 VENT, TUBE SHORT 8512-15 THERMOSTAT 86280 THERMOSTAT (ALTERNATE) 5 82241 CONNECTOR 6 .
SERVICE KITS 18 SERVICE KITS SOLENOID REPAIR KITS 83282 Solenoid, Complete, Dual 85218 Inlet Fitting Kit (includes cap, inlet fitting, washer and screen) 85219 Inlet Strainer 608 p/n 76467 8740 Tea B .
WIRING DIAGRAM 19 608 p/n 76467 8740 Tea B rewer Owners Manual.
Genuine Parts Protect - YOU - All - W ays SER VICE TRAINING - QUALITY SERVICE SER VICE TRAINING - QUALITY SERVICE CUSTOMER SA TISF ACTION CUSTOMER SA TISF ACTION Wells Bloomfield proudly supports CFES.
Een belangrijk punt na aankoop van elk apparaat Bloomfield 8740 (of zelfs voordat je het koopt) is om de handleiding te lezen. Dit moeten wij doen vanwege een paar simpele redenen:
Als u nog geen Bloomfield 8740 heb gekocht dan nu is een goed moment om kennis te maken met de basisgegevens van het product. Eerst kijk dan naar de eerste pagina\'s van de handleiding, die je hierboven vindt. Je moet daar de belangrijkste technische gegevens Bloomfield 8740 vinden. Op dit manier kan je controleren of het apparaat aan jouw behoeften voldoet. Op de volgende pagina's van de handleiding Bloomfield 8740 leer je over alle kenmerken van het product en krijg je informatie over de werking. De informatie die je over Bloomfield 8740 krijgt, zal je zeker helpen om een besluit over de aankoop te nemen.
In een situatie waarin je al een beziter van Bloomfield 8740 bent, maar toch heb je de instructies niet gelezen, moet je het doen voor de hierboven beschreven redenen. Je zult dan weten of je goed de alle beschikbare functies heb gebruikt, en of je fouten heb gemaakt die het leven van de Bloomfield 8740 kunnen verkorten.
Maar de belangrijkste taak van de handleiding is om de gebruiker bij het oplossen van problemen te helpen met Bloomfield 8740 . Bijna altijd, zal je daar het vinden Troubleshooting met de meest voorkomende storingen en defecten #MANUAl# samen met de instructies over hun opplosinge. Zelfs als je zelf niet kan om het probleem op te lossen, zal de instructie je de weg wijzen naar verdere andere procedure, bijv. door contact met de klantenservice of het dichtstbijzijnde servicecentrum.
