Gebruiksaanwijzing /service van het product FAS-10BB van de fabrikant Desa
Ga naar pagina of 26
Save this manual for future reference. BLUE FLAME VENT -FREE N A TURAL GAS HEA TER OWNER’S OPERA TION AND INST ALLA TION MANUAL F A-10BA, F AS-10BB, and F A-60BA 10,000 and 6,000 Btu/Hr Thermostat a.
2 105564 NA TURAL GAS HEA TER SAFETY INFORMA TION WARNINGS IMPORTANT: Read this owner’s manual carefully and completely before trying to assemble, oper- ate, or service this heater. Im- proper use of this heater can cause serious injury or death from burns, fire, explosion, and car- bon monoxide poisoning.
3 105564 OWNER’S MANUAL PRODUCT IDENTIFICA TION Figure 1 - Vent-Free Natural Gas Heater (Model FA-10BA Shown) Control Knob Heater Cabinet Grill Guard Glass Panel Front Panel LOCAL CODES Install and use heater with care. Follow all local codes. In the absence of local codes, use the latest edition of The National Fuel Gas Code ANS Z223.
4 105564 NA TURAL GAS HEA TER FRESH AIR FOR COMBUSTION AND VENTILA TION WARNING: This heater shall not be installed in a confined space or unusually tight construction unless provisions are provided for adequate combustion and ven- tilation air.
5 105564 OWNER’S MANUAL WARNING: If the area in which the heater may be operated is smaller than that defined as an unconfined space or if the building is of unusually tight construction, provide adequate combustion and ventilation air by one of the methods described in the National Fuel Gas Code, ANS Z223.
6 105564 NA TURAL GAS HEA TER FRESH AIR FOR COMBUSTION AND VENTILA TION Continued Figure 2 - Ventilation Air from Inside Building Figure 3 - Ventilation Air from Outdoors Ventilation Air From Outdoors Provide extra fresh air by using ventilation grills or ducts.
7 105564 OWNER’S MANUAL For convenience and efficiency, install heater • where there is easy access for operation, inspection, and service • in coldest part of room Figure 4 - Mounting Clearance.
8 105564 NA TURAL GAS HEA TER INST ALLA TION Continued Attaching Mounting Bracket To Wall Note: Wall anchors, mounting screws, and spacers are in hardware package. The hard- ware package is provided with heater. Attaching To Wall Stud Method For attaching mounting bracket to wall studs 1.
9 105564 OWNER’S MANUAL Tee Joint Reducer Bushing to 1/8" NPT 1/8" NPT Plug Tap Figure 13 - Gas Connection * An CSA/AGA design-certified equipment shutoff valve with 1/8" NPT tap is an acceptable alternative to test gauge connection. Purchase the optional CSA/AGA design- certified equipment shutoff valve from your dealer.
10 105564 NA TURAL GAS HEA TER Gas Meter Control Valve Location Equipment Shutoff Valve CHECKING GAS CONNECTIONS WARNING: Test all gas pip- ing and connections for leaks after installation or servicing. Correct all leaks at once. WARNING: Never use an open flame to check for a leak.
11 105564 OWNER’S MANUAL TO TURN OFF GAS TO APPLIANCE 1. Remove fr ont panel (see Figure 7, page 8). 2. Follow steps 1 thr ough 5 under Light- ing Instructions . 3. With contr ol knob pr essed in, str ike match. Hold match to pilot until pi- lot lights.
12 105564 NA TURAL GAS HEA TER THERMOSTAT MODEL FBS-10BB FOR YOUR SAFETY READ BEFORE LIGHTING A. This appliance has a pilot which must be lighted by hand. When lighting the pilot, follo w these instructions exactly . B . BEFORE LIGHTING smell all around the appliance ar ea for gas.
13 105564 OWNER’S MANUAL BURNER FLAME PATTERN Figure 22 shows a correct burner flame pattern. Figure 23 shows an incorrect burner flame pattern. The incorrect burner flame pattern shows yellow tipping of the flame. It also shows the flame higher than 1/2 the glass panel height.
14 105564 NA TURAL GAS HEA TER Note: All troubleshooting items are listed in order of operation. TROUBLESHOOTING WARNING: Turn off heater and let cool before servicing. Only a qualified service person should service and repair heater. POSSIBLE CAUSE 1.
15 105564 OWNER’S MANUAL OBSERVED PROBLEM Burner does not light after ODS/pilot is lit Delayed ignition of burner Burner backfiring during combustion Yellow flame during burner combustion Slight smo.
16 105564 NA TURAL GAS HEA TER TROUBLESHOOTING Continued WARNING: If you smell gas • Shut off gas supply. • Do not try to light any appliance. • Do not touch any electrical switch; do not use any phone in your building. • Immediately call your gas supplier from a neighbor’s phone.
17 105564 OWNER’S MANUAL FA-10BA FA-60BA FAS-10BB Btu (Variable) 6,000/10,000 6,000 10,000 Type Gas Natural Only Natural Only Natural Only Ignition Piezo Piezo Piezo Pressure Regulator Setting 3" W.C. 3" W.C. 3" W.C. Inlet Gas Pressure (inches of water) Maximum 10.
18 105564 NA TURAL GAS HEA TER Note: Use only original replacement parts. This will protect your warranty coverage for parts replaced under warranty. PARTS UNDER WARRANTY Contact authorized dealer from whom you purchased this product.
19 105564 OWNER’S MANUAL Baltimore Electric 1348 Dixwell Avenue Hamden, CT 06514-0322 1-800-397-7553 203-248-7553 Parts Department Portable Heater Parts 342 N. County Rd. 400 East Valparaiso, IN 46383-9704 All States 219-462-7441 1-800-362-6951 sales@portableheaterparts.
20 105564 NA TURAL GAS HEA TER FA-10BA 28-2 28-1 ILLUSTRA TED P ARTS LIST ODS Pilot Assembly 7 7 32 2 3 19 17 8 9 22 32 31 26 30 27 23 18 28 29 10 21 20 18 30 25 24 22 17 16 13 1 14 15 7 11 12 33 4 5 .
21 105564 OWNER’S MANUAL P ARTS LIST FA-10BA This list contains replaceable parts used in your heater. When ordering parts, follow the instructions listed under Replacement Parts on page 18 of this manual.
22 105564 NA TURAL GAS HEA TER FA-60BA 25-2 25-1 ILLUSTRA TED P ARTS LIST ODS Pilot Assembly 7 7 29 2 3 19 17 8 9 29 28 23 27 24 20 18 25 26 10 18 9 27 22 21 19 17 16 13 1 14 15 7 11 12 30 4 5 7 6 7 7.
23 105564 OWNER’S MANUAL P ARTS LIST FA-60BA This list contains replaceable parts used in your heater. When ordering parts, follow the instructions listed under Replacement Parts on page 18 of this manual.
24 105564 NA TURAL GAS HEA TER FAS-10BB 27-2 27-1 ILLUSTRA TED P ARTS LIST ODS Pilot Assembly 7 7 14 2 3 20 19 14 12 25 8 11 11 13 10 26 22 20 27 28 13 10 24 23 21 19 21 15 1 16 17 7 18 4 5 7 6 7 7 9.
25 105564 OWNER’S MANUAL P ARTS LIST FAS-10BB This list contains replaceable parts used in your heater. When ordering parts, follow the instructions listed under Replacement Parts on page 18 of this manual. KEY PART NO. NO. FAS-10BA DESCRIPTION QTY.
KEEP THIS WARRANTY W ARRANTY INFORMA TION Always specify model and serial numbers when communicating with the factory. We reserve the right to amend these specifications at any time without notice. The only warranty applicable is our standard written warranty.
Een belangrijk punt na aankoop van elk apparaat Desa FAS-10BB (of zelfs voordat je het koopt) is om de handleiding te lezen. Dit moeten wij doen vanwege een paar simpele redenen:
Als u nog geen Desa FAS-10BB heb gekocht dan nu is een goed moment om kennis te maken met de basisgegevens van het product. Eerst kijk dan naar de eerste pagina\'s van de handleiding, die je hierboven vindt. Je moet daar de belangrijkste technische gegevens Desa FAS-10BB vinden. Op dit manier kan je controleren of het apparaat aan jouw behoeften voldoet. Op de volgende pagina's van de handleiding Desa FAS-10BB leer je over alle kenmerken van het product en krijg je informatie over de werking. De informatie die je over Desa FAS-10BB krijgt, zal je zeker helpen om een besluit over de aankoop te nemen.
In een situatie waarin je al een beziter van Desa FAS-10BB bent, maar toch heb je de instructies niet gelezen, moet je het doen voor de hierboven beschreven redenen. Je zult dan weten of je goed de alle beschikbare functies heb gebruikt, en of je fouten heb gemaakt die het leven van de Desa FAS-10BB kunnen verkorten.
Maar de belangrijkste taak van de handleiding is om de gebruiker bij het oplossen van problemen te helpen met Desa FAS-10BB . Bijna altijd, zal je daar het vinden Troubleshooting met de meest voorkomende storingen en defecten #MANUAl# samen met de instructies over hun opplosinge. Zelfs als je zelf niet kan om het probleem op te lossen, zal de instructie je de weg wijzen naar verdere andere procedure, bijv. door contact met de klantenservice of het dichtstbijzijnde servicecentrum.
