Gebruiksaanwijzing /service van het product 823-0290 van de fabrikant Hearth and Home Technologies
Ga naar pagina of 32
SA VE THESE INSTRUCTIONS www .quadrare.com This manual contains instructions for Installation, Operation & Maintenance. Please read this entire manual before you install and use your new room heater . Failure to follow instructions may result in property damage, bodily injury , or even death.
R Page 2 September 1, 2008 Isle Royale W ood Stove 250-5763C and Welcome to the Quadra-Fire Family ! Hearth & Home T echnologies welcomes you to our tradi - tion of excellence! In choosing a Quadra-Fire appliance, you have our assurance of commitment to quality , durabil - ity , and performance.
Page 3 Isle Royale W ood Stove R September 1, 2008 250-5763C Serial Number Label Location ................................. 2 Pre-Use Checklist ..................................................... 3 Listings & Safety Notices .....................
R Page 4 September 1, 2008 Isle Royale W ood Stove 250-5763C LISTINGS and SAFETY NOTICES W ARNING ! DO NOT A TTEMPT TO OPERA TE THIS WOODSTOVE WITHOUT READING AND UNDERST ANDING THESE OPERA TING I NS T R UC T I O NS T H OR O U GH L Y . FAI L U R E T O O P E RATE T H IS APPLIANCE PROPERL Y MA Y CAUSE A HOUSE FIRE.
Page 5 Isle Royale W ood Stove R September 1, 2008 250-5763C DIMENSIONS FRONT VIEW SIDE VIEW 29" (737mm) 28-3/4" (730mm) 30" (762mm) C L 8-1/4" (210mm) 16-1/2" (419mm) 24-5/8&.
R Page 6 September 1, 2008 Isle Royale W ood Stove 250-5763C B A C D CLEARANCES T O COMBUSTIBLES (UL and ULC) G H Ceiling E E F F MINIMUM CLEARANCES TO COMBUSTIBLE MA TERIALS In Inches & (Millimeters) NOTE: "A" ,"C" and "F" Dimensions are to the inside diameter of the flue collar .
Page 7 Isle Royale W ood Stove R September 1, 2008 250-5763C FLOOR PROTECTION The oor must be non-combustible material, extending beneath heater and to the front, sides and rear as indicated. The oor must be non-combustible or otherwise adequately protected from radiant heat given off by the unit and from sparks and falling embers.
R Page 8 September 1, 2008 Isle Royale W ood Stove 250-5763C Calculating Alternate Floor Protection Material Thermal Conductivity: k value The k value indicates the amount of heat (in BTU’ s) that w.
Page 9 Isle Royale W ood Stove R September 1, 2008 250-5763C REVERSIBLE FLUE COLLAR The ue collar is reversible for either a top or rear venting installation. The unit is shipped with the ue collar in the top vent position. CONVERTING COLLAR FOR REAR VENT INST ALLA TION 1.
R Page 10 September 1, 2008 Isle Royale W ood Stove 250-5763C T o be sure that your stove burns properly , the chimney draft (static pressure) should be approximately -.
Page 1 1 Isle Royale W ood Stove R September 1, 2008 250-5763C Thimble Assembly: 12" (305mm) of brick separation between clay liner and combustibles. Fireclay liner 5/8" (16mm) Minimum or Equivalent. Sill support Header Wood Stud 2" (51mm) Clearance from chimney wall Fireclay liner 5/8" (16mm) Minimum or Equivalent.
R Page 12 September 1, 2008 Isle Royale W ood Stove 250-5763C SOLID P ACK CHIMNEY WITH MET AL SUPPORTS AS A THIMBLE Figure 12A Center of Hole W all Center Line Opening Center Line C L 26-7/16" (570mm) Add the 26-7/16 inches (671mm), center-line measurement to the depth measurement of your oor protector .
Page 13 Isle Royale W ood Stove R September 1, 2008 250-5763C First, make the frame for the thimble, ensuring it is no smaller than 14 inches (356mm) square to maintain a 2 inch (51mm) air space around the chimney section. Attach the wall spacer to the chimney side of the frame.
R Page 14 September 1, 2008 Isle Royale W ood Stove 250-5763C CONNECTION T O A MASONR Y FIREPLACE There are several kits available to connect the stove to a masonry replace. Look for a listed kit. The kit is an adapter which is installed at the location of the replace damper .
Page 15 Isle Royale W ood Stove R September 1, 2008 250-5763C When a metal prefabricated chimney is used, the manufac - turer ’s installation instructions must be followed precisely .
R Page 16 September 1, 2008 Isle Royale W ood Stove 250-5763C Spark Arestor Cap Roof Flashing Storm Collar Joist Shield/Firestop Listed Chimney Connector Floor Protector Outside Air Kit Connector Outside Air Floor V ent 1 . An outsid e air inlet must be prov ided for combust ion and must remain clear of leaves, debris, ice and/or snow .
Page 17 Isle Royale W ood Stove R September 1, 2008 250-5763C OUTSIDE AIR TERMINA TION CAP (contains rodent screen) FLEX FLANGE 1 . Remove all materials from packing box. 2. Mount the ex ange (with pipe tting extending out), over the intake air opening at the rear of stove using the four mounting screws supplied with kit.
R Page 18 September 1, 2008 Isle Royale W ood Stove 250-5763C BURNING PROCESS In recent years there has been an increasing concern about air quality . Much of the blame for poor air quality has been placed on the burning of wood for home heating.
Page 19 Isle Royale W ood Stove R September 1, 2008 250-5763C FINAL ST AGE T he nal stage of burning is the charcoal stage. This occurs when the ammable gases have been mostly burned and only charcoal remains. This is a naturally clean portion of the burn.
R Page 20 September 1, 2008 Isle Royale W ood Stove 250-5763C W ARNING! AL W A YS OPERA TE THIS APPLI- ANCE WITH THE DOOR CLOSED AND LA TCHED EXCEPT DURING ST ART -UP AND RE-FUELING OR WHEN USING THE FIRESCREEN. NOTE: See page 21 for operation considerations with a blower installed.
Page 21 Isle Royale W ood Stove R September 1, 2008 250-5763C W ARNING! DO NOT LEA VE THE FIRE UNA TTENDED WHEN THE DOOR IS UNLA TCHED OR WHEN USING THE FIRESCREEN. UNST ABLE FIREWOOD COULD F ALL OUT OF THE FIREBOX CREA TING A FIRE HAZARD TO YOUR HOME.
R Page 22 September 1, 2008 Isle Royale W ood Stove 250-5763C OPERA TING INSTRUCTIONS (Cont’d) WOOD SELECTION AND STORAGE Burn only dry seasoned wood! This will not only minimize creosote formation, but also provide the most efcient heat output.
Page 23 Isle Royale W ood Stove R September 1, 2008 250-5763C CHIMNEY CLEANING 1. Remove all ash from the rebox and extinguish all hot embers before disposal. Allow the stove to cool com - pletely . 2. Close the door tightly and proceed with sweeping the chimney .
R Page 24 September 1, 2008 Isle Royale W ood Stove 250-5763C N OTE: Remove all labels from glass prior to lighting GLASS CARE 1. Ensure that the re is out and the appliance is cool to the touch. 2. Protect a table or counter top with padding or towels.
Page 25 Isle Royale W ood Stove R September 1, 2008 250-5763C DOOR & GASKET Pe riod ica lly che ck the do or gas ket for pr oper se al. As the gasket compresses or “seats” during use, it may b.
R Page 26 September 1, 2008 Isle Royale W ood Stove 250-5763C Service & Maintenance Log Date of Service Performed By Description of Service.
Page 27 Isle Royale W ood Stove R September 1, 2008 250-5763C 12 8 2 10 7 6 1 1 3 4 5 13 1 9 14 Exploded V iews 18 19 20 16 15 17 * Part number list on following page.
R Page 28 September 1, 2008 Isle Royale W ood Stove 250-5763C Andiron Brackets, Pair 832-3610 Andirons with Brackets 844-8980 Ash Removal System Handle Assembly 472-5060 Ash Box Hinge 434-0310 Ash Lip Must specify color .
Page 29 Isle Royale W ood Stove R September 1, 2008 250-5763C Item # Part Description Alphabetical Order SKU IMPORT ANT : THIS IS DA TED INFORMA TION. The most current information is located on the Quadra-Fire web site at .
R Page 30 September 1, 2008 Isle Royale W ood Stove 250-5763C Hearth & Home T echnologies LIMITED W ARRANTY Hearth & Home T echnologies (“HHT”) and its respective brands extends the follow.
Page 31 Isle Royale W ood Stove R September 1, 2008 250-5763C Noise resulting from minor expansion, contraction, or movement of certain parts is normal and complaints related to this noise are not covered by this warranty .
R September 1, 2008 Page 32 • Do NOT discard this manual. • Important operating and maintenance instructions included. • Read, understand and follow these instruci- tons for safe installation and operation. • Leave this manual with party responsible for use and operation.
Een belangrijk punt na aankoop van elk apparaat Hearth and Home Technologies 823-0290 (of zelfs voordat je het koopt) is om de handleiding te lezen. Dit moeten wij doen vanwege een paar simpele redenen:
Als u nog geen Hearth and Home Technologies 823-0290 heb gekocht dan nu is een goed moment om kennis te maken met de basisgegevens van het product. Eerst kijk dan naar de eerste pagina\'s van de handleiding, die je hierboven vindt. Je moet daar de belangrijkste technische gegevens Hearth and Home Technologies 823-0290 vinden. Op dit manier kan je controleren of het apparaat aan jouw behoeften voldoet. Op de volgende pagina's van de handleiding Hearth and Home Technologies 823-0290 leer je over alle kenmerken van het product en krijg je informatie over de werking. De informatie die je over Hearth and Home Technologies 823-0290 krijgt, zal je zeker helpen om een besluit over de aankoop te nemen.
In een situatie waarin je al een beziter van Hearth and Home Technologies 823-0290 bent, maar toch heb je de instructies niet gelezen, moet je het doen voor de hierboven beschreven redenen. Je zult dan weten of je goed de alle beschikbare functies heb gebruikt, en of je fouten heb gemaakt die het leven van de Hearth and Home Technologies 823-0290 kunnen verkorten.
Maar de belangrijkste taak van de handleiding is om de gebruiker bij het oplossen van problemen te helpen met Hearth and Home Technologies 823-0290 . Bijna altijd, zal je daar het vinden Troubleshooting met de meest voorkomende storingen en defecten #MANUAl# samen met de instructies over hun opplosinge. Zelfs als je zelf niet kan om het probleem op te lossen, zal de instructie je de weg wijzen naar verdere andere procedure, bijv. door contact met de klantenservice of het dichtstbijzijnde servicecentrum.
