Gebruiksaanwijzing /service van het product GWH 1000 van de fabrikant Bosch
Ga naar pagina of 28
M O DE L G W H 1 0 0 0 P I N D OOR MOD E L Stand ing pilot Suit able fo r heat ing pot abl e wat er only Not app roved for spac e heat ing or preheat ed wa ter applic at ions MODE L GWH 100 0 P NG - Na tural Gas MODE L GWH 100 0 P LP - Liqu efied Pet roleum (LP ) Gas 6 720 608 124 US (06.
6 720 608 124 2 Index Index 1 Warning 2 2 Appliance d etails 3 2.1 GWH 1000 P specifications (Technic al data) 3 2.2 Unpacking the GWH 1000 P heater 4 2.3 General rules to follow for safe opera tion 4 2.4 Dimensions an d installation clearances 5 3 Installation instructions 6 3.
6 720 608 124 Appliance detai ls 3 2 Applian ce details 2.1 GWH 1000 P specifications (Technical data) Approved in US/Canada Capacity GWH 1000 P : 2.6 GPM Maximum out put GWH 1000 P : 58 400 Btu/hr Maximum in put GWH 1000 P : 74 900 Btu/hr Efficiency in % Recovery effic iency 78% Min.
6 720 608 124 4 Appliance de tails 2.2 Unpacking the GWH 1000 P heater This heater is p acked securely. Before installing the unit, be certain you have the correct heater f or you r type of G as - Prop ane or Natural Gas.
6 720 608 124 Appliance detai ls 5 2.4 Dimensions and installation clearances Fig. 3 Dimensions in Inches and (mm) 4 Heat exchanger 5 Burn er 10 Tem perature co ntrol 11 Wa ter valve 20 G as connectio.
6 720 60 8 124 6 Installation instructions 3 Installat ion instruc tions 3.1 Introduction Please foll ow these i nstructions. Failu re to follow instructions m ay result in: B Damage or i njury.
6 720 60 8 124 Installation instructions 7 3.4 Mounting Heater Remove cov er and inspect. B Remove the temp erature control. B Remove the ou ter case by pulling it fo rwards and then lifting upwar ds. B Ensure that the flue terminal is clear. B After inspection , replace front cover.
6 720 60 8 124 8 Installation instructions 3.5 Combustion air requirements The Aq uaStar water heater holds cold water in its copper heat exchanger and water valve when n ot in u se. Because of this, any cold air th at comes down through the unit's ve nt pipe is capable of freezing these components.
6 720 60 8 124 Installation instructions 9 3.6 Venting B Minimum vent p ipe diameter: 4 inches B Minimum vertic al vent height: 6 feet, wi th no elbows B Establish 12 in ch rise before any elbow The heater must be vente d to t he outside following all local o rdinances and specificat ions for installing a gas appliance vent or ch imney.
6 720 60 8 124 10 Installation instructions Masonry chim ney Masonry chimneys sh all be built and installed in accordance with NFPS 211 or local codes.
6 720 60 8 124 Installation instructions 11 3.7 Gas piping & connections Before connecting the gas suppl y, check the rat ing plate on the r ight si de of the heater to be sure that t he heater is rated for the same gas to whic h i t wil l be connected.
6 720 60 8 124 12 Installation instructions FOR NA TU R AL GAS Maximum Cap acity of pipe in Cubic Fee t of Gas per Hour for Ga s Pressure of 0.5 Psig or le ss and a Pressure drop of 0.3 in Wate r Column (0.75mbar). (Based on a 0.60 Specific Gravity Gas) Btu numb ers given in thousands .
6 720 60 8 124 Installation instructions 13 3.8 Measuring gas pressure Connectin g manometer B Shut off gas. B Remove front cover and loc ate inlet gas pressure measuring point o n the right side, see Fig. 14. B Loosen screw f rom test point on the ri ght side and connect manome ter tube on test point.
6 720 60 8 124 14 Operation inst ructions Fig. 15 Plumbing conne ctions and pressure relief valve show n with o ptional Webstone service valves 3.10 Recirculation application Since recirculation throu.
6 720 60 8 124 Operation inst ructions 15 4.2 Lighting instructions B STOP! Read t he previous safety informati on. B The gas valve must be turned off by s liding the gas valve button to all the way to the left. Fig. 17 B Wait five (5 ) minutes to clear out an y gas.
6 720 60 8 124 16 Operation inst ructions ensure that the hot water temperatu re will rem ain steady, a lthough the w ater flow demand might vary. The output temperature can be adjusted with either the temperature adjustment knob or the ga s control slide.
6 720 60 8 124 Maintenance a nd service 17 5 Mainten ance and service 5.1 Maintenance intervals The GWH 1000 P requires periodic maintenance. The below time ma intenance intervals sh ould keep the unit operating for m any years. Every year B Inspect inlet w ater filter screen ( 5.
6 720 60 8 124 18 Maintenance and service 5.4 Main burners The ma in burner flames should be blue, w ith a mo re intense blue c one in the center core. Yellow f lames could be a sign of wrong size gas orifices or dirty burners, a blockage on the heat exchangers fins.
6 720 60 8 124 Troubleshooti ng 19 6 Troubles hooting 6.1 Introduction Many of the que stions customers ask rega rding operation of this unit c an be answere d by following the troubleshoot ing steps as outlined below. Visi t our web site at www.bosch hotwater.
6 720 60 8 124 20 Troubleshoot ing heat exch anger are available a t www.boschhot water.com. 8. If s teps 1 through 7 do not correct the problem, then confirm t hat the gas pressure is adequate. Ensure gas pressure is in acc ordance w ith m anufacturer's specifications ( see Chapter 3.
6 720 60 8 124 Troubleshooti ng 21 2. Adjus t the gas cont rol slide button from three f lame position towards the one flame posi tion for coo ler temperatures. If the w ater is st ill too hot , the temperature adjust ment knob on the water heater maybe set t oo high.
6 720 60 8 124 22 Troubleshoot ing 6.11 Noise when heater is running 1. Confirm a dequate flow rate throug h the unit. Wit h cold supply shu t off to t he unit, d isconnect hot outlet side t o the unit. Place a half gallon jug under hot ou tlet to ca tch water.
6 720 60 8 124 Protecting t he environment 23 7 Protectin g the en vironment Packing The p acking bo x may be fully recycled a s confirmed by the recyclin g symbol . Componen ts Many parts in th e heater c an be fully r ecycled in the end of the product life.
6 720 60 8 124 24 Interior compon ents and diagram parts list 8 Interior component s and diagr am parts l ist 8.1 I nterior components Fig. 27 Functional s cheme 4 Hea t exch anger 5 Bur ner 10 Tem pe.
6 720 60 8 124 Interior compon ents and diagram parts list 25 8.2 Components diagram Fig. 28 Componen ts Diagram 50 49 32 48 46 45 43 28 29 30 31 25 17 18 19 20 21 23 26 24 27 33 34 35 13 36 37 22 38 39 40 41 42 44 47 8 9 11 12 13 14 15 16 10 6 4 5 51 52 1 2 3 7 6720 6081 24- 10.
6 720 60 8 124 26 Interior compon ents and diagram parts list 8.3 Par ts list Item Description Re ference 1 Front cover 8 705 431 243 0 2 Shield 8 705 506 759 0 3 T emp .
6 720 60 8 124 Twelve Yea r Limited Warranty 27 9 Twelve Y ear Limited Warrant y General Aquastar w ater heaters are warranted by the Manufactur er (B OSCH) throug h BBT No rth America.
Recycled pape r © 200 6 B BT NO RTH AM E R I CA C O R PO RA TI ON , W aits field, VT all rights reser ved Installe r Checklist, to be pe rformed by installer upo n install ation Serial Numbe r ___ __.
Een belangrijk punt na aankoop van elk apparaat Bosch GWH 1000 (of zelfs voordat je het koopt) is om de handleiding te lezen. Dit moeten wij doen vanwege een paar simpele redenen:
Als u nog geen Bosch GWH 1000 heb gekocht dan nu is een goed moment om kennis te maken met de basisgegevens van het product. Eerst kijk dan naar de eerste pagina\'s van de handleiding, die je hierboven vindt. Je moet daar de belangrijkste technische gegevens Bosch GWH 1000 vinden. Op dit manier kan je controleren of het apparaat aan jouw behoeften voldoet. Op de volgende pagina's van de handleiding Bosch GWH 1000 leer je over alle kenmerken van het product en krijg je informatie over de werking. De informatie die je over Bosch GWH 1000 krijgt, zal je zeker helpen om een besluit over de aankoop te nemen.
In een situatie waarin je al een beziter van Bosch GWH 1000 bent, maar toch heb je de instructies niet gelezen, moet je het doen voor de hierboven beschreven redenen. Je zult dan weten of je goed de alle beschikbare functies heb gebruikt, en of je fouten heb gemaakt die het leven van de Bosch GWH 1000 kunnen verkorten.
Maar de belangrijkste taak van de handleiding is om de gebruiker bij het oplossen van problemen te helpen met Bosch GWH 1000 . Bijna altijd, zal je daar het vinden Troubleshooting met de meest voorkomende storingen en defecten #MANUAl# samen met de instructies over hun opplosinge. Zelfs als je zelf niet kan om het probleem op te lossen, zal de instructie je de weg wijzen naar verdere andere procedure, bijv. door contact met de klantenservice of het dichtstbijzijnde servicecentrum.
