Gebruiksaanwijzing /service van het product 1121 van de fabrikant Pride Mobility
Ga naar pagina of 51
Owner’s Manual.
SAFETY GUIDELINES Copyright © 2006 Pride Mobility Products Corp. INFMANU2884/Rev B/May 2006 www .quantumrehab.com Quantum 1 121 The symbols below are used throughout this owner's manual and on the power chair to identify warnings and important information.
Quantum 1121 www .quantumrehab .com 3 I. INTRODUCTION ............................................................................................................................... .4 II. SAFETY .......................................................
4 www .quantumrehab .com Quantum 1121 I. INTRODUCTION SAFETY WELCOME to Quantum Rehab, a division of Pride Mobility Products Corporation (Pride). The power chair you have purchased combines state-of-the-art components with safety , comfort, and styling in mind.
Quantum 1121 www .quantumrehab .com 5 I. INTRODUCTION PRIDE OWNERS CLUB As an owner of a Pride product, you are invited to register your product's warranty and enroll in the Pride Owners Club. Y ou may do so by filling out and returning your enclosed product registration card or by visiting Pride's web site at www .
6 www .quantumrehab .com Quantum 1121 II. SAFETY SAFETY WARNING! Do not operate your new power chair for the first time without completely reading and understanding this owner’s manual. Y our power chair is a state-of-the-art life-enhancement device designed to increase mobility .
Quantum 1121 www .quantumrehab .com 7 II. SAFETY Weight Limitations Y our power chair is rated for a maximum weight capacity . Please refer to the specifications table for this limit. WARNING! Exceeding the weight capacity v oids your warr anty and may r esult in personal injur y and/or damage to your power c hair .
8 www .quantumrehab .com Quantum 1121 II. SAFETY 5 (8.7%) Figure 1. Maximum Safe Angle (Ascending and Descending) WARNING! Even though your power chair is capable of climbing slopes greater than those illustrated in figure 1, do not, under any circumstances, exceed the incline guidelines or any other specifications presented in this manual.
Quantum 1121 www .quantumrehab .com 9 II. SAFETY Freewheel Mode Y our power chair is equipped with a manual freewheel system to allow for manual maneuverability by a trained attendant. For more information about how to place your power chair into and out of freewheel mode, see III.
1 0 www .quantumrehab .com Quantum 1121 II. SAFETY T ransfers T ransferring onto and off of your power chair requires a good sense of balance. Always have an attendant or healthcare pro- fessional present while learning to properly transfer yourself.
Quantum 1121 www .quantumrehab .com 1 1 II. SAFETY Motor V ehicle T ransport Pride recommends that you do not remain seated in your power chair while traveling in a motor vehicle. The power chair should be stowed in the trunk of a car or in the back of a truck or van with the batteries removed and properly secured.
1 2 www .quantumrehab .com Quantum 1121 II. SAFETY Batteries In addition to following the warnings below , be sure to comply with all other battery handling information. For more information about your power chair ’ s batteries, see VI. “Batteries and Char ging.
Quantum 1121 www .quantumrehab .com 1 3 Electromagnetic and Radio Frequency Interference (EMI/RFI) WARNING! Laborator y tests have sho wn that electr omagnetic and r adio frequency wa ves can hav e an adverse af f ect on the perfor mance of electricall y-po wered mobility vehic les.
1 4 www .quantumrehab .com Quantum 1121 III. Y OUR POWER CHAIR THE QU ANTUM 1121 The power chair has two main assemblies: the seat and the power base. See figures 5 and 6.
Quantum 1121 www .quantumrehab .com 1 5 III. Y OUR PO WER CHAIR S S S S S PECIFICA PECIFICA PECIFICA PECIFICA PECIFICA TIONS TIONS TIONS TIONS TIONS Suspension: Active-Trac Drive Wheels: 14 in., pneumatic, center-mounted (solid tires are optional) Caster Wheels: 8 in.
1 6 www .quantumrehab .com Quantum 1121 III. Y OUR POWER CHAIR REAR SEAT TOWERS Figure 6. The Quantum 1121 P ower Base Figure 7. The Quantum 1121 Electronics T ra y (Optional Onboard Charging System S.
Quantum 1121 www .quantumrehab .com 1 7 III. Y OUR POWER CHAIR Electronics T ra y The electronics tray is located on the back of the power base. See figures 6 and 7.
1 8 www .quantumrehab .com Quantum 1121 III. Y OUR PO WER CHAIR T o operate the dual manual freewheel levers: 1. Pull up the manual freewheel lever on each motor for freewheel mode (drive disengaged). See figure 8. 2. Push down the manual freewheel lever on each motor for drive mode (drive engaged).
Quantum 1121 www .quantumrehab .com 1 9 IV . ASSEMBL Y INITIAL ASSEMBL Y Y our power chair may require some assembly either before initial use or after transportation.
2 0 www .quantumrehab .com Quantum 1121 T o install the seat: 1. Set the seat towers to the desired height. T o change the seat height, see V . “Comfort Adjustments.” 2. T ilt the seat back, and slide the rear extrusion onto the rear trapeze bar .
Quantum 1121 www .quantumrehab .com 2 1 V . COMFOR T ADJUSTMENTS Y ou may need the following to make comfort adjustments: ! metric/standard hex key set ! metric/standard socket set and ratchet ! adjustable wrench Seat Height and Seat Angle Adjustment There are four steel towers that connect the seat to the power base.
2 2 www .quantumrehab .com Quantum 1121 SEATBACK ANGLE ADJUSTMENT SCREW ARMREST KNOB JAM NUT V . COMFOR T ADJUSTMENTS Seat Position Adjustment Y ou can move the seat forward or rearward by changing the extrusion mounting position. T o change the position: 1.
Quantum 1121 www .quantumrehab .com 2 3 V . COMFOR T ADJUSTMENTS Figure 16. Controller Installation SETSCREW Figure 17. Foot Platform Height Adjustment Figure 18. Foot Platform Angle Adjustment FOOT PLATFORM BRACKET NUTS AND BOLTS BALL DETENT PIN SETSCREW Controller Position Y ou can position the controller for either left-hand or right-hand use.
2 4 www .quantumrehab .com Quantum 1121 ADJUSTMENT SCREWS V . COMFOR T ADJUSTMENTS Foot Plat form Angle Adjustment Y ou can adjust the angle of the foot platform with a hex key . See figure 18. T o adjust the foot platfor m angle: 1 . Locate the setscrew on the underside of the foot platform.
Quantum 1121 www .quantumrehab .com 2 5 V . COMFOR T ADJUSTMENTS Anti-Tip Wheels The anti-tip wheels are designed to give your power chair increased stability on rough surfaces.
2 6 www .quantumrehab .com Quantum 1121 V . COMFOR T ADJUSTMENTS Power Elevating Seat Option Y our power chair may be equipped with a power elevating seat actuator . See figure 22. The power elevating seat is equipped with a system that reduces the power chair ’ s speed by one half whenever the seat is elevated more than 1-2 inches.
Quantum 1121 www .quantumrehab .com 2 7 V . COMFOR T ADJUSTMENTS Figure 23. T og gle Switch Power Elevating Seat Operation Y ou can control the power seat through either the toggle switch located on the armrest or through your controller . For information on how to raise and lower your power seat through your controller , see VII.
2 8 www .quantumrehab .com Quantum 1121 VI. BA TTERIES AND CHAR GING BA TTERIES AND CHARGING The power chair uses two long-lasting, 12-volt, deep-cycle batteries. These batteries are sealed and maintenance free. Since they are sealed, there is no need to check the electrolyte (fluid) level.
Quantum 1121 www .quantumrehab .com 2 9 VI. BA TTERIES AND CHAR GING WARNING! Prev ent injur y and/or equipment damage! If y our of f-boar d ba tter y charger has not been tested and approved for outdoor use, then do not expose it to adverse or extreme weather conditions.
3 0 www .quantumrehab .com Quantum 1121 Frequently Asked Questions (F AQs) How does the charger work? The battery charger takes the standard electrical outlet voltage of 120 V AC (alternating current) and converts it to 24 VDC (direct current). The power chair batteries use direct current to run your power chair .
Quantum 1121 www .quantumrehab .com 3 1 VI. BA TTERIES AND CHARGING What type of batteries should I use? W e recommend deep-cycle batteries that are sealed and maintenance free. Both AGM and Gel-Cell are deep-cycle batteries that are similar in performance.
3 2 www .quantumrehab .com Quantum 1121 Figure 26. VSI Controller VII. OPERA TION VSI ELECTRONIC CONTROLLER The electronic controller is what you use to operate your power chair .
Quantum 1121 www .quantumrehab .com 3 3 VII. OPERA TION On/Off Key The on/off key turns the VSI on and off. WARNING! Unless faced with an emergency situation, do not use the on/off key to stop the power c hair . T his will cause the po wer c hair to stop abr uptly .
3 4 www .quantumrehab .com Quantum 1121 VII. OPERA TION Actuator Keys and Actuator Light s (For Optional Equipment) Actuator keys and actuator lights are used for optional equipment such as power elevating seats or power elevating leg rests. For specific operation of the actuator keys and actuator lights, contact your Quantum Rehab Specialist.
Quantum 1121 www .quantumrehab .com 3 5 WARNING! Failure to proper ly align the connector s can result in dama ge to the VSI, the charger , and the connectors. Thermal Rollback The VSI controller is equipped with a thermal rollback circuit. This circuit monitors the temperature of the controller , which roughly translates to motor temperature.
3 6 www .quantumrehab .com Quantum 1121 VII. OPERA TION REMOTE PLUS CONTROLLER The Remote Plus is a modular electronic control system. The electronics necessary to operate the power chair are con- tained in several modules located on different parts of your power chair .
Quantum 1121 www .quantumrehab .com 3 7 VII. OPERA TION On/Off Key The on/off key turns the system power on and off. WARNING! Unless faced with an emergency situation, do not use the on/off key to stop the c hair . This will cause the power chair to stop abr uptly .
3 8 www .quantumrehab .com Quantum 1121 VII. OPERA TION ! ! ! ! ! Ripple up and down of lights: The joystick was not in the neutral position when the controller was turned on. If you get “ripple up and down of lights”, turn of f the controller , allow the joystick to return to the neutral position, then turn on the controller .
Quantum 1121 www .quantumrehab .com 3 9 VII. OPERA TION Actuator Lighting Module (Not Shown) The actuator lighting module is also located on the power base. The actuator lighting module provides a control and power interface between the power module, the lights, and/or the power seat actuator .
4 0 www .quantumrehab .com Quantum 1121 THE MICRODRIVE CONTROLLER The electronic controller is what you use to operate your power chair . It takes the battery voltage and sends it to the appropriate system.
Quantum 1121 www .quantumrehab .com 4 1 Profile and Speed Indicator The profile and speed indicator is a 5-segment illumi- nated display that indicates speed setting as well as drive profile.
4 2 www .quantumrehab .com Quantum 1121 Drive Profile Selection Y our Microdrive controller may be programmed for more than one drive profile that allows the system to be custom tailored to your environment. T o select a profile setting: 1. Use the on/of f switch to power on the chair and the controller .
Quantum 1121 www .quantumrehab .com 4 3 FLASHING LIGHTS DIAGNOSIS SOLUTION 10 High Battery V olt age Check batteries. 9 Solenoid Brake Fault Check motor/brake wiring. 8 Possible Controller Fault See Quantum Rehab S pecialist. 7 Possible Joystick Fault See Quantum Rehab S pecialist.
4 4 www .quantumrehab .com Quantum 1121 VIII. CARE AND MAINTENANCE CARE AND MAINTENANCE Y our Quantum 1121 is a sophisticated power chair . Like any motorized vehicle, it requires routine maintenance checks. Y ou can perform some of these checks, but others require assistance from a Quantum Rehab Specialist.
Quantum 1121 www .quantumrehab .com 4 5 VIII. CARE AND MAINTENANCE ! The body shroud has been sprayed with a clear sealant coating. Y ou can apply a light coat of car wax to help it retain its high-gloss appearance. ! Check all electrical connections.
4 6 www .quantumrehab .com Quantum 1121 VIII. CARE AND MAINTENANCE Storage Y our power chair should be stored in a dry place, free from temperature extremes. When storing, disconnect the batteries from the power chair . See VI. “Batteries and Char ging.
Quantum 1121 www .quantumrehab .com 4 7 F ollow these easy steps for a quick and safe repair for both solid and pneumatic tires: 1. T urn of f the power to the controller . 2. Set the power chair up on blocks. 3 . If you are changing a pneumatic tire, completely deflate it before removing the wheel.
4 8 www .quantumrehab .com Quantum 1121 T o replace the batteries: 1. T urn of f the power to the controller . 2. Make sure that the power chair is in drive mode. See III. “Y our Power Chair .” 3. Remove the ball detent pin that secures the foot platform to the frame.
Quantum 1121 www .quantumrehab .com 4 9 IX. WARRANTY LIFETIME LIMITED WARRANTY For the lifetime of your power chair from the date of purchase, Pride will repair or replace at our option to the origina.
5 0 www .quantumrehab .com Quantum 1121 IX. WARRANTY RECONDITIONED UNITS WARRANTY All reconditioned units are covered by a six-month warranty from Pride effective from the date of purchase. WARRANTY EX CL USIONS This warranty does not extend to those items which may require replacement due to normal wear and tear .
Quality Control- Model 14 0 0 Pride keeps a more detailed report on file at the factory . Date Inspected Inspector Thank you for making the Quantum 1121 your choice in power chairs. We have thoroughly inspected your Quantum 1121. The following check marks indicate that it has been tested, driven, and inspected.
Een belangrijk punt na aankoop van elk apparaat Pride Mobility 1121 (of zelfs voordat je het koopt) is om de handleiding te lezen. Dit moeten wij doen vanwege een paar simpele redenen:
Als u nog geen Pride Mobility 1121 heb gekocht dan nu is een goed moment om kennis te maken met de basisgegevens van het product. Eerst kijk dan naar de eerste pagina\'s van de handleiding, die je hierboven vindt. Je moet daar de belangrijkste technische gegevens Pride Mobility 1121 vinden. Op dit manier kan je controleren of het apparaat aan jouw behoeften voldoet. Op de volgende pagina's van de handleiding Pride Mobility 1121 leer je over alle kenmerken van het product en krijg je informatie over de werking. De informatie die je over Pride Mobility 1121 krijgt, zal je zeker helpen om een besluit over de aankoop te nemen.
In een situatie waarin je al een beziter van Pride Mobility 1121 bent, maar toch heb je de instructies niet gelezen, moet je het doen voor de hierboven beschreven redenen. Je zult dan weten of je goed de alle beschikbare functies heb gebruikt, en of je fouten heb gemaakt die het leven van de Pride Mobility 1121 kunnen verkorten.
Maar de belangrijkste taak van de handleiding is om de gebruiker bij het oplossen van problemen te helpen met Pride Mobility 1121 . Bijna altijd, zal je daar het vinden Troubleshooting met de meest voorkomende storingen en defecten #MANUAl# samen met de instructies over hun opplosinge. Zelfs als je zelf niet kan om het probleem op te lossen, zal de instructie je de weg wijzen naar verdere andere procedure, bijv. door contact met de klantenservice of het dichtstbijzijnde servicecentrum.
